Question about 2004 Harley Davidson FLHT - FLHTI Electra Glide Standard

1 Answer

2003 electra glide fuel hose inside tank

How tow replace fuel hose inside tank

Posted by Anonymous on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Harley Davidson Master
  • 43,096 Answers

Posted on May 07, 2015

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 2336 Answers

SOURCE: replace rear brake pads

Remove right saddlebag, pull the two caliper mounting bolts and remove the caliper. Do not open bleeder or disconnect line. You will need to push a large screwdriver between the old pads before removing them in order to push the pucks back into the caliper or the new pads will not spread enough to reinstall. Then pull the two smaller bolts from the caliper and the pads will fall out. The pads are different for inside and outside, so pay attention, and remember, after reinstalling, before riding, be sure to pump brake pedal, and it may take a few stops before brakes stop as effectively as before.

Posted on Nov 10, 2008

  • 69 Answers

SOURCE: 1978 Electra-Glide Starter initionally catches,

sounds like the starter is bad. if access to it easy for you then it can be removed and taken to your local repair shop and rebuilt. Or try locateing one on ebay.

Posted on Mar 12, 2009

  • 1 Answer

SOURCE: Rear fuel line at the tank is leaking

The connection is a quick dissconnect, I unpluged the line by pushing up on the bottom of the fitting and pulling down on the retainer . This allowed me to unplug the line. I then removed the fitting that was threaded into the tank and found the rubber "O" ring was bad, I replaced the "O" ring and put the parts back together. ( i sprayed a little WD 40 on the Quick dissconnect and applied a small amount of "O" ring lube to the ring prior to putting everything back together )

Posted on May 18, 2009

  • 109 Answers

SOURCE: 2001 Harley Davidson Road King

My guess. One hose is feed to fuel rail one hose is return from rail and one would be a vent of some kind.

Posted on Mar 21, 2010

  • 1 Answer

SOURCE: where is the fuel filter located on my 2000

my 1999 ultra classic fuel filter is in the tank

Posted on Jul 12, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2003 harley fl fuel tank gasket top plate torque specifications


While pushing down on the canopy, align holes in canopy
with those in fuel tank. Hand start ten new T20
TORX screws in perimeter of canopy. Tighten screws to
18-24 in-lbs (2.0-2.7 Nm) using the pattern shown in the figure below.


04c39913-750b-47bf-a34c-945f68e8b908.jpg

Jul 13, 2014 | 2003 Harley Davidson FLHTCUI Electra Glide...

1 Answer

2004 Harley Davidson Electra Glide Classic Fuel Injection. Engine runs rough, sometimes on a single cylinder..backfires, chokes, runs ok when accelerating. When Gas tank is topped off (even if only one...


sounds like your fuel line inside tank has rubbed a hole in it on the side of the tank this is a common problem. Need to pull hole fuel unit out of tank to replace plastic line.

Sep 07, 2011 | 2004 Harley Davidson FLHTC - FLHTCI...

1 Answer

2000 Harley Davidson electra glide FLH w/efi The fuel in the right tank is not transfering to the left where the guage is and the idiot fuel light comes on so I fuel it up and it take 2 gallon.I put a new...


The vent between the tanks is located under the tank panel. The fuel vent is in the right side gas cap. Did you check to make sure fuel was flowing out of the right tank while you had the crossover hose off?

Good Luck
Steve

Jun 04, 2011 | 2000 Harley Davidson FLHT Electra Glide...

2 Answers

Fuel leak coming from under tank by the hoses(2 lines coming out of tank)


if it has crimped clamps, remove them and replace with adjustable ones, replacing hose in the process would be beneficial!!

Feb 02, 2011 | 2000 Harley Davidson FLHT Electra Glide...

1 Answer

2003 electra glide standard


Have you changed the fuel filter?. It's in the gas tank. Can you hear fuel pump run and turn off when ignition is turned on?

Apr 12, 2009 | 2003 Harley Davidson FLHTCUI Electra Glide...

1 Answer

Removing gas tank on harley flhtci


remove seat, remove console on top of tank, disconnect wiring from console to tank, disconnect vent line if present, disconnect fuel line on tank, disconnect fuel gauge (up under tank on left side, 3 wires, 4 wire connector, wires are yellow, orange, and black), remove bolt at rear of tank, remove two side bolts up front under tank (coil bracket is there also, carefully cut clamp on cross over hose located up front under tank.
This works better with three hands remove one side of cross over hose, fuel will flow freely so the extra hands are good at "plugging" the hose and the tank. Gently remove tank tilting front of tank as much as you can till you get it clear of the frame, while still tilted at a steep angle put the cross over hose back on.
To make things easier drain all fuel out of tank before reversing the process to reinstall tank. Hope this helps.

JP

Mar 16, 2009 | 2003 Harley Davidson FLHTCUI Electra Glide...

Not finding what you are looking for?
2004 Harley Davidson FLHT - FLHTI Electra Glide Standard Logo

104 people viewed this question

Ask a Question

Usually answered in minutes!

Top Harley Davidson Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Mike

Level 3 Expert

4340 Answers

yadayada
yadayada

Level 3 Expert

76673 Answers

Are you a Harley Davidson Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...