Question about 2004 Factory bike Chrono SM 250

1 Answer

Quad bike keeps cutting out

I can start the quad and it ticks over fine if anything it may be a little fast but as soon as i try rev it it cuts out can any1 help the quad is a apache vmax 50cc with qingoi engine

Posted by on

  • Anonymous Mar 16, 2014

    Apache rtr odo meter service indicatot still blinks after servicing?
    My bike's engine cut off switch doesn't work many times

×

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Master
  • 3,567 Answers


ALWAYS have a fire extinguisher on hand when working on carburetors.
Remove the water trap bowl at the bottom of the petcock, (gas valve). Is there any water or trash in the bowl? Drain a cup of gas from the tank. Is there any water or trash in the cup? Dump it, clean it and re-mount it, ( not all bikes have a water trap bowl ).

Drain the carburetor. There may be a screw on the lower side of the carb float bowl. Remove the screw then replace it after the fuel drains. Turn the gas back on and wait a minute for the carb to fill with gas. If the bike doesn't start and run properly then shut off the gas and remove the carburetor from the engine.

Remove the float bowl and clean the entire carb with a spray carb cleaner from the auto parts store. Wear protective goggles to avoid getting spray in your eyes. Spray into all the little airways and fittings in the carb. Remove the idle screw and the air screw on the outside throat of the
carb and spray into the screw holes as well.
< < READ CLOSELY > >
Be sure to put these two screws back in the same hole they came out of. IMPORTANT > do not tighten these two adjusters down. Only screw these in until they LIGHTLY seat. Now turn each adjuster one and one half turns outward. Before putting the slide back in the throat of the carb, move the clip on the jet needle one notch lower. Put the rest of the
carb back together, clean the air filter and install the carb. Let the float bowl fill then start the engine. This process should get you back on the road.

Please rate this solution. Thanks!

Posted on May 17, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Hi, anyone know what the factory carb settings are for an aeon mini kolt 50cc. Having problems with getting it started, changed spark plug and battery


Two-Stroke Scooter / ATV Carburetor Settings And ...

? 4:37
https://www.youtube.com/watch?v=A1vRMERs4RQ
Jun 2, 2012 - Uploaded by 90GTVert
Part 2 of a 4 part video detailing all of the basic settings and ... Two-Stroke Scooter / ATV Carburetor Settings ...

Fix your Mini bike Carb - bogging, cutting out etc - YouTube

? 4:51
https://www.youtube.com/watch?v=lbtDMFUiD0k
Aug 15, 2011 - Uploaded by Cpt MishMash VonRandom
If you are having trouble with your mini bike/quad whereby its difficult to ... Two-Stroke Scooter / ATV ...

quad 50cc carb Questions & Answers - Fixya

www.fixya.com > Forum > Tags
50cc carb wondering what the factory setting is for a 2002 50cc Kawasaki kid's ...aeon mini kolt 50cc quad will rev a little then cuts out no power Likely a lean ...

Aeon mini kolt 50cc quad will rev a little then cuts out no ...




Jan 05, 2016 | Factory Motorcycles

1 Answer

I have a Mitsubishi shogun eqqippe 2001 3.2did it starts and drives fine but wont tick over keeps cutting out can any1 help ?


Check IAC for dirty deposits, also EGR, throttle body blade and MAF. Also usual tune up items.

Aug 04, 2015 | Mitsubishi Cars & Trucks

1 Answer

Wont rev, ticks over fine


Sounds like a broken cable to the throttle body.

Check that both cables are intact.

Apr 16, 2014 | 2004 BMW R 1200 GS

1 Answer

Apache quad


carb might be clogged clean it

Mar 21, 2014 | ATVs

1 Answer

My 2005 r1 ticks over too fast when warm and wont slow down with idle screw


First off a 05 dont have slipper clutch or idel screw I have an 05 only 08 & up has slipper if it's ticking its cam chain tentionr or clutch assmbly plates springs ect or valves need adjusting

Apr 13, 2013 | 2005 Yamaha YZF-R1

1 Answer

Why does my mccullock tivoli 60 cut out when i increase revs?


probably proper fuel not raching the engine use carburettor cleaner with the engine on it should solve the purpose

Aug 29, 2012 | Garden

1 Answer

When i start my 2004 golf it cuts out when cold


That could be many things causing that. Best to take it into a repair shop. Could just be as little as a tune up required.

Feb 03, 2012 | 2000 Volkswagen Golf

1 Answer

Wheres the choke on a 49cc pocket rocket


The choke is on the carb. Check if the carb set screw is set right, turn it all the way in and then back out 1 1/4 turns. then fine tune by 1/4 turn increments.

Feb 02, 2012 | Quad 47 cc / 49 cc Pocket Mini Bike...

1 Answer

Suzuki lt 50 quad starts and wil tick over but when u try 2 rev it she bogs down and cuts out like a blo9cked carb but i'v had the carb off and its all clean and fine


I got a Suzuki lt 50 it starts fine drives fine at low speed then when I go over half throttle it bogs down I've cleaned the spart plug cleaned the carb and cleaned the jets but its still doin it any ideas please ??

Sep 16, 2011 | Suzuki GSX 750 ES Motorcycles

Not finding what you are looking for?
2004 Factory bike Chrono SM 250 Logo

1,937 people viewed this question

Ask a Question

Usually answered in minutes!

Top Factory bike Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22133 Answers

john h

Level 3 Expert

12104 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

Are you a Factory bike Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...