Question about Motorcycles

1 Answer

Suzuki ozark 250

The electrical start button makes a grinding noise and wont start the ATV, but the pull rope will. what is wrong with it.

Posted by on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 10 Answers

It sounds like the bendix, or engagement clutch is not fully engaging.
Unfortunatly this is a starter removal issue - you have to take the starter off to verify it.
The starter motor is turning (if it wasn't it wouldn't grind) so your batt and electric are good to that point.

Check the dealer to see if there are any similar problems for others and check "Bike Bandit" to see if they have the parts diagram - It is always easier, if you can see how the parts go together.
Good Luck

Posted on Nov 26, 2013

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
polarcycle
  • 1392 Answers

SOURCE: 2004 250 suzuki ozark quad will not run w/o choke

needs the carb cleaned out.

Posted on Jul 13, 2009

  • 149 Answers

SOURCE: '06 Suzuki Eiger ATV will not start. When pushing the

Try shorting out the 2 10mm nuts on the starter relay (has the lead from the battery and starter going to it) if the the engine turns over chech the relay or safety switches. It will flash so make sure the is no open fuel. If nothing happens try tapping the starter motor l(lightly) then try it. If this works the brushes in the starter are worn out..Dont keep on doing it as you will burn the comutator in the starter..Brushes are cheap.

Posted on Jul 03, 2010

  • 1 Answer

SOURCE: I have a 2002 Suzuki Ozark 250 ATV. I only has

I don't have a solution but I do have the exact same problem, '03 or '04 (not sure) Suzuki 250 Quadrunner Ozark,really low hrs, left in storage for 2.5 yrs, gas went bad, cleaned it out, now hard to start and won't idle by itself.
I have taken the carb apart and cleaned it out, but did not replace anything, and it will still not start very easily or idle. Before I took the carb apart I thought it was flooding because it would start with the accelerator wide open, but when I would let off, it would die again. Whats going on?? I really don't want to pay to have it fixed.

Posted on Oct 12, 2010

  • 1 Answer

SOURCE: I have a 2005 Suzuki Ozark 250 ATV. When it is

Sounds like the float is stuck open. Try taking carb out and cleaning all the parts.

Posted on Nov 30, 2010

  • 2 Answers

SOURCE: suzki ozark 250 cleaned out tank and carb runs but will not idle

clean carb, adjust valves and perform and perform a compression test

Posted on Nov 07, 2012

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Can't pull start my 1995 250 suzuki quadrunner LT-F250 or electric start it but if I jump it electric start works when motor running warm cold won't work or pullcord either


Take your battery to O'Reilly's or AutoZone and have the CCA (Cold Cranking Amps) checked.. it takes amperage to crank your ATV..not voltage..
DO NOT EVER JUMP YOUR ATV WITH A CAR OR HI-AMP BATTERY CHARGER..TOO MANY AMPS!!!!

Have a qualified professional clean and set the carburetor...it will make sure the starting process is easier...new spark plug too... and check the air filter...replace if not perfect!!!

Jul 15, 2017 | Suzuki 2005 QuadSport Z400

1 Answer

Part number for neutral light fuse on my suzuki ozark 259 atv


Take the fuse to Oreilly's, Auto Zone. Advance Auto..etc.. one of them will have it..

Jan 31, 2017 | Suzuki 2008 Ozark 250

1 Answer

04 ozark 250 4 wheeler wont go into 1st gear


Check the clutch lining and release bearing. Normally, you would also have to change the pilot bearings.

Feb 02, 2014 | Suzuki Motorcycles

1 Answer

Is it hard to rebuild a carburator for a ozark 250


nope. just remove the float bowl. you will see the jets, pull them out and clean or replace them. you can get a rebuild kit through rockymountain atv. take your time and have a compressed air source

Jul 23, 2013 | Motorcycles

1 Answer

I have a 2002 Suzuki Ozark 250 ATV. I only has about 11 hours on it and was in storage for years. I rode it without problem last fall but now is difficult to start and will not idle. I drained the old gas...


I don't have a solution but I do have the exact same problem, '03 or '04 (not sure) Suzuki 250 Quadrunner Ozark,really low hrs, left in storage for 2.5 yrs, gas went bad, cleaned it out, now hard to start and won't idle by itself.
I have taken the carb apart and cleaned it out, but did not replace anything, and it will still not start very easily or idle. Before I took the carb apart I thought it was flooding because it would start with the accelerator wide open, but when I would let off, it would die again. Whats going on?? I really don't want to pay to have it fixed.

Oct 11, 2010 | 2004 Suzuki RM-Z 250

1 Answer

LT50 Suzuki quad starter pull cord wont turn, any ideas why ?


1.Take the recoil off (pull rope)
2.Than look into it and see if the rope is what is causing it

Apr 23, 2010 | Quad 47 cc / 49 cc Pocket Mini Bike...

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

265 people viewed this question

Ask a Question

Usually answered in minutes!

Top Motorcycles Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4535 Answers

yadayada
yadayada

Level 3 Expert

76649 Answers

kakima

Level 3 Expert

102366 Answers

Are you a Motorcycle Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...