Won't start after replacing manfold gaskit. timming is ok replace fuel pump,coil. getting spark to plugs. the starter just want to whining and not turn the motor over. 2.8 tb 5speed 4x4 1987. also getting gas to tb. Running fine befor I change gaskit to fix a oil leak.

Try spraying starting liquid at the throttle body and then start.If it starts and runs smooth then its faulty fuel pump and clogged fuel filter issue.--------

A car that cranks over but doesn't start, in many cases will be due to a bad fuel pump, a broken timing belt, an inoperative cam sensor or crank sensor. Also these problems are related to faulty spark plug. Check the spark at spark plugs when you start the car. Do you notice any spark. Actually you should see. If in case there is no spark then it's a spark plug problem. Also the coil pack gives power to spark plug. So check the voltage at coil pack. It will show 12 volt. If there is no voltage noticed at coil pack then its faulty coil pack that has to be replaced. If all the possible options checked out ok then check the car starter. The starter gets power from battery to start the car. If the starter is faulty then it will not let the car to start. Also check and confirm that there is fuel in the car. If its very low fuel then in some cases this causes the problem. Also check and confirm that fuel pump is functioning properly and the fuel filter is not clogged. One of the easiest ways to check for a fuel pump related problem is to spray a little starting fluid into the air intake while trying to start the car. If the car starts momentarily, then there's a good chance the fuel pump is not working or the car is out of gas. You can also listen for the fuel pump's humming sound when the key is first turned on. Also if a inoperative fuel pump is suspected, a good technician will always check to verify there is power and ground being supplied to the pump, to eliminate the possibility of a bad relay or electrical issue. Fuel pressure can be checked with a pressure gauge and if there is pressure, pulse can be checked at the fuel injectors in several ways including the most common, with the use of noid lights. If the injectors don't have pulse the engine won't start. ---------- This troubleshooting tips will help you to solve the problem. Thanks. Helpmech.

Engine wont start.If car battery voltage is low then engine wont start.The fully charged battery will show 12 volt.But if battery is showing 12 volt.Then check the battery to starter connection.If that is also checked ok then check voltage for starter itself.The starter is also a 12 volt part.But if the starter is faulty then it has to be replaced.If you start the car but if its not starting then its starter fault.But if the car makes cranking noise but its not getting turn over then there are many other possibilities.A car that cranks over but doesn't start, in many cases will be due to a bad fuel pump, a broken timing belt, an inoperative cam sensor or crank sensor. Also these problems are related to faulty spark plug. Check the spark at spark plugs when you start the car. Do you notice any spark. Actually you should see. If in case there is no spark then it's a spark plug problem. Also the coil pack gives power to spark plug. So check the voltage at coil pack. It will show 12 volt. If there is no voltage noticed at coil pack then its faulty coil pack that has to be replaced. If all the possible options checked out ok then check the car starter. The starter gets power from battery to start the car. If the starter is faulty then it will not let the car to start. Also check and confirm that there is fuel in the car. If its very low fuel then in some cases this causes the problem. Also check and confirm that fuel pump is functioning properly and the fuel filter is not clogged. One of the easiest ways to check for a fuel pump related problem is to spray a little starting fluid into the air intake while trying to start the car. If the car starts momentarily, then there's a good chance the fuel pump is not working or the car is out of gas. You can also listen for the fuel pump's humming sound when the key is first turned on. Also if a inoperative fuel pump is suspected, a good technician will always check to verify there is power and ground being supplied to the pump, to eliminate the possibility of a bad relay or electrical issue. Fuel pressure can be checked with a pressure gauge and if there is pressure, pulse can be checked at the fuel injectors in several ways including the most common, with the use of noid lights. If the injectors don't have pulse the engine won't start. ---------- This troubleshooting tips will help you to solve the problem. Thanks. Helpmech.

The starter and starter solenoid has to be checked.There are few more possibilities that also are to be checked to confirm the fault.But as per click click its indicating faulty or loose connected starter or jammed starter solenoid.In both case the starter assembly has to be replaced. The other possibilities as follows:---

A car that cranks over but doesn't start, in many cases will be due to a bad fuel pump, a broken timing belt, an inoperative cam sensor or crank sensor. Also these problems are related to faulty spark plug. Check the spark at spark plugs when you start the car. Do you notice any spark. Actually you should see. If in case there is no spark then it's a spark plug problem. Also the coil pack gives power to spark plug. So check the voltage at coil pack. It will show 12 volt. If there is no voltage noticed at coil pack then its faulty coil pack that has to be replaced. If all the possible options checked out ok then check the car starter. The starter gets power from battery to start the car. If the starter is faulty then it will not let the car to start. Also check and confirm that there is fuel in the car. If its very low fuel then in some cases this causes the problem. Also check and confirm that fuel pump is functioning properly and the fuel filter is not clogged. One of the easiest ways to check for a fuel pump related problem is to spray a little starting fluid into the air intake while trying to start the car. If the car starts momentarily, then there's a good chance the fuel pump is not working or the car is out of gas. You can also listen for the fuel pump's humming sound when the key is first turned on. Also if a inoperative fuel pump is suspected, a good technician will always check to verify there is power and ground being supplied to the pump, to eliminate the possibility of a bad relay or electrical issue. Fuel pressure can be checked with a pressure gauge and if there is pressure, pulse can be checked at the fuel injectors in several ways including the most common, with the use of noid lights. If the injectors don't have pulse the engine won't start. ---------- This troubleshooting tips will help you to solve the problem. Thanks. Helpmech.

There are some possibilities which you will have to check in this case:--

1) First of all check the power and voltage to the battery. With meter it will show exact 12 volt if the battery is charged. If the voltage is less get the battery charged at local auto repair shop. If the battery is internally drained and not getting charged then its time to replace the battery.

2) When you crank the car do you see spark coming at the spark plug? If no then its time to check the spark plugs and coil pack. If the spark plugs are not worn out and looks new then its time to check coil pack. The spark plug gets power to spark from coil pack.

3) The other thing to check in this case is the starter solenoid of the car. If the battery is charged and you start the car then it gives power to the starter to start the car. But if starter is faulty or not connected properly then car will not start.

4) The other thing to check in this case is fuel in the car. If there is fuel in the car then check the blockages in the fuel pump if the fuel pump looks proper then check the fuel filter above the fuel pump.

5) If all the above possibilities mentioned above checked out OK/perfect then it's a electrical issue and the wiring's in the car needs to be checked. The car gets power from the battery to get started. so the wires from battery needs to be checked one by one.

-------------

Thanks. keep updated for any more query.you can rate this solution and show your appreciation.

The battery to starter connection has power.the battery is ok.but there are many other possibilities related to battery and its other connections,the spark plugs,the fuel pump,the fuel itself,the sensors(o2 sensor,maf sensor)the valve(IAC valve,egr valve). Most probably the spark plug,the coil pack and crank shaft sensor.This 3 are not getting power to get the car start.

There are some possibilities which you will have to check in this case:--

1) First of all check the power and voltage to the battery. With meter it will show exact 12 volt if the battery is charged. If the voltage is less get the battery charged at local auto repair shop. If the battery is internally drained and not getting charged then its time to replace the battery.

2) When you crank the car do you see spark coming at the spark plug? If no then its time to check the spark plugs and coil pack. If the spark plugs are not worn out and looks new then its time to check coil pack. The spark plug gets power to spark from coil pack.

3) The other thing to check in this case is the starter solenoid of the car. If the battery is charged and you start the car then it gives power to the starter to start the car. But if starter is faulty or not connected properly then car will not start.

4) The other thing to check in this case is fuel in the car. If there is fuel in the car then check the blockages in the fuel pump if the fuel pump looks proper then check the fuel filter above the fuel pump.

5) If all the above possibilities mentioned above checked out OK/perfect then it's a electrical issue and the wiring's in the car needs to be checked. The car gets power from the battery to get started. so the wires from battery needs to be checked one by one.

Thanks. keep updated for any more query.you can rate this solution and show your appreciation.

There are some possibilities which you will have to check in this case:--
1) First of all check the power and voltage to the battery. With meter it will show exact 12 volt if the battery is charged. If the voltage is less get the battery charged at local auto repair shop. If the battery is internally drained and not getting charged then its time to replace the battery.
2) When you crank the car do you see spark coming at the spark plug? If no then its time to check the spark plugs and coil pack. If the spark plugs are not worn out and looks new then its time to check coil pack. The spark plug gets power to spark from coil pack.
3) The other thing to check in this case is the starter solenoid of the car. If the battery is charged and you start the car then it gives power to the starter to start the car. But if starter is faulty or not connected properly then car will not start.
4) The other thing to check in this case is fuel in the car. If there is fuel in the car then check the blockages in the fuel pump if the fuel pump looks proper then check the fuel filter above the fuel pump.
5) If all the above possibilities mentioned above checked out OK/perfect then it’s a electrical issue and the wiring's in the car needs to be checked. The car gets power from the battery to get started. so the wires from battery needs to be checked one by one.
Thanks. Keep updated for any more query. You can rate this solution and show your appreciation.

There are some possibilities which you will have to check in this case:--
1) First of all check the power and voltage to the battery. With meter it will show exact 12 volt if the battery is charged. If the voltage is less get the battery charged at local auto repair shop. If the battery is internally drained and not getting charged then its time to replace the battery.
2) When you crank the car do you see spark coming at the spark plug? If no then its time to check the spark plugs and coil pack. If the spark plugs are not worn out and looks new then its time to check coil pack. The spark plug gets power to spark from coil pack.
3) The other thing to check in this case is the starter solenoid of the car. If the battery is charged and you start the car then it gives power to the starter to start the car. But if starter is faulty or not connected properly then car will not start.
4) The other thing to check in this case is fuel in the car. If there is fuel in the car then check the blockages in the fuel pump if the fuel pump looks proper then check the fuel filter above the fuel pump.
5) If all the above possibilities mentioned above checked out OK/perfect then it’s a electrical issue and the wiring's in the car needs to be checked. The car gets power from the battery to get started. so the wires from battery needs to be checked one by one.
Thanks. Keep updated for any more query. You can rate this solution and show your appreciation.

a) Do you have crank no start? (see entire write up)
b)No crank no start ,No dash lights?, ( battery, battery cables, ignition switch,,starter relay)

If you have symptom A then the affected items are , ignition switch, battery, battery cables, starter, starter relay ,coil, coil pack, ignition module ,Distributor cap ,rotor, (if applicable) spark plugs and wires.
The best thing to do is to first make sure your timing belt didn't break. As long as the engine cranks you can do this. Give the battery a 3 min charge . Then have a helper crank the vehicle while you observe the rotation of all the pulley's and belts. They must rotate together. If the vehicle has a distributor remove the cap, ground the coil wire and remove fuel pump relay ( to disconnect the pump for testing)and watch the rotor as the engine is cranked. it should spin. If this is a-ok your worse nightmare is over.
Now we have eliminated the timing belt as being a cause. We now have to charged the battery again for three min and load test it( this is best done by a repair shop a load tester is expensive .If the battery if more than 5yrs old you may want to replace it.
If battery does not pass load test replace it.
Whatever you decide the rest of the items can NOT be checked out without a fully charged battery.
Check ignition switch and starter relay for B+ going to them and leaving them. Check starter circuit. Make sure B+ is making it to starter ( use a digital voltmeter). If B+ (12 volts) is making it to the starter and it doesn't crank then the starter is defective. Verify this by removing the starter and have it bench tested.
If starter cranks now your into coil testing . First thing reconnect the distributor.
Pull a spark plug, hook it up to a spark tester and ground it, now crank the engine if you get spark coil is ok and in all likelihood so is module.
If you don't get spark test for spark at the coil wire.
If you get spark here and don't get it at the spark plug wire problem is at distributor cap , rotor or spark plug wire. If plugs look bad use a fresh plug to do testing and naturally replace them.
If all of the above are a-ok.
Next is fuel checks. Reinstall fuel pump relay
Easiest fuel check is to put key into ignition cylinder and turn to on position. Lister for pump to buzz or hum. if it doesn't then check fuel pump relay for B+ going to it and leaving it and going to the pump. If B+ making it to pump and it doesn't turn on the pump is your problem. If B+ not making it to pump either the relay or the ignition switch is defective.
Naturally if the pump is defective have a repair shop do the repair . Its dangerous and a real pain.
Good Luck
Now the cutting out after running fora whilrcoild have caused by the coil, ignition module, fuel pump.
We kinda have to get the car to start first to be conclusiveas to why it cuts out.

I'm listing all the basic items that could possibly hang you up. By your write up I would say its the *fuel pump but it doesn't hurt to check the rest.
Charge the battery for three min and load test it( this is best done by a repair shop a load tester is expensive .If the battery if more than 5yrs old you may want to replace it.
If battery does not pass load test replace it.
Whatever you decide the rest of the items can NOT be checked out without a fully charged battery.
Check ignition switch and starter relay for B+ going to them and leaving them. Check starter circuit. Make sure the CORRECT AMOUNT OF B+ is making it to starter ( use a digital voltmeter). If B+ (12 volts) is making it to the starter and it doesn't crank then the starter is defective. Do a starter current draw test to verify this or remove the starter and have it bench tested.
If starter cranks now your into, coil testing .
Pull a spark plug hook it up to a spark tester and ground it, now crank the engine if you get spark coil is ok and in all likelihood so is module.
If you don't get spark test for spark at the coil wire.or coil pack which ever is applicable.
If you get spark here and don't get it at the spark plug wire problem is at distributor cap , rotor or spark plug wire.or ignition module. If plugs look bad use a fresh plug to do testing and naturally replace them.
If all of the above are a-ok.
Next is fuel checks.
*Easiest fuel check is to put key into ignition cylinder and turn to on position. Lister for pump to buzz or hum. if it doesn't then check fuel pump relay for B+ going to it and leaving it and going to the pump. If B+ making it to pump and it doesn't turn on the pump is your problem. If B+ not making it to pump either the relay or the ignition switch is defective.IN YOUR CASE IT SOUND LIKE YOU HAVE RESIDUAL PRESSURE BUT NO VOLUME TO FOLLOW THROUGH. ( PUMP DYING)
Naturally if the pump is defective have a repair shop do the repair . Its dangerous and a real pain.
Good Luck

I gave you more than you should need

a) Do you have crank no start? (see entire write up)
b)No crank no start?, ( battery, battery cables, ignition switch,,starter relay)
c)No dash lights, no crank? (battery, battery cables ignition switch)
If you have symptom A then the affected items are , ignition switch, battery, battery cables, starter, starter relay ,coil, coil pack, ignition module ,Distributor cap ,rotor, (if applicable) spark plugs and wires.
The best thing to do is to first make sure your timing belt didn't break. As long as the engine cranks you can do this. Give the battery a 3 min charge . Then have a helper crank the vehicle while you observe the rotation of all the pulley's and belts. They must rotate together. If the vehicle has a distributor remove the cap ground the coil wire and watch the rotor as the engine is cranked. it should spin. If this is a-ok your worse nightmare is over.
Now we have eliminated the timing belt as being a cause.

b) We now have to charged the battery again for three min and load test it( this is best done by a repair shop a load tester is expensive ).If the battery if more than 5yrs old you may want to replace it.
If battery does not pass load test replace it.
Whatever you decide the rest of the items can NOT be checked out without a fully charged battery.
Check ignition switch and starter relay for B+ going to them and leaving them. Check starter circuit. Make sure B+ is making it to starter ( use a digital voltmeter). If B+ (12 volts) is making it to the starter and it doesn't crank then the starter is defective. Remove the starter and have it bench tested to verify.
a) If starter cranks now your into coil testing .
Pull a spark plug hook it up to a spark tester and ground it, now crank the engine if you get spark coil is ok and in all likelihood so is module.
If you don't get spark test for spark at the coil wire.
If you get spark here and don't get it at the spark plug wire problem is at distributor cap , rotor or spark plug wire. If plugs look bad use a fresh plug to do testing and naturally replace them.
If all of the above are a-ok.
Next is fuel checks.
Easiest fuel check is to put key into ignition cylinder and turn to on position. Lister for pump to buzz or hum. if it doesn't then check fuel pump relay for B+ going to it and leaving it and going to the pump. If B+ making it to pump and it doesn't turn on the pump is your problem. If B+ not making it to pump either the relay or the ignition switch is defective.
Naturally if the pump is defective have a repair shop do the repair . Its dangerous and a real pain.
Good Luck