Question about 2004 Suzuki GSX-R 1000 Mladin Replica

2 Answers

04-5 gsxr 1000

Bike was parked up for 2 years and was going well . wen i recently started it it wont rev out rite i changed the oil , plugs and feul and its still no better can you help me please

Posted by on

2 Answers

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 8 Answers

My 04 gsxr 1000 was parked for a year and a half when i bought it. I had a ton of rust in the fuel tank. The engine is fuel injected so it needs a free flowing fuel pump to keep a constant pressure. more than likely the strainer at the bottom of the pump housing is plugged up full of rust. You will need to remove the tank from the bike and drain all the bad fuel. Unbolt the pump housing from under the tank take care not to damage the o ring. Separate the pump from the housing by pulling apart. This may take some brute force because the rust tends to stick the pump to the housing. Once separated you will see the plastic micro strainer it will be solid brown impregnated by rust. Carefuly remove it and soak it in some fresh clean gosoline. Swish it around in a glass jar with a lid on it if possible. This worked for me. The alternative is a new strainer for about 100.00 USD. Clean the rest of the pump externally with a soft bristle brush. Drain the pump as best you can. Do not attempt to disassemble the pump as it is sealed and considered maintenance free. Ventalate the tank untill completely dry and blow it out with compressed air untill no more rust dust comes out of it. At this point you can recoat the inside of the tank if you wish, there is a product called kreme for that. Im cheap so i didn't recoat mine. Reassemble, refill with high octane fuel and dont store long term without draining the fuel tank completely and run the engine til it starves itself of fuel. With all this said YOU ARE DEALING WITH FUEL BE CAREFUL, DONT BLOW YOURSELF UP!!!

Posted on Mar 14, 2009

  • Level 1:

    An expert who has achieved level 1.

    MVP:

    An expert that got 5 achievements.

    New Friend:

    An expert that has 1 follower.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Contributor
  • 41 Answers

I work on 4 wheelers, I don't mess with bikes very often, but It sounds like u have dirty carbs!!

Posted on Dec 11, 2008

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Can 1994 GSXR 1100 Fairings bolt on to a 1994 GSXR 750?


Cant see why it wont fit as I think the frames are the same onlly the engine siz is different

Aug 09, 2014 | Suzuki GSXR 600 750 1000 KEYCHAIN KEY RING...

2 Answers

What does white smoke coming from exhaust of a 01 'suzuki gsxr 1000 mean when starting only?


For motorcycles with 4-stroke engines: The white smoke from the exhaust means that the engine oil is leaking into the combustion chamber where the petrol burns. ... This eventually means that you have to get your piston changed along with the piston rings that prevent the engine oil leaking into the combustion chamber.

Mar 14, 2017 | NiceCycle Cell Phones

1 Answer

Just bought a 1993 suzuki gsxr 750. has been sitting in a garage for 2 years. we took the carbs off and cleaned them really well, changed the oil, and air filter and we added new gas. bike starts up and...


If is runs better with full choke, then the bike is lean, check for air leaks at the carb manifold, vacumn cracked hoses, non standard exhausts, perhaps the mufflers have rusted out while sitting

Apr 24, 2011 | 1993 Suzuki GSX-R 750 WP

1 Answer

GSXR shut down while riding


i had this prob a nightmare my su 1000 done this then. after a few weeks,i would park up go for a cuppa , try to start it and nothing just clicking from the switch. i disconnected the immobiliser

Jul 11, 2009 | 2003 Suzuki GSX-R 750

3 Answers

Gsxr 1000 k1 wont start lights horn etc come on f1 light flashing will not turn over as if starter not kicking in dont no how to get fault codes up can here system kicking in wen turning ignition on but...


you need to ground your starter to see if is good or if it is your solenoild check all fuses first then take a rubber handled screw driver and touch the hot to the frame or a groun if the starter spins then your solenoid is bad or a fuse but more than likley the solenoid is bad

Jun 22, 2009 | 2001 Suzuki GSX-R 1000

1 Answer

Bike will not start after motor exchange


r u seriously thinking someone on Fixya will sort this 4 u? Join up @ gixxer dot com and ask there. Should b a pretty simple solution they can walk u through.

May 14, 2009 | 2003 Suzuki GSX-R 1000

3 Answers

How fast does a Suzuki GSXR 1000 go? 2002 gsxr 1000r started fine loaded it on trailer went to town came back went to unload it and it would not start was running great turns over good lots of fuel no f1...


Most sports bikes are limited to 300km/h by the manufacturers in an effort to be responsible. Actually the ? was about the 1000 not "most sport bikes". The Suzuki gsxr1000 for 2007 is rev limited to 184 mph. U do the math to figure out kph but in the U.S. who cares about the metric numbers.

Apr 24, 2009 | 2002 Suzuki GSX-R 1000

1 Answer

Gsxr 1000 3 years old


Try draining all the old fuel out and running fresh fuel through it.Dont try to dilute it as stale fuel turns acidic and corrodes everything it is in contact with.Fuel system may require complete clean out

Dec 09, 2008 | 1994 Suzuki RF 900 R

2 Answers

3 year old gsxr 1000


have you checked the oil pressure?

Dec 08, 2008 | 1994 Suzuki RF 900 R

Not finding what you are looking for?
2004 Suzuki GSX-R 1000 Mladin Replica Logo

483 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

70347 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

Ed Nelson
Ed Nelson

Level 2 Expert

149 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...