Question about Motorcycles

1 Answer

Gsxr 600 was over charging blow 3 fuses I replaced it now won't start

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Renaissance:

    An user who is expert in 3 categories / brands.

  • Motorcycles Master
  • 1,190 Answers

Rectifer and alternator need checking !

Posted on Apr 19, 2014

4 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

SOURCE: GSXR 600 K1 Won't start tries to fire up and the exhaust pops but that's all

Based off of the limited information, the solutions are going to be generalized.

Visually check your battery for any acid build up. If you spot any, obviously some acid remove would be called for. Acid can sap a battery's output to a starter.

Visually inspect fuel components. Fuel injectors on bikes tend to get clogged when they sit for a while. Especially on older models. Refer to a repair guide for your specific model for guidance on the procedure to inspect fuel injectors.

Those two common starting problems for bikes. Without more information it is hard to offer a specific solution.

Posted on May 29, 2012

searcher1974
  • 229 Answers

SOURCE: i have a gsxr-600 the postive of the batt. hit the frame hasn't ran right since and shuts off after about 3 miles and then you have to wait before it will start again

You have shorted something out. Possibly fried the ECM. Check all fuses,and wiring. If they are all good,then the ECM is probably fried...and time for another.

Posted on Sep 25, 2012

  • 1 Answer

SOURCE: I have a suzuki gsxr 600 and it will not start, but it clicks when I hit the starter button.

I had the same problem. Put the bike in gear and rock it forward and back to where you feel it catch. Try starting it again. I found amy starte had a couple worn spots. I was able to use this metod for months. I finally changed my starter a year later.

Posted on Feb 07, 2013

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have a 2007 gsxr and i have went through and checked everything it wont turn over i took the starter off bench tested it it works i took stator cover off and turned engine by hand


Hi, Timothy and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, needs to be 12.5 volts or better and be able to pass a load test if necessary.
4. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
5. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
6. FOB battery low or dead.
7. Faulty ignition switch.
8. Faulty starter button.
9. Faulty kickstand or clutch pull in switch/sensor.
10. Security alarm needs a reset.
11. Starter control circuit, relay, or solenoid faulty.
12. Main fuse or circuit breaker may be blown or faulty.
13. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
14. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below and for more specific information or questions at no charge please feel free to contact me at xlch@mail.com. Good luck and have a wonderful day.
Bike won turn over
Help Troubleshooting 2003 GSXR 600 Won turn over
Suzuki GSXR electrical issues starter relay won start PROBLEM SOLVED
Suzuki GSX R750 Service Manual
OEM parts for Suzuki
http://mybikemanuals.com/suzuki/suzuki-gsx-owners-manuals

Feb 28, 2017 | 2007 Suzuki GSX-R 600

1 Answer

My 2000 Suzuki 600 gsxr clutch issues


Replace all the clutch plates and the springs, or get a racing clutch. And stop slipping the clutch to do wheelies :>)

Plates
https://store.schnitzracing.com/suzuki/gsxr600/clutch

Springs
http://www.motorcycle-superstore.com/1508761/d/2000-suzuki-gsx-r600-street-bike-clutch-springs

  • 2000 Suzuki GSX-R600 Clutch - Motorcycle Superstore www.motorcycle-superstore.com/873178/d/2000-suzuki-gsx-r600-clutch Clutch 2000 Suzuki GSX-R600 ... 2000 Suzuki GSX-R600 Clutch. ... it was easy to install and it was the first clutch system i ever put on my 2007 GSXR 1000 ...
  • 2000 Suzuki Katana 600 Clutch Springs - Motorcycle Superstore www.motorcycle-superstore.com/.../d/2000-suzuki...600-clutch-springs Clutch 2000 Suzuki Katana 600 ... KG Clutch Factory High Performance Spring SetFor ... and it was the first clutch system i ever put on my 2007 GSXR 1000 ...
  • GSXR 750 Suzuki Sport Motorcycle Clutch Parts www.orientexpress.com/c-84-clutch_suzuki-sport-gsxr750.aspx ... Clutch Springs Suzuki - GSXR 600 2004-2005/GSXR 750 2000-2005/High Performance/Heavy Duty. Price: $35.95 (USD) GB Racing - Clutch Cover Suzuki ...
  • GSXR 600 Suzuki Sport Motorcycle Clutch Parts www.orientexpress.com/c-84-clutch_suzuki-sport-gsxr600.aspx ... Clutch Springs Suzuki - GSXR 600 ... Orient Express - Clutch Springs Suzuki - GSXR 600 2004-2005/GSXR 750 2000 ... GB Racing - Clutch Cover Suzuki - GSXR 600 ...
  • 2000 Suzuki GSX-R600 Street Bike Clutch Springs ... www.motorcycle-superstore.com/1508761/d/2000-suzuki-gsx-r600... Clutch 2000 Suzuki GSX-R600 Street Bike Parts ... Race Suits; Riding Suits; Riding Underwear; Socks; ... Clutch; Cooling System; Drive; Electrical; Engine;
  • Suzuki GSXR600 Clutch Plates and Parts - Schnitz Racing https://store.schnitzracing.com/suzuki/gsxr600/clutch Shop Schnitz Racing for Suzuki GSXR600 clutch plates, ... Valves & Springs; Exhaust. ... Suzuki GSXR600 Clutch Components and Parts from Schnitz Racing.
  • Suzuki GSXR 600 1997-2000 EBC SRK Complete Clutch Kit www.nicecycle.com/Suzuki-Clutch-Kit-p/ebc-clutchkit36.htm Suzuki GSXR 600 1997-2000 EBC SRK Complete ... heavy duty clutch springs of either ... Suzuki GSXR 600 2006-2007 EBC SRK Complete Clutch Kit Suzuki GSXR 600 ...
  • Sigma Clutches for Suzuki - Bikehps.com www.bikehps.com/acatalog/Sigma_Clutches_for_Suzuki.html Sigma Clutches for Suzuki. Sigma Suzuki GSXR600 & GSXR750 K6-K8 2006-2008 Performance Slipper Clutch . Ref: ... - Requires GSX-R1000 clutch springs (not ...

    Suzuki GSXR600 Clutch Plates and Parts Schnitz Racing
  • Jun 12, 2016 | 2000 Suzuki GSX-R 600

    1 Answer

    Suzuki 600 far not start i chance the switch


    Hi, Anonymous and the usual suspects are:
    1. Ignition Switch not in the "ON" position.
    2. Engine Run Switch in the "OFF" position.
    3. Discharged battery, needs to be 12.5 volts or better and be able to pass a load test if necessary, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
    4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
    5. Faulty starter button/switch.
    6. Faulty kickstand or clutch pull in switch/sensor.
    7. Security alarm needs a reset.
    8. Starter control circuit, relay, or solenoid faulty.
    9. Main fuse or circuit breaker may be blown or faulty.
    10. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
    For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have nice a day.
    07 GSXR 600 not starting
    07 gsxr 600 won start
    Steps to Take When Your Motorcycle Won Start Dennis Kirk Powersports Blog
    http://www.suzukigsxr.cz/docs/Suzuki_GSX-R_600_K4+K5.pdf

    Jun 07, 2016 | Suzuki Motorcycles

    1 Answer

    Left bike on at work..battery died, bought new battery "ready start" still no power


    Hi, Ramessu and the usual suspects are:
    1. Ignition Switch not in the "ON" position.
    2. Engine Run Switch in the "OFF" position.
    3. Discharged battery, needs to be 12.5 volts or better and be able to pass a load test if necessary, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
    4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
    5. Faulty starter button/switch.
    6. Faulty jiffy stand or clutch pull in switch/sensor.
    7. Security alarm needs a reset.
    8. Starter control circuit, relay, or solenoid faulty.
    9. Main fuse or circuit breaker may be blown or faulty.
    10. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
    For more information about your issue and valuable "FREE" downloads that you will need please click on the links below Good luck and have nice a day.
    Bike won start
    Engine won start
    2006 GSXR 600 Has Good Charge but Won Start
    Kawasaki Z1000 Service Manual

    Apr 13, 2016 | 2006 kawasaki Z 1000

    1 Answer

    06 gsxr 600 stalled at a stop light and wouldn't restart, already replaced the battery and stator?


    It sounds like its possibly a bad regulator/rectifier. I have posted a link to a video on how to test your regulator. How to test 2 plug Regulator Rectifier for K6 K7 GSXR 750 600 1000

    Jul 12, 2014 | 2007 Suzuki GSX-R 750

    1 Answer

    08 gsxr turned off while idling and wouldn't turn back over


    When the engine is idling, the alternator is not charging. Starting the bike will drain a weak battery. A fast idle (1000 rpm or so) will quickly recharge the battery. If the battery is dead and the alternator is not charging the bike will not run. Check the connections at the battery. Remove and clean them. Check the main fuse and all other fuses. (The temp indication may be a false reading due to other problems.)

    Apr 13, 2014 | 2008 Suzuki GSX-R 600

    1 Answer

    97 gsxr 600. My fuel pump ground wire is getting hot and melting? Is it a short to power or bad connections? Also when trying to start my starter relay clicks like fifty times and I kno i have a good...


    It is most likely a short - it could be a short in the fuel pump itself strange that it is not causing a fuse to blow? The current draw may be below the limit of the fuse. A click on the starter is usually is a faulty solenoid but could be something as basic as dirty battery terminals - try cleaning them first.

    Feb 01, 2013 | Cars & Trucks

    1 Answer

    I have a gsxr-600 the postive of the batt. hit the frame hasn't ran right since and shuts off after about 3 miles and then you have to wait before it will start again


    You have shorted something out. Possibly fried the ECM. Check all fuses,and wiring. If they are all good,then the ECM is probably fried...and time for another.

    Sep 23, 2012 | 1997 Suzuki GSX-R 600

    2 Answers

    2009 gsxr 600 does not start. Clutch engaged fuel pump comes on but no cranking from starter button. Power to battery 11.75 no fuses blown don't know where to go next. Couplers to starter connected


    Well its not starting because you don't have enough voltage. The most likely reason your battery is low is because your not charging when riding due to a bad rectifier/regulator, they go out a lot on GSX-R's. Had to replace mine 3 times already on a 2009 gixxer 600, they put them in a bad place and they get so hot they go bad.

    Apr 30, 2012 | 2008 Suzuki GSX-R 600

    1 Answer

    I have an 04 gsxr 600. She has no power except in the pe selection on the ignition switch and all I get is my brake light, turn signals and hazards. Battery shoots good, I have checked all possible fuses...


    Hi, Jllay0603 nice novella and the usual suspects are:
    1. Ignition Switch not in the "ON" position.
    2. Engine Run Switch in the "OFF" position.
    3. Discharged battery, needs to be 12.5 volts or better and be able to pass a "LOAD" test if necessary.
    4. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
    5. Tip over sensor needs a reset.
    6. Faulty ignition switch.
    7. Faulty starter button.
    8. Faulty kickstand or clutch pull in switch/sensor.
    9. Starter control circuit, relay, or solenoid faulty.
    10. Main fuse or circuit breaker may be blown or faulty.
    11. Check for engine trouble codes.
    For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
    2004 GSXR 600 won start
    What to do When Your Motorcycle Won Start
    Suzuki 2004 GSX R600 Service Manual
    OEM parts for Suzuki
    Suzuki GSX R600 2003 Owner Manual

    Mar 21, 2017 | 2004 Suzuki GSX-R 600

    Not finding what you are looking for?
    Motorcycles Logo

    Related Topics:

    21 people viewed this question

    Ask a Question

    Usually answered in minutes!

    Top Motorcycles Experts

    Arnie Burke
    Arnie Burke

    Level 3 Expert

    4514 Answers

    yadayada
    yadayada

    Level 3 Expert

    75117 Answers

    kakima

    Level 3 Expert

    102366 Answers

    Are you a Motorcycle Expert? Answer questions, earn points and help others

    Answer questions

    Manuals & User Guides

    Loading...