Question about 2002 Suzuki VL 1500 Intruder LC

1 Answer

I have a 2003 Suzuki 1500 intruder, we went on a ride and I had some leaking on the right side, it was blowing on the brake cables. I don't know where it came from. Help Please.

Posted by Anonymous on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Night Owl:

    An expert who has answered 10 or more questions between 12 midnight and 6am on the same day.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 162 Answers

Check fork tube for seal leakage

Posted on Jul 12, 2017

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 2336 Answers

SOURCE: fuse box

The main fuse is under the panel on the right side behind the forks and the rest of the fuses are in the crank case under the cover...where you fill the oil.

Posted on Nov 10, 2008

  • 2 Answers

SOURCE: Clutch bleed on a Suzuki 1400 Intruder 2000

One the left-hand side of the bike (facing forward), there is cover plate just ahead of the drive shaft. Remove that cover (mine has 8mm bolts). The bleeder valve is under this cover. Go to an auto parts store and get a "one man bleeder kit" or if you have some plastic tubing that will fit over the valve, you can use that and a clean jar. Follow the instructions on the bleeder kit, or if you're using the jar and tubing, fill the jar about a quarter of the way with break fluid (use DOT4, but never DOT5!). Take the cover off the master cylinder up at the handlebars, place the tube over the end of the bleed valve (after loosening it a turn or two. Place the other end of the tube down in the break fluid in the jar. Work the clutch lever until you stop getting bubbles in the jar. Be sure to keep the fluid level up in the reservoir. Tighten the bleeder valve, remove the tubing, top off the fluid and replace the covers.

Be careful not to get brake fluid on anything. It will eat paint and mess up other things.

Posted on Feb 13, 2009

  • 4 Answers

SOURCE: suzuki 1400 intruder wont start.. just clicking noise.

It's most likely the connection to the battery. The screws dont tighten in well and you get the famous clicking....I replaced the stock philips screws with a hex bolt and after two years of trying to solve the problen have been starting everytime for the past year no problems. Another gie away is the intermitant starting problem gets worse when wet.

Posted on Sep 16, 2009

  • 68 Answers

SOURCE: Suzuki intruder 1500 charging system

You need to buy a volt meter and set it on 10, or 20 v-. Start the bike and see what it says. A good charging system will show 13-14+ volts. If the meter says 11-12 volts or does not change, you have a bad stator, or rect/reg. Take to a shop to have it further tested. Chaz Moto DC

Posted on Jan 22, 2010

  • 2 Answers

SOURCE: 2002 VL 1500 Intruder LC: What is the proper tire pressure for Suzuki vl 150...

Tire pressure is 29 lbs for the front and 36 lbs for the rear

Posted on Jun 29, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Suzuki 1500 intruder rear cyl oil leak on spark plug side of head. ??


Hi, Mike due to the magnitude of yesterday's solar flare my night and x-ray vision optical devices have become inoperable so you will have to be my eyes, to find the source of your oil leak, start at the point where you see oil and trace its path going up and forward, if there is too much oil present then buy a spray can of engine degreaser apply it to the affected area then rinse off with a pressure wand or garden hose, use compressed air to blow off excess water or just let it drip dry, take your bike for a 5 mile ride and check for the leaks. For more information about your issue please click on the blue links below. Good luck and have a wonderful day.
My 1999 vulcan 1500 has an oil leak
Oil leaking into spark plug holes
Suzuki VL1500 Service Manual
OEM parts for Suzuki
Suzuki Intruder VL1500B Owner Manual

Feb 17, 2017 | Suzuki VL 1500 Intruder LC Motorcycles

1 Answer

1997 1400 Intruder. Why doesn't it crank or start?


Hi, Jesse the following applies to carbureted also fuel injected models and the usual suspects are:
1. Severely discharged or a damaged battery, should have 12.5 volts or better and be able to pass a load test if necessary.
2. Failed alternator/generator and or voltage regulator.
3. Loose or corroded battery terminals and or cables especially the "NEGATIVE" cable, look for loose, corroded, or broken connectors inside the cable harness at "BOTH" ends.
4. Failed main circuit breaker or ignition switch, check for loose connections and continuity.
5. Failed system and or ignition relay, check for continuity.
6. Failed ignition coil, ignition/electronic module.
7. Failed CKP, CPS, CMP, MAP, TPS, or BAS sensor, corroded, loose or broken wire connector pins/sockets.
8. Throttle cables and or idle speed improperly adjusted hot idle speed should be 950 RPM to 1000 RPM.
9. Air/fuel mixture ***** improperly adjusted.
10. Water or dirt in the fuel system, carburetor or filter.
11. Restricted, blocked or kinked fuel line.
12. Fuel tank empty.
13. Gas cap is not venting properly or fuel tank venting system blocked.
14. A failed fuel pump, pressure regulator and or fuel injectors.
15. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
16. Needle and seat stuck closed in the float bowl.
For more information about your issue and valuable "FREE" downloads that you need please click on the links below. Good luck and have a nice day.
motorcycle com
Suzuki Intruder 1500 Not Turning Over This might be why
2002 Suzuki Intruder 1500 won start
for the 1500 manual click on the tiny "download" word bottom left of the page it's free
VL 1500 INTRUDER 1998 00
https://www.tradebit.com/filedetail.php/9360741-1987-2003-suzuki-vs1400-intruder-service-manual-plus $10

Apr 02, 2016 | Suzuki Motorcycles

1 Answer

How do you rebuild the rear master cylinder on a 2003 Suzuki 1500 intruder


1. Remove it.
2. Disassemble it. You will need snap ring pliers.
3. Reassemble it with new rubber seals.
4. Reinstall it and bleed the brake system.
(Check price on replacement, as it may be comparable to the price of just the parts.)

Sep 10, 2013 | 2003 Suzuki VL 1500 Intruder LC

1 Answer

Problem with 800cc suzuki intruder 2002 2002 suzuki intruder 800cc amonth ago i changed all fuilds and brakes also plugs and filter brike ran really good yesterday a couple buddies wanted to go riding


when i shut off my 2002 suzuki motorcyle it run perfect then went to start i and have no power battery good have no light on dash no head light brrake light everything is dead what could be wrong can you help with a idea thank you dave

Mar 26, 2012 | Suzuki Motorcycles

1 Answer

How do I know if I have enough oil in my 1500 Suzuki intruder


there is a little round glass window on lower right side of engein. you should see the oil.

Oct 01, 2011 | 2002 Suzuki VL 1500 Intruder LC

1 Answer

I need to know how to tell if my rear brakes need to be replaced on my 2001 suzuki 800 intruder


if you can see the pads check if they look thicker then a dime, if they get down to that thin then replace them
also look for pitting and wear on the rotor
when riding lightly engage the brakes , if it feels like it is pulsing then the rotor may be warped

Aug 02, 2011 | 2001 Suzuki VL 1500 Intruder LC

1 Answer

Need to know oil capacity for 2001 suzuki 1500 lc


4.4 quarts if you are changing your oil filter when you change your oil. I own a 2003 Suzuki Intruder 1500 VL.

Jun 07, 2010 | 2001 Suzuki VL 1500 Intruder LC

Not finding what you are looking for?
2002 Suzuki VL 1500 Intruder LC Logo

Related Topics:

37 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

75817 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

Ed Nelson
Ed Nelson

Level 2 Expert

149 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...