Question about Suzuki VL 800 Volusia Motorcycles

Open Question

2004 suzuki volusia 800 final drive broke what could be wrong

With the back tire off the ground and the motor running and in gear you can stop the tire from turning it makes a grinding noise but with your hand on the drive shaft case it feels like the drive shaft is turning

Posted by Anonymous on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 1 Answer

SOURCE: 2004 suzuki volusia 800 speedometer stopped

I had this same problem its the teeth on the bottom of the speedo take your front tire off be careful with your brakes slide out the axle then just turn your front wheel to one side and the speedo wiil fall out I am willing to bet that the teeth are broken on the end they are made of plastic if you want something a little more detailed just drop me a line at j.rberrios@yahoo.com

Posted on Mar 10, 2009

Ad
dushko
  • 59 Answers

SOURCE: how to change coolent

like anywhere else. what do you expect to hear if you are lazy to ask properly in a few sentences?
first have the engine cool down, then pour out the old coolAnt into a container like a distilled water  container. Add distilled water and coolant in proper volumes and crank up the engine. then de-aerate the cooling system and it's done

Posted on Apr 15, 2009

  • 13 Answers

SOURCE: 2004 suzuki volusia 800 speedometer stopped

I had this problem. there is a speed sensor in the front wheel hub. it is behind the brake and the axel goes through it. if you take the front wheel off you will notice it hanging down on a thick hose/cable. if it isnt aligned right when you put it back on, it will not read or will break off the little wings that seat in the wheel. the piece i am talking about normally falls out when you take the wheel off. the housing for it is what I described above. it is the flower looking piece in the pic in the link below.
http://www.oneidasuzuki.com/store/parts-accessories/speed-sensor-speedometer-vl800-2001-05-c50t.html

Posted on May 15, 2009

nitro650
  • 93 Answers

SOURCE: fuse box on motorcycle

Normally it's found under the driver seat

Posted on Oct 05, 2009

  • 10 Answers

SOURCE: how do you remove rear wheel on suzuki intruder 800

unhook all the brake linkages and rods,axle nut,pull the axle out,and shift the entire wheel to the right and it should pull out,its really easy,although i know it sounds a little overwelming

Posted on May 28, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

What is the top of line Suzuki 800


Hi, Frank the answer to this question is way above my pay grade for this situation, I would call or visit my local dealer or reputable shop's service/parts department and inquire about any possible quick fix, answers, or parts inquiry.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Suzuki VL800 Service Manual
OEM parts for Suzuki
Suzuki VL800 Owner Manual
2004 Suzuki VL 800 Volusia Motorcycle Specs
Suzuki Intruder
Suzuki VL800 Volusia model history

Oct 16, 2017 | 2004 Suzuki VL 800 Volusia

1 Answer

2004 VOLUSIA SPUTTERS AND BACKSFIRES WHEN AT IDLE AND WHEN AT STOPS AND STARTS


Hi, Have you checked and cleaned your spark plugs, remember it's usually the simplest thing that causes poor starting and or running issue's.

Jun 16, 2015 | 2004 Suzuki VL 800 Volusia

1 Answer

Where do you fill and drain the gear box for a Suzuki Volusia intruder 2002 800


I figure that engine and gearbox use the same oil filling; but check the following:
  1. Need 2002 Suzuki Volusia 800 Owners Manual - Suzuki ...

    www.volusiariders.com/.../186127-need-2002-suzuki-volusia-800-owne... Apr 26, 2009 - Suzuki Volusia Forums : Intruder Volusia and Boulevard Forum ... Thanked 0 Times in 0 Posts. Need 2002 Suzuki Volusia 800 Owners Manual ...

Apr 28, 2015 | Suzuki Motorcycles

1 Answer

My 2001 volusioa intruder got hot on the bottom end, left side, and the shifter got really tight and hard to shift?I was told it could be low on oil and am not sure how to check it?


Engine and Transmission
The motorcycle is powered by a 805-cc, or 49.12-cubic-inch, two-cylinder, four-stroke engine. The engine's bore and stroke measure 83.0 and 74.4 millimeters, or 3.3 and 2.9 inches, respectively. The compression ratio is 9.4-to-1. The engine is liquid-cooled. Like most other bikes in its class, the 2004 Suzuki Volusia 800 features a five speed transmission,

Suspension, Brakes and Tires
The 2004 Suzuki Volusia 800 comes with an oil-damped telescopic front suspension, and link-type, oil-damped, seven-way adjustable rear suspension with spring preload. The front and rear brakes are single disc. The bike has a 130/90-16 front tire and a 170/80-15 rear tire.

Apr 23, 2011 | 2003 Suzuki VL 800 Volusia

1 Answer

I have a 2003 suzuki volusia 800 cc and my speedometer does not work, to include the mileage meter


You will need to replace the speedometer sensor which is located on the right side of the front tire hub. It costs about $130.00. To do it yourself, you'll need to hoist the bike so the front tire is off the ground. Remove the front tire. The sensor is that black doughnut looking thing with a wire attached. Repace that and you should be good to go.

Jul 19, 2010 | 2002 Suzuki VL 800 Volusia

1 Answer

2004 VL 800 Volusia: How do i refill the coolant on my 2005 suzuki vl80...


the coolant resivoir bottle is located behind the rear engine cover on the kick stand side

May 18, 2010 | 2004 Suzuki VL 800 Volusia

1 Answer

04 suzuki volusia cant tighten throttle up


either the cable has streached to much or the plastic in your throttle grip is damaged

Jun 21, 2009 | 2004 Suzuki VL 800 Volusia

1 Answer

2003 suzuki VL 800 volushia


probably only need 1/2 to 3/4 litre,when you are filling the final drive through the large bolt hole,that is also the level guide,when the oil starts to dribble out the hole,the drive is full.

May 30, 2009 | 2003 Suzuki VL 800 Volusia

2 Answers

2004 suzuki volusia 800 speedometer stopped


I had this same problem its the teeth on the bottom of the speedo take your front tire off be careful with your brakes slide out the axle then just turn your front wheel to one side and the speedo wiil fall out I am willing to bet that the teeth are broken on the end they are made of plastic if you want something a little more detailed just drop me a line at j.rberrios@yahoo.com

Mar 09, 2009 | 2004 Suzuki VL 800 Volusia

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

23 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

76846 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Richard
Richard

Level 2 Expert

83 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...