Question about Motorcycles

1 Answer

Over revving i have a keeway hurricane 50.i had a new throttle cable fitted a couple of days ago and now it is over revving.some advice would be great.many thanks

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Renaissance:

    An user who is expert in 3 categories / brands.

  • Motorcycles Master
  • 1,554 Answers

New throttle cable?

Was it properly adjusted?
There should be just a little slack when throttle grip is at idle position.

Check cable routing, making sure there are no sharp bends, or it's hanging up on something.

Finally, lube the cable.

Posted on Feb 15, 2014

Testimonial: "hi,there was no sharp bends in cable not touching anything .all the above was checked but still revving."

  • Strech
    Strech Feb 15, 2014

    Next would be check the idle speed screw on the carb.

×

Ad

4 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad
  • 1 Answer

SOURCE: Where is the VIN on my keeway hurricane?

if you look down from the handle bars to where your feet go you will see a little rectangle on the plastic, if you pop this off the VIN is underneath

Posted on Jun 01, 2009

  • 1 Answer

SOURCE: my moped looses power and the exhaust gets very

Is it a 2 stroke? if so, 1st make sure your gas/oil ratio is correct. 2nd make sure you have the correct sparkplug.... and 3rd... sorry to say.... you may be close to a piston and/or ring seizure. The loss of power and extra heat generation is probably coming from friction between a worn cylinder and the piston/ring.

Posted on Jan 03, 2010

  • 1 Answer

SOURCE: really hard to start

When I bought my Keeway it was supposed to have an alarm and remote start. The dealer said they remove that system from all Keeways they sell because it drains the battery. If yours has remote start,, that may be the problem. I have two Keeways and it seems that if they aren't started and run every day, they will be hard to start. The dealer also told me that these scooters will be difficult to start if they are allowed to sit for any length of time.

Posted on Oct 18, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Keeway Hurricane engine number location


Hi, Sc4t for this scenario you will need your service/owners manual if you can't find the best tool you ever bought for your Honda, despair not, for a mere zero $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
KEEWAY HURRICANE User Manual Page 7
http://www.49ccscoot.com/manuals/Keeway_50cc_2T_Service_Manual.pdf
Hurricane 50 Keeway Scooter Parts Racing Planet USA
http://get2itparts.com/_zz_keeway/Hurricane_Body_06-08.pdf
KEEWAY HURRICANE User Manual

Jun 29, 2017 | Keeway Motorcycles

2 Answers

Keeway hurricane 50 keeps over revving


Weak return spring? Is routed correctly so it doesn't pull when the hadlebars are moved?

Feb 15, 2014 | 2006 Keeway Hurricane 50

1 Answer

My keeway superlight 125cc I have fitted a 150cc


Hi, Anonymous first thing is you forgot to measure the aftermarket for more information about your question and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
piston slap issue
http://www.antiquemotorcycle.org/bboard/showthread.php?19951-What-Causes-Piston-Slap-amp-or-galled-cylinders KEEWAY SUPERLIGHT 125 150 SCOOTER SERVICE REPAIR PDF MANUAL DOWNLOAD 2006... $12
Keewayparts com Genuine Keeway Parts Shipped Worldwide
KEEWAY HURRICANE User Manual

Aug 05, 2013 | Keeway Matrix 150 Motorcycles

1 Answer

My keeway 2010 50 won't start up fully


Hi Rileyluhpink, for more information about your question please visit the website below. Good luck and have a nice day.
http://www.49ccscoot.com/manuals/Keeway_50cc_2T_Service_Manual.pdf

Dec 31, 2012 | 2010 Keeway Hurricane 50

1 Answer

Keeway xray wont start


Hi, Bernado45 before testing any electrical component in the Starter Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test because your battery may have 12.5 volts or more but little or zero amps causing the battery to be faulty and must be replaced, especially "AGM" batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
4. Bank angle sensor needs a reset or is faulty.
5. FOB battery low or dead.
6. Faulty ignition switch.
7. Faulty starter button.
8. Faulty kickstand or clutch pull in switch/sensor.
9. Security alarm needs a reset.
10. Starter relay, solenoid or starter circuit wiring faulty.
11. Starter armature or field coils have failed.
12. Main fuse or circuit breaker may be blown or faulty.
13. The electric starter is working but starter clutch has failed.
14. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
Keeway hurricane won start 49ccScoot com Scooter Forums
Scooter Troubleshooting Scooter won start All about Scooters
KEEWAY 50cc Series Service Manual
Quality Replacement Parts For Keeway
KEEWAY QJ50T 21U Maintenance Manual

Apr 07, 2017 | Keeway Motorcycles

1 Answer

Keeway hurricane 50 .the electricty went off suddenly


Hello and happy thanksgiving from the USA.
I would suspect that you have a defective igntion switch, the igntion switch is what powers up all of the electrical system when you turn the key to run, the contacts can get burnt or the connector or both. The switch is under/behind the ignition key cylinder which operates the switch or course.

Nov 24, 2011 | 2008 Keeway Hurricane 50

1 Answer

Where is the gear oil filler bolt located on the 2010 Keeway Hurricane?


@tomhorton47

Hi I have the same question ! What gear oil should I replenish with ?

Aug 15, 2011 | 2010 Keeway Hurricane 50

1 Answer

2009 Keeway Matrix 50 hard to start


Hi, Fmapalategui and the usual suspects are:
1. Spark plugs in bad condition or have an improper gap or are partially fouled.
2. Spark plug cables in bad condition.
3. Battery damaged or nearly discharged, should have 12.5 volts.
4. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
5. Throttle controls not adjusted correctly.
6. Water or dirt in the fuel system.
7. Water or dirt in the carburetor.
8. Intake air leak.
9. Fuel tank vent hose and vapor valve plugged, or fuel line closed off, restricting fuel flow.
10. Choke valve inoperative.
11. Engine lubricant to heavy (winter operation).
12. Ignition is not functioning properly (possible sensor failure).
13. Faulty ignition coil.
14. Valves sticking.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Scooter Troubleshooting Scooter won start All about Scooters
Troubleshooting
https://cdn.billiger.com/dynimg/WVitYwbFO_Xqc9BITNwYEzt4H9rycHjeBa9LTdXG2DAx4FiuJjDLH0m3jLRp2CDfo6HAhqpeLtB50uY6U1doHI/Keeway-RY6-Racing-50-ccm-3-6-PS-45-km-h-rot-silber-Bedienungsanleitung-7ceda8.pdf
Keeway Scooter Parts Racing Planet USA
Keeway Focus Maintenance Manual

Dec 26, 2017 | 2009 Keeway Matrix 50

1 Answer

2008 Keeway Arn 125 high idle


Hi, W32twood and the usual suspects are:
1. Throttle cables improperly adjusted, pinched or need lubrication.
2. Idle adjusting screw needs to be backed off.
4. Air fuel mixture adjusted too lean start with 2 full turns.
5. Intake system air leak.
6. Fast idle choke ramp is not releasing.
7. Faulty automatic choke.
8. Broken throttle return spring.
9. Damaged diaphragm or slide.
10. Faulty MAP, TPS, ATS, O2, sensors or wiring/connector.
11. Multiple carburetors not in sync.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
think broke my scooter and it my only way of getting to work Please help...
gy6 carb for 150cc scooter engine
2006 Keeway ARN 125 150 Scooter Repair Manual Download Manuals Technical $22
http://www.family-motorsports.net/GY6-50cc-150cc.pdf free
Keeway Scooter Parts Racing Planet USA
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf

Dec 10, 2017 | 2008 Keeway Arn 125

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

136 people viewed this question

Ask a Question

Usually answered in minutes!

Top Motorcycles Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4888 Answers

yadayada
yadayada

Level 3 Expert

79847 Answers

Donald DCruz
Donald DCruz

Level 3 Expert

17130 Answers

Are you a Motorcycle Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...