Question about 2001 KTM Exc-Racing E 400

Open Question

Water pump seal - 2001 KTM Exc-Racing E 400

Posted by Anonymous on

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Water pump leaks out weep hole in water pump when plugged in otherwise doesn't leak! Does this mean water pump seal is out?


Yes. Water pump seal is leaking. The weep hole keeps the water from getting to the bearing in the water pump.

Dec 19, 2016 | Cars & Trucks

1 Answer

Water pump seals


Basically the only way water can get in the oil is if there is a corrosion hole in the housing behind the pump impellor. Water pumps have only 1 seal and if that leaks water will drain from a hole in the pump housing under neath the pump.

Mar 11, 2013 | Husaberg Motorcycles

1 Answer

How do I replace the timing belt and water pump on my 1991 sun bird. 2.0 liter engine


Water Pump: Remove timing belt rear protective covers, Remove lower radiator hose from water pump. Remove water pump attaching bolts then the water pump and sealing ring, Clean engine block and water pump sealing surfaces, then apply a 3/32 inch of RTV sealant to sealing surfaces. While RTV sealant is still wet, install water pump. Tighten attaching bolts finger tight. Install lower radiator hose on water pump, then belt rear protective covers. Install timing belt

Jan 18, 2013 | Cars & Trucks

1 Answer

I have an oil leak from a drain hole in front of engine.what could be the problem?


If the oil plug bolt is leaking you need a new aluminum sealing washer. There are no oil weep holes in the front of the motor. Is it the weep hole under the water pump? You probably have a bad water pump seal or a bad oil seal on the water pump shaft. Buy a new water pump and the K&L water pump gasket kit. The K&L gasket kit comes with all the gaskets, seals, and washers necessary to do the water pump replacement for a fraction of the cost of the OEM Honda individual gaskets, seals, and washers.

Jan 30, 2011 | 1985 Honda GL 1200 Aspencade Gold Wing

1 Answer

I have a 2003 VL 800 Suzuki. I have oil leaking from behind the water pump housing. And yes it is coming out of the small hole behind the water pump. Could this be the oil seal on the water pump? Steve


yes steve- this is the water pump by-pass hole. There is a secondary backup al behind it to stop the water entring the gearbox. Replace the waterpump seal. Most suzukis' use a mechanical seal. they are prity easy to change- although usually requires removal of the clutch cover. I always replace the mechanical seal, back up seal & the bearing all at once.If it is a standard seal type- be sure to ckeck the shaft of the impellor for groves worn in it where the seal contacts the shaft - in mechanical type seals this does not apply.
Hope this helps regards
Andrew

Aug 10, 2010 | 2003 Suzuki VL 800 Volusia

3 Answers

Milky oil on my wr450f 2004


your water pump seal and oil seal have failed on the water pump shaft. Replace both seals noting which way the seals face. replace the water pump shaft if it is scored. Chaz- Moto DC

Jan 20, 2010 | 2004 Yamaha WR 450 F

2 Answers

Lossing water out of small hole on under side of motor ? Normal or not


Not, sounds like a seal vent for the water pump, shouldn't leak.

Jan 07, 2010 | 2005 Honda CRF 450 R

1 Answer

I gave you the wrong pump it was the water pump that was changed


There is a shaft seal in automotive water pumps that can fail.
You will know if it's that seal because water will be dripping from the bottom of the water pump.
If the water is not near the water pump, then look for a freeze plug that is leaking.

Dec 21, 2009 | 1992 Buick Park Avenue

4 Answers

Why is there a water leak coming from the water pump?


i would say you answered your own question, if there is water leaking from the water pump i would say the water pump is leaking and it needs to be replced,either the bearing is bad and its leaking out the shaft,or the seal is bad and its leaking outta there either way you need a new water pump,check the belt for wear when you replace it,,

Oct 07, 2009 | 1998 Dodge Caravan

1 Answer

I have a leak in the water pump on my Kubota F2400 and also a oil/hydraulic fluid leak somewhere underneath the engine. I need to repair them. Help.


your rear seal (oil) pump and mybe your engine seal both are out. do you have water in the pump oil? if so your water seals are out too. need to get A comlete seal kit for the pump.

Oct 05, 2009 | Garden

Not finding what you are looking for?
2001 KTM Exc-Racing E 400 Logo

Related Topics:

16 people viewed this question

Ask a Question

Usually answered in minutes!

Top KTM Experts

yadayada
yadayada

Level 3 Expert

75822 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

Brian Anderson

Level 3 Expert

356 Answers

Are you a KTM Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...