Question about 2003 Suzuki AN 400 Burgman

2 Answers

Bike wont start battery is ok 12.5volts lights dont turn on fuse ok what can i check

Posted by on

  • Anonymous Apr 09, 2009

    i have the same problem

×

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Master
  • 948 Answers

Test the battery voltage while you are trying to start the scooter. The surface charge can be over 12v but under load drop to well under 9, indicating a faulty battery.

Posted on Feb 22, 2009

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

I had a very similar problem last week. Coming home from work, the bike went dead with no electrics at all. Battery and fuse ok. Turned out that the red wire from starter solenoid was broken internally, if wiggled, then power came back. So i cut it off the plug at solenoid and crimped a connector on it, and then connected it to the red terminal on the solenoid. Bingo, it now runs better that it ever has. One proviso here though, by doing what i did, it removes the fuse from the circuit, so not ideal, and needs sorting at some point.

Posted on Jul 20, 2009

1 Suggested Answer

Benimur
  • 6966 Answers

SOURCE: 00 kawasaki ninja zx6r my bike don have no power,

Hi and welcome to FixYa,

I understand that you have checked the:

  • battery - that it is fully charged and that the cables & terminals / connectors are clean and tight;
  • fuses - including the 30 Amp main fuse;
  • starter relay - there is +12 on the white wire.
Should the above hold true, then the only remaining components to suspect / check would be the always on +12 connectors and/or the ignition switch.

Good luck and thank you for asking FixYa.

Posted on Nov 18, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Wont start at all


If you have no light you can't even hot wire it sounds like the ignition switch is bad in the start and run positions.

Jan 30, 2014 | 2005 Yamaha YZF-R6

1 Answer

2008 electra glide battery draw, test light pulses, now bike wont crank over


The pulsing could be the alarm module. When bike is turned of, you will get small draw for a minute or so and then it should go very low, below a miliamp or so. This is the alarm module setting itself. Check for this. Is battery gone flat while checks were being made? Make sure ignition switch is on when disconnecting battery if alarm (Stock HD) is fitted. If not, alarm module gets confused and can cause problems. The corrct procedure for disconnecting a battery from an alarm fitted HS is - alarm off, ignition switch on, pull main fuse (Maxi Fuse), disconnect battery. To fit, ignition stitch off, connect battery then install main fuse.

Nov 01, 2013 | Harley Davidson FLHTCUI Electra Glide...

1 Answer

Bike turns over all lights on except the neutral light when i try and start it it wont start all fuses work battery good


You dont say what bike this is, most modern bikes wont start if the neutrol light does not work, this is safety feture to stop you starting the bike in gear, does the bike turn over ok or not? Does the bike have the gearing selection reversed as with rear sets in track mode as the gears are reversed, and neutrol would be 1 down from the top

May 05, 2011 | Yamaha NC 110 Motorcycles

1 Answer

Charged battery up for bike because would not start


?.....was the bang when you tried to start the bike...or as you turned ignition on?...if when you turned ignition on sounds like you need to check wireing...if bang was when you truned eneing over it could be unburt petrol that banged when bike tried to fire up !!...

Feb 17, 2010 | 1998 Honda CBR 1100 XX Super blackbird

2 Answers

2001 gsxr 1000 wont start.


ur bikes wiring needs thuro inspection for cuts corrosion and bad connections--smoke probly commin from these issues and a clic can be a loose wire or failin starter

Dec 28, 2009 | 2001 Suzuki GSX-R 1000

2 Answers

Starting fault


There are two safety switches that you may need to test. 1) Neutral safety switch- this switch is what tells the bike that it's in neutral and allows the starter to engage. 2) Kickstand safety switch- this switch will not allow the bike to run in gear if the kickstand is down. My initial guess is the neutral safety switch. If the neutral safety switch is bad, then you will not be able to start the bike with the kickstand down because the bike thinks that it's in gear (even if in neutral). This also may explain why the initial intermitent problem of not starting when warm since the metal contacts will expand and possibly not make contact when warmed up. Are you trying to start the bike with the kickstand up or down? If it were the kickstand safety switch, the bike would probably start okay and then die when you put it in gear.

Oct 10, 2009 | 1995 kawasaki ZZR 1100

1 Answer

1989 yahama fzr wont start


could be the diode. They will read in one direction only coils sound ok

Jul 26, 2009 | Yamaha XS 650 H Motorcycles

1 Answer

Bike will not start no power


Touch a 12" piece of wire to one terminal then touch the other end of the wire to the other terminal. Got a really good spark? No spark = bad battery. Okay, so you do get a good spark. Check the wiring harness for an unplugged wire. Also check for loose connections and burned wires. Bad ignition switch? Kill switch turned on?

Mar 13, 2009 | 2005 Honda CBF 500 ABS

1 Answer

Bike will not start no power


maybe a master 20 or 30 amp on the positive wire from battery

Feb 22, 2009 | 2003 Yamaha Road Star Silverado

1 Answer

Bike wont start


check that it is fully charged as some new batt arnt charged failing that check the starter fuse next to the battery should be a 30amp fuse

Feb 21, 2009 | 2003 Honda CBR 954 RR Fireblade

Not finding what you are looking for?
2003 Suzuki AN 400 Burgman Logo

713 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

60769 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4471 Answers

Ed Nelson
Ed Nelson

Level 2 Expert

149 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...