Question about Motorcycles

1 Answer

Suzuki burgman 650

Electric starter wont engage...battery is charged...help

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Master:

    An expert who has achieved Level 3.

  • Master
  • 450 Answers

Cross the 2 bolts on relay, does this turn engine, if so bad connection to battery, if not replace relay.

Posted on Jul 25, 2013

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad

SOURCE: suzuki burgman 650 won,t change gear

I had the same problem until I found out that when you put the Burgman on it's center stand, it pushes a small round metal pin (spring loaded or something similar) that limits the Burgman to 1st gear only. Some kind of safety feature, I guess. You can see the little switch if you put the bike on it's side-stand, get down on the right hand of the bike and look where the centre stand meets with the body of the bike. My switch was stuck in permanent "on" so I just pulled the pin to it's full extention with a pair of pliars, then cut it with a junior hacksaw.

Posted on Jun 03, 2009

  • 3567 Answers

SOURCE: Need used suzuki burgman 650 engine

google "burgman dealers" and you can find a dealer and even corporate HQ. Also google "mororcycle salvage burgman" Site numbers 7 & 8 look promising. Also, "mororcycle salvage burgman 650". Between the dealers and the salvage yard you should be able to find another engine.

A “very helpful” rating for this answer? Thanks!

Posted on Jun 17, 2009

ryszardx
  • 88 Answers

SOURCE: need engine oil capacity for 650 suzuki burgman scooter

2.7 Quarts or 3.1 Quarts with a filter change.

Posted on Jul 06, 2009

carlsbiz
  • 1124 Answers

SOURCE: Transmission blew on my Burgman 650

A good friend of mine had 2 also. Same exact thing happened to both..
It "might " be a good idea to get a "savaged" trani IF it has low miles..
To answer your qusetion - I think it is self evident that these tranies are good for roughly 30-k miles - infortunaltely..

Note;
Thank you for posting your question on FixYa.com
We are helping people on a points system.
If the information provided here was at all helpful,
please be kind - rate well and close the post.
Thank you – and enjoy your day ;o)

Posted on Aug 01, 2009

  • 13 Answers

SOURCE: No electric power on a suzuki rf900.

a: Main 30A fuse blown - probably the wiring round the fairing bracket under Suzukis cable-tie

b: Main 30A fuse ok - the multi plug on top of the starter solenoid is corroded.

c: Very low battery volts - alternator coupling gone.

d: join www.rfownersclub.co.uk you will be rewarded with the best knowledge ever and all free

Posted on Feb 24, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I not getting anything the Suzuki burgman 650 will not do anything


Hi, Duke before testing any electrical component in the Starter Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test because your battery may have 12.5 volts or more but little or zero amps causing the battery to be faulty and must be replaced, especially "AGM" batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
4. Bank angle sensor needs a reset or is faulty.
5. FOB battery low or dead.
6. Faulty ignition switch.
7. Faulty starter button.
8. Faulty kickstand or clutch pull in switch/sensor.
9. Security alarm needs a reset.
10. Starter relay, solenoid, starter have failed or circuit wiring faulty.
11. Starter armature or field coils have failed.
12. Main fuse or circuit breaker may be blown or faulty.
13. The electric starter is working but starter clutch has failed.
14. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
http://burgmanusa.com/forums/15-burgman-650/46583-2003-650-won-t-start.html
Scooter Troubleshooting Scooter won start All about Scooters
Suzuki AN650 Service Manual
OEM parts for Yamaha
Suzuki Burgman 650 2004

May 18, 2017 | 2005 Suzuki Burgman 650

1 Answer

I have 2012 Suzuki Burgman 650 scooter, how do I reset the clock and from kilos to miles


Hi, Jim for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Suzuki, despair not, for a mere zero $ you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have a nice day.
http://burgmanusa.com/forums/15-burgman-650/8849-mph-km-h-miles-kms.html
07 Suzuki Burgman 400 Set Time Clock
Suzuki AN650 Service Manual
OEM parts for Suzuki

Jan 06, 2017 | 2012 Suzuki Burgman 650 Executive

1 Answer

Where is the ECM located on a 2007 Suzuki 650 Bergman scooter?


Hi, Mike for this scenario you will need your service/owners manual if you can't find the first and best tool you ever bought for your Suzuki, despair not, for a mere $0 you can download another one. For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have a nice day.
2007 Suzuki 650 Burgman ECM location Google Search
http://burgmanusa.com/forums/15-burgman-650/45951-ecm-failure.html
Suzuki AN650 Service Manual
OEM parts for Suzuki

Oct 24, 2016 | 2007 Suzuki Burgman 650

2 Answers

86 suzuki savage 650 new battery new starter new solenoid but wont start


Hi, Vera and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, needs to be 12.5 volts or better and be able to pass a load test if necessary, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Faulty ignition switch.
6. Faulty starter button.
7. Faulty kickstand or clutch pull in switch/sensor.
8. Security alarm needs a reset.
9. Starter control circuit, relay, or solenoid faulty.
10. Main fuse or circuit breaker may be blown or faulty.
11. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have nice a day.
Thread Suzuki Savage won start Help Newbie
SUZUKI LS650P Manual
OEM parts for Suzuki
Suzuki LS650 Savage 1986 2004 Workshop Repair Service Manual Download...

Jul 17, 2016 | Suzuki Motorcycles

1 Answer

Intermittent problem to start all lights are on but bike won't start


Hi, Mary and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, needs to be 12.5 volts or better and be able to pass a load test if necessary, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Faulty starter button/switch.
6. Faulty jiffy stand or clutch pull in switch/sensor.
7. Security alarm needs a reset.
8. Starter control circuit, relay, or solenoid faulty.
9. Main fuse or circuit breaker may be blown or faulty.
10. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue and valuable "FREE" downloads that you will need please click on the links below. Good luck and have nice a day.
http://burgmanusa.com/forums/15-burgman-650/46583-2003-650-won-t-start.html
http://burgmanriders.com/forums/showthread.php/6957-2003-burgman-400-won-t-start
07 Suzuki Burgman 400 Starter Switch Problem
http://www.motorscooterguide.net/Manuals/Suzuki_AN650_Service_Manual.pdf

Apr 07, 2016 | 2006 Suzuki Burgman 650

1 Answer

Where can i see rectifier on my burgman 125uh 2003 model..which part of the scooter thanks in advance


650 Regulator Rectifier experience - Suzuki Burgman Forum - BurgmanUSA

burgmanusa.com/...burgman.../49945-650-regulator-rectifier-experience...
Apr 18, 2012 - This is my experience swapping out my rectifier with an aftermarket Mosfet unit. I have no long term review right now but here are some ... scooter stalls at low rpm's - Suzuki Burgman Forum
May 23, 2015
Starting / Electrical issue with 2008 Burgman 400 - Suzuki ...
Feb 14, 2013
2003 650 CVT motor issues! - Suzuki Burgman Forum
Dec 9, 2010
OIL LIGHT ON - Suzuki Burgman Forum - BurgmanUSA
Apr 17, 2004
More results from burgmanusa.com

How to wire a GY6 scooter regulator / rectifier and how it all ...

? 4:56
www.youtube.com/watch?v=u8dGhevthRI

Oct 28, 2009 - Uploaded by serpentza
How to wire a GY6 scooter regulator / rectifier and how it all works (Part 3 .... My scooter has no spark how to fix. gy6 chinese scooter 139qmb ...

Oct 28, 2015 | Motorcycles

1 Answer

2004 Burgman 650. Ignition light flickering


you have a lose electrical conection. Maybe a lose wire on your ignition barrel.

Oct 28, 2009 | 2003 Suzuki AN 650 Burgman

1 Answer

Need used suzuki burgman 650 engine


google "burgman dealers" and you can find a dealer and even corporate HQ. Also google "mororcycle salvage burgman" Site numbers 7 & 8 look promising. Also, "mororcycle salvage burgman 650". Between the dealers and the salvage yard you should be able to find another engine.

A “very helpful” rating for this answer? Thanks!

Jun 17, 2009 | 2003 Suzuki AN 650 Burgman

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

58 people viewed this question

Ask a Question

Usually answered in minutes!

Top Motorcycles Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4525 Answers

yadayada
yadayada

Level 3 Expert

76164 Answers

kakima

Level 3 Expert

102366 Answers

Are you a Motorcycle Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...