Question about 2005 Suzuki RM-Z 450

1 Answer

Help my suzuki wont start without the hot start and it wont idle

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Scholar:

    An expert who has written 20 answers of more than 400 characters.

  • Expert
  • 149 Answers

If its been sitting for a while or run through a lot of water or water in the fuel, try draining the carby 1st by lossening the 17mm drain plug at the bottom of the carby.
if its full of water and or gunk you should remove it and clean.

With patience you can remove the main and pilot jets to clean them..The Pilot sounds more like the problem.....If you have to get the carby off remove the rear (seat) frame lower bolts loosen the top bolt rear ex pipe and swing the frame up watch out for the wires then remove the carby...

Try removing the jets 1st...it can be a pain but its much easier.

Posted on Feb 27, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have a 99 suzuki srad 750 that wont start once hot, ive changed batteries,stator,and starter,still wont start without a jump start


Did starter include a new solenoid? However, there has been a rash of bad "new" solenoids. Try to "jump" around the solenoid to see if it spins the starter motor. If it does, most likely a bad "new" solenoid.

Apr 05, 2015 | Suzuki Motorcycles

1 Answer

ON A 2004 SUZUKI XL7 2.7 WILL THE EGR VALVE MAKE YOU PUMP THE GAS BEFORE IT STARTS. WHEN IS WARMED UP IT WONT START UNLESS YOU PUMP THE GAS .IF IT SETS OVER NIGHT IT STARTS RIGHT UP


2.7L V6, Good, the rare post with engines stated. like mine. same.
hot starts fail, cold good
can be many things, (we find this with simple tests (ask)
lack of supply air, cranking (IAC stuck closed)
flooding do to , ECT reads wrong or injector leak.
EGR stuck open sure, its a service point, we clean it, then it works.
(works means , at least closed to crank, not pass smog tests)
ever tune it up, get it the full 60kmile tuneup, if not, why not?
spark plugs. C.O.P boots bad? buy new ones,(ask) cheap (ask)
(basics) no hot starts, easy
bad spark. any or all of 6 cylinders.
no air to start (IaC)
too much fuel to start (any of 6 cylinders)



The egr is near imposable to reach on this dog. top center rear of engine.
the IAC is easy. see here. (IDLE AIR CONTROL VALVE)

IS Engine idle hot, ever below, 800 RPM? or surging?????






25408344-fivq5xl3wt5ieutt12itpjng-4-0.jpg see all parts here (matches most V6s by suz)

http://www.fixkick.com/engine/2.5L%202004%20Tracker/25L-2004-engine.pdf

Feb 09, 2015 | 2004 Suzuki XL-7

1 Answer

2002 Suzuki vz80, starts and idles great, wont to take off


Make sure you engine is hot to the touch before you ride away. After its warmed up make sure your chock is off or your motor will stall because it is too rich when warm.

Oct 13, 2013 | 2000 Suzuki VZ 800 Marauder

1 Answer

Have 2003 suzuki aerio won't idle after temp light goes out


the engine can not idle right for vast reasons.
wont idle, does that mean
1: stalls.?
2: or wont regulate, hot.
3: or both.
So , no DTCs, no cell lamp glowing , running?
you replaced some very expensive parts, by guessing?
checking fuel pressure costs $20 for the tool.
do you have a $50 scan tool? if yes, you can scan all sensors.
and see if the sensors all look good. do they?
did you buy a used maf ,or new suzuki maf $$$ or the china clone.
most of the clones are no good.
best is , used, and from Cardone.(rebuilt by pros)
the China clones , read wrong, the ECU does not know its wrong
because it is not stuck at 0 or 5v. so assumes its right and is wrong.
with a scan tool you can see the MAF read wrong. do you?
what i do is plot TPS angle, RPM and MAF output and log that.
then at home read the values.

the #1 reason for stalls is leaking EGR. ever clean and service it?

Apr 10, 2013 | 2003 Suzuki Aerio

1 Answer

I have a 1994 Intruder. It only starts and runs


The hot side is running way too lean. Have your carbs synchronized may help. Try draining the bowls. Good luck.

May 28, 2010 | 1994 Suzuki VS 800 Intruder

2 Answers

I recently bought a suzuki rm 125 and it wont run with out me giving it revs y is this . i cant leave it to tick over because wen i let off the throttle the bike dies????


the idle buddy is too low,on the carb is a screw the ide screw turn it in 1/4 of a turn with the bike running untill it idles the way you want it too and it will idle the pic below ill help ya buddy 34c510c.jpg

Sep 22, 2009 | 2003 Suzuki RM 125

1 Answer

Recurring Mystery Problem in a 1986 Suzuki Alto. (Idle related)


Bad fuel, water in the fuel, dirt in the fuel.

Drain the fuel tank completely.

Pour in a gallon or two of fresh fuel.

See how it goes.

Put some of the old fuel in a glass bottle, hold it up in front of a light and see if you can see any foreign material in it...






Aug 19, 2009 | 1989 Suzuki Swift

2 Answers

I got a 1990 Suzuki GSX750F Katana, the problem is that when I pull the choke out and start it up it will idle, now if I take right off it rides great, but when I come to a stop or hold the clutch long...


It still sounds like it still running rich. If it doesn't have any performance mods like aftermarket exhaust it wont like the stage 3 kit. The stage 3 kit should be install if it has high performance exhaust and k&n pods instead of an airbox and filter. Or the floats may be stuck or improperly adjusted.

Jun 21, 2009 | 1997 BMW R 80 R

1 Answer

Won't idle especially when hot.


not real sure but you may be sucking air from a hose or loose manifold





















May 23, 2009 | 2001 Suzuki DR-Z 250

2 Answers

1995 suzuki sidekick 16 valve


Check throtle position sensor... one section closes a set of contacts when you take your foot off the accelerator... this is sent back to the engine control computer which adjust the timing to insure the engine stays @ ~ 800 rpm. It's easy to set with just a simple multimeter...

Jul 15, 2008 | 1995 Suzuki Sidekick

Not finding what you are looking for?
2005 Suzuki RM-Z 450 Logo

Related Topics:

184 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

66744 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4509 Answers

Ed Nelson
Ed Nelson

Level 2 Expert

149 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...