Question about 2008 KTM 530 EXC-R

1 Answer

Ktm exc 530

Engine n exaust gets red hot very quik and runs lumpy

Posted by Anonymous on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Hot-Shot:

    An expert who has answered 20 questions.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 20 Answers

Lean carb or air leak.

Posted on Sep 26, 2015

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 1 Answer

SOURCE: 2008 KTM 530 EXC is a bugger to start.

I have both a 2007 525 EXC and 2008 530 EXC. 525 is always very easy to start w/ choke on while cold. Each have the JD carb kit. I found the 530 hard to start but have a cold-start routine where I kick it through to get it lubed up a bit and then e-start it w/ only partial or no choke (I think it is still a bit rich there.). Now starts much easier and predictably.
vince

Posted on May 27, 2009

  • 5 Answers

SOURCE: 2008 KTM 530 EXC WON'T FIRE WITH STARTER

change engine valve

Posted on Jun 15, 2009

voodoomox
  • 1689 Answers

SOURCE: 2008 KTM 530 EXCR - Engine oil is being pumped to transmission

a big YES

Posted on Jan 11, 2010

Testimonial: "Thanks for the information. I just wanted to be sure that if I paid for the repair it would be better than stock."

  • 108 Answers

SOURCE: ktm output shaft oil seal

if you are lucky there is a clip behind the front sprocket remove both then pop the seal out drain gear box oil first though. if not which i think is most probable the engine will need splitting if you are good with spanners it is quite easy being a 2 stroke .in brief remove engine remove bore and carb in one lump remove sprocket gear lever split g-box .seal up push old seal out, from outside in, fit new then reverse prosses. a good manual will help.

Posted on Feb 13, 2010

joemxavier
  • 342 Answers

SOURCE: how to adjust ktm 530 exc-r hydrolic clutch

first you have to remove the case of clutch then you have to remove the all the bolts then you add a new one >>

Posted on Jun 12, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Why dose oil shoot out of exaust and smoke on my 1999 KTM exc ? Mostly the lower end ? could it be the crank seal ?


DEALING WITH SAME PROBLEM.. ITS LEADING TO CRANK SEAL, BUT TRING TO GET POWER VALVES RIGHT DONT KNOW EXACTLY HOW THEY ARE SUPPSOSED TO BE POSITIONED..??

May 29, 2014 | MSR 1994-1999 Ktm Exc 300 Dirt Bike Upper...

1 Answer

KTM 530 2009 starter spins but motor will not turn over


Hi, Anonymous the starter clutch is a separate mechanical gear driven component that is activated by the starter motor, it engages the clutch pack gear or the flywheel gear to turn over the engine. It has an internal mechanism that allows the gear to turn in one "ONE DIRECTION" only and once the engine starts allows the gear to free spin with engine rotation. If the starter gear free spins in "BOTH DIRECTIONS" then the drive gear has failed, it might be serviceable on some models but usually needs to be replaced.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Need Help Electric Start wont start but kickstart does
KTM starter problem slow crank solution and bendix fix
KTM 450 EXC EU Repair Manual
http://www.partsfish.com/page/oem-parts-for-ktm
KTM 450 EXC EU Owner Manual

Oct 12, 2017 | 2009 KTM 530 EXC

1 Answer

Why am i finding a little oil coming out of a small hole in the cylinder under the spark plug, is it to much engine oil ? ktm 530 excr 2009.


No its an exit hole for water, oil or crud from around the plug holeplug threads get dirty when used & build up it has to go somewhere
Ride Safe
Bike-Doc

Jan 07, 2012 | 2009 KTM 530 EXC

1 Answer

My KTM 2008 530 EXC-R used up constantly engine oil. I checked therefore frequently and took care of it, but after a while the rattle noise of the engine started. So I went to my mechanic to open and check...


Hi, Splishys the reliability of a rebuilt engine is determined by the expertise of the technician, the quality of the parts and the length of the warranty personally I give a brand new factory warranty on all engines I rebuild designed for street use only, for more information about your question and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
http://www.karlstrommotor.se/upload/PDF/KTM08/repmanual450_540exc08.pdf
http://www.partsfish.com/page/oem-parts-for-ktm
KTM 450 EXC Owner Manual
KTM 530 EXC 2008
https://en.wikipedia.org/wiki/KTM_500_EXC

May 08, 2017 | 2008 KTM 530 EXC-R

1 Answer

How to adjust ktm 530 exc-r hydrolic clutch


first you have to remove the case of clutch then you have to remove the all the bolts then you add a new one >>

Jun 12, 2010 | 2008 KTM 530 EXC-R

1 Answer

'09 KTM 530 EXC-R HEADSHAKE


I would recommend getting the front tire balanced. Get the front wheel off of the ground and spin it to see how "out of round" it is.I know the tires on these are DOT approved, but they are not a comfortable ride at highway speeds. Head shake is usually caused when the front end gets light. (My Husaberg does it bad at 90mph) You can play a little with the suspension, or even move the forks up a little in the triple clamps, or the enevitable, get a stabilizer.

Sep 17, 2009 | 2008 Aprilia SXV 5.5

1 Answer

What is the part number fo the spark plug on a 2008 KTM 530 EXC


LKAR8A-9 plug at Bike bandit.com part # 7279671-001

Jul 17, 2009 | 2008 KTM 530 EXC-R

2 Answers

Wen running hot the overflow of the radiator runs bak onto the radiator and exaust cause a big boil up and smoke everywhere. why is it getting so hot?


the puke line for the radiator runs to the frame between the radiators. it's a bad location for it and very messy in the event of coolant loss.

yes they tend to run hot...
ktm has a great add on electric fan for your bike and it well help greatly. save money by installing it yourself as its easy to install.

also use Engine Ice or Water Wetter for better cooling.

I prefer Evans NPG, cost more but worth it!

Jun 25, 2009 | 2008 KTM 450 EXC-R

Not finding what you are looking for?
2008 KTM 530 EXC-R Logo

Related Topics:

143 people viewed this question

Ask a Question

Usually answered in minutes!

Top KTM Experts

yadayada
yadayada

Level 3 Expert

76630 Answers

bazzz7071
bazzz7071

Level 2 Expert

342 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4535 Answers

Are you a KTM Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...