Question about Bajaj Avenger Motorcycles

1 Answer

Bike not charging battery - Avenger Bajaj Motorcycles

Posted by Anonymous on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Bajaj Master
  • 43,785 Answers

Hi Anonymous, in order to check out any main system electrical circuit, you have to start with a fully charged battery 12.5 volts or better, and be able to pass a load test if necessary.
1. Check battery terminals for damage or corrosion, check battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
2. Check the voltage drop at the battery when you hit the starter button, anything below 9 volts you might have a faulty battery.
3. Check voltage at the battery with the bike running at 3,600 RPM should be 14.3 to 14.7 volts. If you are not getting these numbers, you might have a faulty voltage regulator.
4. Make sure voltage regulator is grounded and functioning properly, watch the video below on how to test a voltage regulator.
5. Unplug the connector to the alternator and hook your multimeter leads to the alternator (pin/socket selection does not matter) set the multimeter to AC volts, at an idle the meter should read 16 to 20 volts AC. at 2,000 RPM 32 to 40 AC volts, 3,000 RPM 48 to 60 AC volts. If you are not getting these numbers, you may have a faulty rotor, follow step 6
6. Set the multimeter to OHM'S, connect one lead to the alternator (any pin/socket) and the other to a ground, the meter should read infinity. Connect both leads to the alternator meter should read 0.1 to 0.2 OHM'S. If you are not getting these numbers, you have a bad stator.
7. Check all wiring in the charging circuit for worn or chaffed spots and all wiring connectors in the circuit for corroded, broken, or loose pins/sockets, which is the # 1 offender.
For more information about your issue please visit the websites below. Good luck and have a nice day.
How to test and repair the charging system on scooter
Motorcycle Battery Charging System Explained
Bajaj Avenger 2006 service manual DOWNLOAD FREE FULLMANUALS COM
http://www.marutibajaj.com/pdf/Avg-200.pdf
Bajaj Auto Avenger 200 User Manual

Posted on Dec 01, 2015

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Charging system


What age is the bike?
older bike will not charge at idle.
you will know if the bike is charging by measuring theu voltage of the battery with the bike and all accessories switched off if it is a new battery it will be above 13V
A dead battery will be about 11V anything under this and it probably will not recover by charging and you will have to buy a new battery.

ok so lets say the battery is holding 12.5 volts if you start the bike and rev it up and it show higher than 12.5 volt your bike is charging note some bike dont charge under 3000rpm.

Sep 26, 2013 | 2002 Moto Guzzi California 1100 EV Special...

2 Answers

The bike dies, after a fully charged battery.


Bike has magneito (thats spelled wrong ) On line youtube veido shows how to fix that.

Apr 01, 2012 | MBK Motorcycles

2 Answers

Wont start batteerry checked ok , if i jump it with cables it starts , but will not start again the next day


the battery may seem ok, but it's obviously discharging itself or not charging during riding.

Try this...charge the battery with a battery charger.
disconnect the charger, and put a volt meter on the battery.
Start the bike.
Rev up to 2000 RPM. If the voltage is not HIGHER than it was before starting the bike, there's something wrong with the charging circuit.
If it IS charging, turn the bike off, and disconnect the battery overnight.
If the bike will not start the next day after reconnecting the battery, the battery needs to be replaced.

If the battery is NOT charging at 2000 RPM, the charging circuit is bad, and is likely what is draining the battery overnight.

Jun 24, 2011 | 1995 Honda VT 600 C Shadow

1 Answer

I just bought a new battery for my 2005 Softail Deluxe; I road yesterday (10/20 miles) as I was finishinng the run, the bike shut off; could this mean the battery was not fully charged? Will a trickle...


Good idea put it on a trickle charge, however, the battery had enough charge init to start the bike initially, and the bike should have charged the battery after 10-20 miles, worth checking the charge rate to the battery from the rectifier,

Apr 25, 2011 | 2005 Harley Davidson FLSTN- FLSTNI Softail...

1 Answer

Bike not charging - think battery is past its best.


just replace your battery. maybe your battery is defective. but when you change a battery a new one. but still the problem is at ease. maybe the charging parts of the battery is defective.

Jun 25, 2010 | 2005 Moto Morini Corsaro 1200

1 Answer

The battery was low so i jumped it with a booster pack.will the battery recharge itself with the bike running?


If the charging system of your bike is ok, it should charge the battery, unless if the battery has its life span over whereby it wont hold charge any longer.
Best would be to get the battery checked and also the charging rate of your bike.
Hope this helps.

Jan 27, 2010 | Yamaha FZR 600 Motorcycles

2 Answers

CHARGE BATTERY, THEN START BIKE UP. AFTER RIDING


Sounds like you are not getting a charge from the alternator. You need to check battery voltage with a meter with the engine off, key off. Then again with it running, and the voltage should increase. If not, it's not charging.

Jan 26, 2010 | 1999 Honda GL 1500 SE Gold Wing

1 Answer

1993 Kawasaki 750R - Charging issue - Weird!!!


i know this sounds silly ,but when you bought the battery had it been activated,new batterys are critical in their first charge and you cannot use a standare type automotve charger,if bought dry the battery needs to have the acid filled ,left to sit for at least 2 hours prior to charging,once it has sat for the 2 hrs with the acid in,the new battery will need to be charged with a "cteck"or similar type charger for at least 13 hrs before it can be put into normal service,what happened with yours i think is that sure you gave it a charge but it has only recieved a "surface charge"and will be usable for a very short time,it may recover for a brief period and go again untill the surface charge dissipates,(or in other words ..runs out of charge)best thing you can do with the battery is take it to a auto electrician and have the battery cycled and conditioned,this is not expensive to do and will give you piece of mind,after conditioning the battery shouldngive excellent service,i have the battery in my goldwing coditioned about every 12 months and i have the same battery that was in the bike when i bought the bike 8 years ago and still no electrical or battery problems(costs about $25 to get it done)once a year but that beats $280 for a new one...hope this helps

Jul 09, 2009 | 1990 kawasaki ZXR 750

2 Answers

Bikes dead!! Battery wont charge, been charging all night Help!


You didn't mention if you charged the battery in- or out of the bike. If H-D has a modern alternator, it may have failed diodes that are draining the battery and stealing charge current if charged while connected. If the battery was made in China . . . oh, well.

Jul 01, 2009 | 2006 Harley Davidson XL 1200 C Sportster...

1 Answer

Charging system


I think 13.26 is very good for a bike of it's age. Especially charging a bigger cell battery such as a car battery! I wouldn't worry to much about your charging system looks to be doing just fine. almost sounds like your bike needs to be taken out for a Relief of sitting run.

Nov 10, 2008 | 1993 Yamaha FZ 750 KT (Europe)

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

50 people viewed this question

Ask a Question

Usually answered in minutes!

Top Bajaj Experts

sachin sharma
sachin sharma

Level 2 Expert

171 Answers

Donald DCruz
Donald DCruz

Level 3 Expert

17130 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Are you a Bajaj Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...