Question about 2005 Suzuki Boulevard C90T

Open Question

My 1998 suzuki 800 marauder will not start with the starter push button.It does start jumping the wires on the solenoid sometimes or by jumping the battery

Posted by on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
oldmanewtoys
  • 414 Answers

SOURCE: atv will only start if you jump across the starter

it could be clutch safety switch as well

Posted on Mar 08, 2010

Ad
bazzz7071
  • 342 Answers

SOURCE: I can't start sometimes my suzuki marauder 800

check your battery connection make sure they are clean and tight also check the acid level in the battery and the ground cable if your battery is over 3 yrs old it my not be holding a charge well also.

Posted on May 13, 2010

Testimonial: "THANK YOU I'LL CHECK THE BATERY CHARG"

  • 2 Answers

SOURCE: My 2005 Suzuki Boulevard Will not start most of

Same problem here ... 2008 C90T ... dealer no help ... in 3rd or 4th, ignition off, force it to roll backwards until you hear the piston shift ... should start then. Told it's the rear piston stopping at or near top dead center, but also told adjust the decompression will "solve" the issue; anyway, a rolling forward-start in 4th will work, too, otherwise try rolling the bike backwards until you hear, and you will know when the piston moves and then it will start.

Posted on May 25, 2010

HansPP
  • 2510 Answers

SOURCE: 1997 Suzuki GSXR won't start. Starter button and

Check for an in-line fuse for the started solenoid. Will the starter turn if you take a jump to the solenoid pull-in terminal?

Posted on Feb 02, 2011

  • 738 Answers

SOURCE: 1982 Suzuki GS 650GL won't start. I've purchased a

Well the good news is the click indicates the switch is working, when you press the switch the 2poles on the solenoide are joined together alowing the current to the starter,bridge the wires at the solenoide this should put power directly to the starter you wont need to press the start switch, if the engine does not turn over check the connections to both the battery and starter motor,

Posted on Jul 25, 2011

Testimonial: "I'll check that asap and leave a response as soon as I figure it out! thanks alot!"

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1997 Suzuki VZ 800 Marauder wont start


It sounds like a starter relay.the fact that the bike will start when you jump to the starter motor supports this.Your starter relay will be close to the battery and will have four wires going to it ,two lighter wires and two battery size.cables.It will be about two inches long and be black on top and metallic below.Service is by replacement only, I think they are around $25-$35.Just remember you have battery power going to the one side,don't let it ground on the frame.good luck

May 06, 2014 | 1997 Suzuki VZ 800 Marauder

1 Answer

2000 be the 800 Suzuki Marauder won't start has juice from the battery but no click at the button or no sound from the starter.


bypass button by crossing the large bolts on the solonoid, it will spark. if starter motor spins you know the buttons at fault take apart and clean

Feb 15, 2013 | Motorcycles

1 Answer

What needs to be addressed if I have a new battery and all my '97 suzuki marauder 800 does is click when I press the start button?


Your battery is new ... did it come fully charged or were you suppose to charge it before you installed it? Check the voltage, should be at least 11 volts. I might be calling the store to get further instruction ...

Double check all connections, make sure they are clean and tight (and proper - negative to the ground, positive to the hot side of the start solenoid).

Dec 03, 2012 | 1997 Suzuki VZ 800 Marauder

1 Answer

OK I have a 98 VZ800 Suzuki Marauder, the last few times Ive gone for a ride its started to give me starting issues. Id get a click but no start the first time it started on the 3rd try, then each ride...


Hi, Lkirby2 nice novella before testing any electrical component in the Starter Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test because your battery may have 12.5 volts or more but little or zero amps causing the battery to be faulty and must be replaced especially "AGM" batteries and the usual suspects are:
1. Battery terminals have loose or corroded connections.
2. Battery cables faulty due corroded or broken internal wiring at the cable connector especially the "NEGATIVE" cable which needs to be checked at "BOTH" ends.
3. Battery voltage, must be 12.5 volts or better, voltage from the battery to the main circuit breaker to the ignition switch to the security/ignition fuse to the TSM/TSSM module to the engine stop/run switch to the starter button to the starter relay to the green wire that connects to the starter solenoid can not drop more than 1/2 volt of battery voltage.
4. With a voltmeter connected to the battery, the ignition switch in the on position, the kill switch in the run position, the starter button depressed, starter engagement should not bring voltage below 8-9 volts.
If a lower voltage is produced a proper battery load test should be performed with a load tester to validate battery integrity or battery replacement.
5. Faulty starter relay, check continuity.
6. Faulty starter solenoid, check contact plate and shoes for excessive electrical erosion/etching, refurbish as necessary or invert contact plate and use the virgin backside. Check contact shoes for being loose. Replace solenoid if the negative function is still a final outcome.
7. Faulty starter, bench test starter with a 12-volt battery if negative function check, decontaminate and undercut armature commutator segments as necessary, check segments with an ohmmeter probe each one and the segment next to it for shorts. Have the armature tested with a growler and field coils, and brush plate with an ohm-meter for opens, shorts or grounds. Replace brushes if less than .438" It is generally cheaper to overhaul/refurbish a starter motor than buying a new one.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
98 Suzuki vz 800 Marauder starting issues
What to do When Your Motorcycle Won Start
Suzuki 1997 VZ800 Service Manual
OEM parts for Suzuki
http://mybikemanuals.com/suzuki

Apr 01, 2017 | 1998 Suzuki VZ 800 Marauder

2 Answers

1982 Suzuki GS 650GL won't start. I've purchased a


Well the good news is the click indicates the switch is working, when you press the switch the 2poles on the solenoide are joined together alowing the current to the starter,bridge the wires at the solenoide this should put power directly to the starter you wont need to press the start switch, if the engine does not turn over check the connections to both the battery and starter motor,

Jul 25, 2011 | 1982 Suzuki Gs 550 L

1 Answer

When the ignition switch is pushed all the bike does is clicks. It will push start and run with no other problems.


If you push the starter button and the solenoid clicks, the button is good. Take a wire and jump the two posts on the solenoid or touch the two cables together. If your starter works, then you need a new solenoid. If you hold the starter button and tap on the starter with a plastic hammer and the starter works you need new starter brushes. Anything else wrong with the starter and you need to replace the starter assembly , unless the manufacturer sells replacement parts so you can repair the starter. most manufacturers only sell replacement starter brushes.

Nov 22, 2010 | 2001 Suzuki VS 800 Intruder

1 Answer

I can't start sometimes my suzuki marauder 800 when I press the start button I only hear a click from under the seat (relay) if I short circuit the two red wires abeam the relay nothing happened if someone...


check your battery connection make sure they are clean and tight also check the acid level in the battery and the ground cable if your battery is over 3 yrs old it my not be holding a charge well also.

May 12, 2010 | 1999 Suzuki VZ 800 Marauder

1 Answer

How do i jump the ignition switch on a marauder 2002. lost the key


My first thought is to get a locksmith to make a new key for the bike. A Suzuki dealer might be able to make one too. I know GM can (or could) make a new key if you gave them the vehicle identification number. You can also buy an aftermarket key switch and keys from most parts stores.If you insist on messing up the wiring on your bike pull the switch so you can see what you are doing. One wire will run directly from the positive terminal on the battery and will be hot. Hook a jumper from the always hot wire to the wire that leads to the ignition system. That is your on/off switch. Hook a second jumper to the always hot terminal and touch it to the wire leading to the starter solenoid lead. That is your start button. Good Luck.

Mar 20, 2010 | 2002 Suzuki VZ 800 Marauder

1 Answer

My bike won't turn over?


You either blew some fuses and or sometimes if you jump a cycle battery with a auto or truck you put to much amperage into the cycle system and it burns things up. Have a good look at the whole wiring harness.Gook luck. donnyb60

Mar 22, 2009 | 2001 Suzuki VZ 800 Marauder

Not finding what you are looking for?
2005 Suzuki Boulevard C90T Logo

Related Topics:

26 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

76846 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4536 Answers

Richard
Richard

Level 2 Expert

83 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...