Question about 2006 KTM 450 SX

1 Answer

2007 ktm 450sxf electric start issues

Battery charger shorted out and now bike won't turn over? did i short the ignition or just a fuse? i just bought the bike and don't have a manual for it yet. I hooked up another battery to test it and still nothing. any help will be appreciated-  cody

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Hot-Shot:

    An expert who has answered 20 questions.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 48 Answers

I would check the main fuse first then i would check the charge in the battery the shorted charger may have discharged the battery or killed some of the cells

Posted on Jan 13, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I was changing blinker and crossed a wire it shorted out lost all power to motorcycle and all fuses in fuse box are good what could be problem and where is it located


Hi, Leslie either your battery is dead, your main fuse is blown or you have a battery connection issue or you have a dead short which is usually the easiest to find. Using a test light connected to the hot side of the blown fuse holder, start probing the wire leaving the fuse holder about an inch away the test light should illuminate, keep probing towards the ignition switch until the test light no longer illuminates you are now very close to the short. Good luck and have a nice day.
why doesn my motorcycle power on
http://www.starbikeforums.com/forums/14-royal-star/23673-no-electrical-power-when-key-turned.html
No electrical power on bike
No electrical power

Apr 10, 2016 | Power Motorcycles

1 Answer

I've got a KTM 125sx 2002 I've done a top end rebuild piston etc and put a new coil and plug on it and the bike won't start with the kicker, only with a bump start took the plug out and its got a weak


Hi, Ian and the usual suspects are:
1. Fouled spark plugs.
2. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
3. Loose connection at ignition coil or plug between ignition sensor and module.
4. Spark plug cables in bad condition, shorting / leaking, spark plug cable connections loose.
5. Faulty ignition coil or ignition / electronic module
6. Failed CKP, CMP, or BAS sensor.
7. Faulty ignition switch.
8. Security alarm failing to disarm needs reset
For more information about your issue and valuable free downloads that you will need please visit the websites below. Good luck and have a nice day.
125sx won kick start please help me KTM 2 Stroke
ktm 85 sx no spark
1999 2003 KTM 125 200 SX MXC EXC Service Manual Moto Data Project

Feb 23, 2016 | KTM Motorcycles

1 Answer

Motor blows fuse


there is a short in the system that is connected to that relay/fuse. Could also be melted wires if you tried to ever jump start it from a car, start position on a charger or jump start box. Jump starting a motorcycle should never be done. The gauge of wires on a motorcycle are much lighter than vehicles.
It is VERY rare but i have seen batteries that are reversed polarity. Check to make sure battery is 12v + when you test it. Not 12v -

Apr 03, 2014 | 2007 Suzuki Boulevard S40

1 Answer

My 2000 ktm 200 will not start


Hi, Aw98628 and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the enrichner.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. A severely discharged or damaged battery, you need 12.5 volts or better and be able to pass a load test if necessary.
13. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
14. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
15. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections loose, or connected to the wrong cylinders.
16. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
17. Faulty neutral, clutch lever, or kickstand safety switch.
18. Faulty fuel pump or fuse or relay.
19. A stuck bent or burnt valve.
20. Tilt sensor needs a reset.
21. Security system not disarming alarm needs a reset.
22. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need please click on the blue links below. Good luck and have a wonderful day.
200 EXC won start your thoughts
What to Do Check When Dirt Bike Won Start
1999 2006 KTM 125 200 Engine Workshop Repair Service Manual Download... $15 cheap
http://www.partsfish.com/page/oem-parts-for-ktm
KTM EXC 200 EXC Owner Manual

Mar 25, 2017 | 2005 KTM EXC 200 Usa

1 Answer

Problem on my ktm 450sxf 2007 model inner hub on the clutch


Your hub on the shaft - the nut is too tight. The nut is pushing the hub too far on the shaft and making it a drag. Need to back the nut off and torque it at factory spec. That could be somewhere between and 12-15 lbs. This has happened to someone else I know.

May 26, 2012 | KTM 450 SX-F Motorcycles

1 Answer

2011 ktm 530 exc ignition fuse


Should be a fuse but if not,Check the earth circuit you may have fried the wiring check for burt wires

Jan 27, 2012 | 2011 KTM 530 EXC

1 Answer

I gust bought a 2007 night rod special without a user manual. The bike would not restart after a short ride. I turned on the ignition switch, pulled in the clutch and heard an electrical pop from the...


Hi Agfanara804, call, take a ride or trailer your bike over to your local dealers service/parts department, I'm sure they will be happy to take your Harley Davidson for a test ride if necessary/possible and offer professional advice and assistance concerning your issue. Good luck have a nice day.

Aug 23, 2010 | 2008 Harley Davidson VRSCDX Night Rod...

1 Answer

Starter button began to turn over and the stopped.


Hello. Since your experiemcing an entire electrical failurte I would start by looking at your fuses. If they are all fine, then you might want to check to see if there is a short in the starter button, which seems to be the issue, but may not be. If these don't work, come back and we'll continue. I hope this helps you, and please remember to rate this fix when we are finished,

Jun 28, 2010 | 2002 Harley Davidson XL 1200 S Sportster...

1 Answer

I have a 2007 KTM 450sxf after i ride it it dies within a minute


I'd start with simple things like checking the plug and doing a few electrical tests.Some tests you may be able to do yourself like resistance checks.Compare the following spec with what you get ; Primary coil . 25~35 0hms Secondary 5050~7550 Valve clearance inlet 0.10~0.15 exuast 0.15~0.20 both cold and in mm.

Nov 27, 2009 | 2008 KTM 250 SX-F

Not finding what you are looking for?
2006 KTM 450 SX Logo

Related Topics:

384 people viewed this question

Ask a Question

Usually answered in minutes!

Top KTM Experts

kevmx2003

Level 2 Expert

86 Answers

yadayada
yadayada

Level 3 Expert

70346 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

216 Answers

Are you a KTM Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...