Question about 1996 Suzuki GSX-R 750 T
My Bike Wont Star,New Spark Plugs battery Full Charge,Fuel Pump Work fine cause,It flood the carb,just no signal off ignite.
Yes, a dirty Carburetor can stop the engine from running.
Drain the carburetors. There should be a screw on the lower side of each CARB float bowl. Remove the screw then replace it after the fuel drains. Is there any water in the gas? Remove the water trap bowl at the bottom of the petcock, (gas valve). Is there any water or trash in the bowl? Drain a cup of gas from the tank. Is there any water or trash in the cup? Dump it, clean it and re-mount it, (not all bikes have a water trap bowl). Turn the gas back on and wait a minute for the carbs to fill with gas. Try to start the engine. If the bike doesn't start and run properly then shut off the gas and remove the carburetors from the engine.
FOR EACH CARB > Remove the float bowl and clean the entire Carb with a spray Carb cleaner from the auto parts store. Wear protective goggles to avoid getting spray in your eyes. Spray into all the little airways and fittings in the Carb.
FOR NO SPARK > Check the fuses. Next, check for spark but with a new spark plug. How good is the battery? Is the kill switch on? Does the side stand have a kill switch? Is it working properly? Tip-over kill switch on your bike? Check the operation of the ignition switch and all kill switches with a volt ohmmeter.
Check the wiring harness. Did a wire come unplugged? Are all wires clean and with solid connections? Any abraded or pinched wires? Is the bike in neutral and the neutral light is lit up? If no neutral light, check the neutral switch and neutral switch wire on center casing. If still no spark, get CDI system and coils checked at the dealers shop.
Please rate this answer. Thanks
Posted on Apr 14, 2009
I am a bike mechanic and ever since this ethanal gas came out i hav been cleaning carbs constantly. first problem it plugs up the pilot jet which should be removed and blown out with air. the other problem is when the bike sits too long this fuel will swell up the rubber tip on the float needle it sticks in the seat which of course will not let any fuel to the to the carb. sometimes banging the side of the carb with a screwdriver handle gently will unstick the float needle. 9 out of 10 the carb must be removed and cleaned. hope this helps.
Posted on Apr 14, 2009
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Posted on Jan 02, 2017
Tips for a great answer:
Jan 18, 2014 | Motorcycles
Aug 20, 2010 | Enfield Bullet 500 Motorcycles
May 10, 2010 | 2007 BMW R 1200 GS
Feb 13, 2010 | 1990 kawasaki ZXR 750
Aug 03, 2009 | 2001 Suzuki SV 650
Jun 30, 2009 | 1997 BMW R 1100 GS
Jun 14, 2009 | 1997 Yamaha XVS 650 Dragstar
May 29, 2009 | 1991 Suzuki VS 1400 Intruder
Dec 13, 2008 | 2007 kawasaki Z750
382 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: