Question about Triumph Motorcycles

Open Question

Oil leak gearbox filler cap - Triumph Motorcycles

Posted by Anonymous on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get to try the service completely Free afterwhich it costs $6 per call and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
alicantecoli
  • 22219 Answers

SOURCE: kia rio gearbox oil filler location? 1.3 2004 manual

half way-level- on front or side of gearbox,think its on the fifth gear housing behind wheel arch on this model ,round plug with a square drive in centre

Posted on Nov 29, 2008

Ad
DickCanFixIt
  • 948 Answers

SOURCE: Where is the gearbox oil filler on a 2005 Sportster XL 883L

The bike has a wet clutch, it uses the engine oil to lubricate the motor, transmission, and cool the clutch.

Posted on Jan 16, 2009

  • 4 Answers

SOURCE: Topping up gearbox oil on 99 Hyundai Lantra (manual)

You can actually do it from the top if it is similar to a 2001 Elantra??? On your right center of the tranny, there should be two big bolts I believe a 17mm one on the bottom left the other top right of the other. The bottom left is the drain plug the top right is where you fill it. If you want to make things easier you can remove the air cleaner and the air cleaner housing then unscrew the sensor on top of the tranny you can poor it in from the top. You will need to then unscrew the fill hole (Top right bolt) Pour the lube in to the hole where you had taken out the sensor until it pours out of the fill hole. Sounds like more work but by doing this you will avoid making a mess trying to fit the squeeze bottle into the tiny hole. Hope this makes Sense????

Posted on May 17, 2009

Bigmick9
  • 18 Answers

SOURCE: where is the gearbox oil filler cap located onford

there is a sump lug. it is located halfway up the gearbox, it will be a square lug i.e a spanner will not remove

Posted on Sep 08, 2009

SOURCE: oil coming out of engine oil filler cap even

The engine breather pipe seems to be blocked.
It may also damage the oil seals.

Posted on Oct 27, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Leaking oil from the top of the cap...


Oil cap leaking - Harley Davidson Forums

www.hdforums.com/forum/sportster.../550364-oil-cap-leaking.html
Aug 13, 2010 - There is always a big amout of oil at the bottom of the bike (probably all from oil cap) and it's drippin' all the time especially if bike is hot. 2007 sportster 883 leaking oil
May 31, 2009
Sportster Oil Leak
Oct 3, 2006
More results from www.hdforums.com

Oil leak at filler cap - Stromtrooper Forum : Suzuki V-Strom ...

www.stromtrooper.com/v-strom-service.../78495-oil-leak-filler-cap.html
Aug 24, 2012 - but more so it seems to me that a new bike shouldn't be leaking oil at all. ... Do I just need to have the dealer replace the seal on the filler cap?

Harley Davidson Motorcycles : About Slobbering Oil ...

? 2:20
https://www.youtube.com/watch?v=lB2DpvxKTGw
Dec 1, 2008 - Uploaded by expertvillage

Jan 20, 2016 | Motorcycles

1 Answer

Can the Oil Pressure Switch on a Kia Sorrento cause an oil leak?


Do you mean filler cap or the oil filter? An improperly seated O-ring on an oil filter is a common source of oil leaks, but these leaks are usually major and noticeable as soon as the engine is started. An oil pressure switch can also be a source of leaks, but a much slower leak. A leak from an oil filler cap would be slower still.

Feb 13, 2014 | Kia Sorento Cars & Trucks

1 Answer

L have a 2000 vw 4motion need to change automatic gearbox oil how do l put in new oil and how many liters does it take


How to check & change oil in automatic transmission on 2000 VW Passat 4Motion:

At the bottom of the automatic gearbox (tiptronic) you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up. Tightening torque is 24 Nm.

tdisline_278.jpg


Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Only ATF with designation ESSO LT 71 141 may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: G 052 162 A2 (1 liter wrapping)
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.
3. The oil level is correct if a slight amount of oil runs out when ATF temperature is between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg) (caused by increase of oil level when heated). For warmer climates, 122 F deg (50 C deg).
4. Hang filled ATF reservoir VAG 1924 as high as possible.
5. Shift lever in "P" position, engine running at idle.
6. Place oil drip pan under transmission oil pan.
7. Remove ATF filler plug (at the bottom of the automatic gearbox you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up.
8. With ATF temperature between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg), for warmer climates, 122 F deg (50 C deg), a slight amount of oil will flow from filler hole when ATF level is correct.
9. If necessary drain or top off ATF to attain correct oil level. Top ATF with filler hook from VAG 1924 ATF reservoir. Insert VAG 1924 (tool) ATF reservoir filler hook into filler hole and top off until a slight amount of oil flows from filler hole.
NOTE: Fit filler hook into one of the oil deflector cap slots placed on the filler opening.
CAUTION: Do not press filler hook upward or oil deflector cap can be pushed off.
10. Reinstall ATF filler plug. Tightening torque is 24 Nm.


The automatic gearbox oil capacity (drain & refill) is 2,6 ... 3,0 litres.
The front differential oil capacity is 0,75 litres. Oil type: SAE 75 W / 90 Synthetic.
The rear differential oil capacity is 1,5 litres. Oil type: SAE 90.


Another automatic gearbox type for 2.5 TDI engine:

tdisline_279.jpg

Front differential versions:

tdisline_280.jpg tdisline_282.jpg

Rear differential versions:

tdisline_283.jpg tdisline_284.jpg

Please do rate my response. Thanks!

Feb 19, 2011 | 2000 Volkswagen Passat 4Motion

1 Answer

My engine is perfect but the power is not reaching the wheels, it is an automatic. Could it be gearbox or low oil in gearbox


How to check & change oil in automatic transmission on 2004 Audi A4

At the bottom of the automatic gearbox (tiptronic) you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up. Tightening torque is 24 Nm.

tdisline_168.jpg


Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Only ATF with designation ESSO LT 71 141 may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: G 052 162 A2 (1 liter wrapping)
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.
3. The oil level is correct if a slight amount of oil runs out when ATF temperature is between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg) (caused by increase of oil level when heated). For warmer climates, 122 F deg (50 C deg).
4. Hang filled ATF reservoir VAG 1924 as high as possible.
5. Shift lever in "P" position, engine running at idle.
6. Place oil drip pan under transmission oil pan.
7. Remove ATF filler plug (at the bottom of the automatic gearbox you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up.
8. With ATF temperature between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg), for warmer climates, 122 F deg (50 C deg), a slight amount of oil will flow from filler hole when ATF level is correct.
9. If necessary drain or top off ATF to attain correct oil level. Top ATF with filler hook from VAG 1924 ATF reservoir. Insert VAG 1924 (tool) ATF reservoir filler hook into filler hole and top off until a slight amount of oil flows from filler hole.
NOTE: Fit filler hook into one of the oil deflector cap slots placed on the filler opening.
CAUTION: Do not press filler hook upward or oil deflector cap can be pushed off.
10. Reinstall ATF filler plug. Tightening torque is 24 Nm.


Please do rate my response. Thanks!

Jan 22, 2011 | 2004 Audi A4

1 Answer

Wondering how to check fluid levals in transmission? i have what appears to be gear oil leaking from gearbox connected to half shaft on right side.


How to check & change oil in automatic transmission

At the bottom of the automatic gearbox (tiptronic) you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up. Tightening torque is 24 Nm.

tdisline_121.jpg


Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Only ATF with designation ESSO LT 71 141 may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: G 052 162 A2 (1 liter wrapping)
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.
3. The oil level is correct if a slight amount of oil runs out when ATF temperature is between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg) (caused by increase of oil level when heated). For warmer climates, 122 F deg (50 C deg).
4. Hang filled ATF reservoir VAG 1924 as high as possible.
5. Shift lever in "P" position, engine running at idle.
6. Place oil drip pan under transmission oil pan.
7. Remove ATF filler plug (at the bottom of the automatic gearbox you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up.
8. With ATF temperature between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg), for warmer climates, 122 F deg (50 C deg), a slight amount of oil will flow from filler hole when ATF level is correct.
9. If necessary drain or top off ATF to attain correct oil level. Top ATF with filler hook from VAG 1924 ATF reservoir. Insert VAG 1924 (tool) ATF reservoir filler hook into filler hole and top off until a slight amount of oil flows from filler hole.
NOTE: Fit filler hook into one of the oil deflector cap slots placed on the filler opening.
CAUTION: Do not press filler hook upward or oil deflector cap can be pushed off.
10. Reinstall ATF filler plug. Tightening torque is 24 Nm.

Please do rate my response. Thanks!

Dec 21, 2010 | Audi A6 Cars & Trucks

1 Answer

WHERE IS THE FILLER PLUG ON THE GEARBOX ON A 1998 PASSAT TDI PLEASE


Hi,

Just checking.... it is a manual gearbox?

You may need a special tool for the drain plug and a 17mm allen key for the filler (some use the special drain tool for the filler as well)

The drain plug is located under the diff housing.

The filler plug is located on the left (nearside) off the gearbox (look to the left of the hole and you can see the 17mm hex filler bung).

Check you can undo the filler bung, then drain the gearbox oil.

Refit drain bung and fill gearbox through filler/level ********* until gearbox oil is up to the level of the filler bung.

Refit, test drive, check for leaks and retest level again when cold.

Cheers,

"If this has helped you in any way, please rate this solution" :-)

Jan 27, 2010 | 1998 Volkswagen Passat

1 Answer

Rm125 1997 gearbox oil level


open up the oil filler cap & see if oil is above the gears teeth & that should be ok

Jul 29, 2009 | 2003 Suzuki RM 125

1 Answer

Where does the transmission oil and engine oil go?


engine oil has a filler cap on top of the engine,and the gearbox oil goes in the filler plug on the side of the gearbox when i refilled one last week after putting a clutch in one .

Jan 15, 2009 | Daewoo Nubira Cars & Trucks

1 Answer

Where is the gearbox oil filler on a 2005 Sportster XL 883L


The bike has a wet clutch, it uses the engine oil to lubricate the motor, transmission, and cool the clutch.

Jan 15, 2009 | 2005 Harley Davidson XL 1200 C Sportster...

2 Answers

Ford ka engin oil


You really need an inspection pit as the car needs to be level. Unscrew filler cap from front face of gearbox ( carefull though as there is a blanking cap as well and it is the one furthest from engine) The oil level should be between 5mm and 10mm below bottom edge of filler plug)

Aug 07, 2008 | 2005 Ford Focus

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

14 people viewed this question

Ask a Question

Usually answered in minutes!

Top Triumph Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

yadayada
yadayada

Level 3 Expert

76649 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

Are you a Triumph Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...