Question about Suzuki Motorcycles
The air filter is under the dash. you need to pull the covers and the panel for the fuel filler and speed cluster. once you get that panel off you can get to the fuel filer air filter and many other things that are hide under the covers
Posted on Mar 21, 2015
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Hi ...... Find where the battery is, under the seat or behind a side panel. Disconnect the black (negative lead usually with a 10mm spanner then disconect the red (positive) lead. The battery will be held in place with a 'rubber' strap or a bracket and depending on type of battery there may be a vent hose from the battery to the lower half of the bike, this just pulls off and remains in place until you replace the battery. Installation is reverse except you connect red (positive) first.
Let us know how you get on.
Posted on Jan 20, 2009
Any changes you make to the exhaust system will alter the sound the bike produces. The more you cut baffles,and open up the exhaust, the louder it will get. What you do alter to a greater extent,is the state of tune of the motorcycle. Any changes to exhaust or inlet plumbing will require a retune of the engine to suit the modifications. This can be subtle to dramatic. Opening up exhausts can often rob low end power where exhaust port scavaging is relient on some back pressure for maximum effect.
Best to work directly with an engine tuner to do the mods that are known you can get away with, or buy aftermarket prebuilt pipes that have a known previously tested state of tune. Nothing worse than doing something, that then costs money to put back the way it was on finding out it didnt work as well as was hoped.. Hope this has helped you steer your custom mods a little. I can say with certainty, that I have ventured to do what you are doing many times in the past, and it has always cost me more money in tuning and... and well more parts :) Cheers
Posted on Jan 20, 2009
I know for the models till 2002 where the battery is located in front of the rear wheel.
Place the bike on her side stand
remove the negative battery lead at the left side, just below the transmission tube ( cone ) 10mm socket wrench
On the right side remove the security cap on the positive lead ( cross screwdriver ), then remove the positive lead.
The battery is hold in place with a 'floor plate'. remove both bolts of the floorplate ( on each side ) while holding the palte into place.
gently lower the plate and the battery.
I hope the 2004 model has the same assembly!
Posted on Apr 02, 2009
the manual probably wont give you those details,go onto www. bikebandit.com type in your make and model,this will bring up a full parts schematic with part numbers etc,if not just simply get them off your local dealer,they are normally quite helpfull if they think they are going to get a sale..hope this helps
Posted on Jul 10, 2009
Tips for a great answer:
Aug 25, 2017 | 2002 Suzuki VL 1500 Intruder LC
Apr 14, 2016 | 2002 Suzuki VL 1500 Intruder LC
Sep 23, 2014 | 2004 Suzuki Intruder LC 1500
Jul 18, 2014 | 2004 Suzuki Intruder LC 1500
Jun 15, 2012 | 2002 Suzuki VL 1500 Intruder LC
Apr 02, 2011 | 2002 Suzuki VL 1500 Intruder LC
May 30, 2010 | 2000 Suzuki VL 1500 Intruder LC
May 17, 2010 | 2002 Suzuki VL 1500 Intruder LC
Apr 15, 2009 | 2002 Suzuki VL 1500 Intruder LC
62 people viewed this question
Usually answered in minutes!