Question about 2003 Suzuki VS 800 Intruder
Where is battery on 1993 suzuki intruder?
It (assuming it is a VS800) is in a trap door under the bike between the frame. disconnect the negative lug (left side) then the positive (right side) (this will be a small slotted screw viewable through a postage stamp sized window on the side of the battery cover) from underneath you remove the two front trap-door bolts and the cover will swing downward (be ready to support it as it swings) to add clearance have the back wheel up on a small thin board and one of equal size under the side stand for more info on suzuki intruders and boulevard series bikes check with www.intruderalert.com
Posted on Nov 10, 2008
a 6ya Mechanic can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repair professionals here in the US.
click here to Talk to a Mechanic (only for users in the US for now) and get all the help you need.
Posted on Jan 02, 2017
SOURCE: fuse box
You are sitting on the motorcycle, that's what we call right and left. Remove the left side cover, look near the middle and you will see a black rectangular box mounted sideways. It has a phillips head screw in the middle. On the end of the box that faces the front of the bike it should say FUSE (it may have dust over the words). Remove the screw and pop the plastic box off, the fuses are under there - 4 or 5 of them. This is for a 1992 1400cc suzuki intruder, but the designs haven't changed much over the years. This link might be of interest to you: http://www.allworldauto.com/recalls/NHTSA_94V036000_1993_SUZUKI_INTRUDER_recall_7381.html
Posted on Nov 10, 2008
Hi ...... Find where the battery is, under the seat or behind a side panel. Disconnect the black (negative lead usually with a 10mm spanner then disconect the red (positive) lead. The battery will be held in place with a 'rubber' strap or a bracket and depending on type of battery there may be a vent hose from the battery to the lower half of the bike, this just pulls off and remains in place until you replace the battery. Installation is reverse except you connect red (positive) first.
Let us know how you get on.
Posted on Jan 20, 2009
Your best bet is to go to a Suzuki shop and get one there. That way you know for sure you have the right battery and that it will fit your bike.
Posted on Mar 26, 2009
I know for the models till 2002 where the battery is located in front of the rear wheel.
Place the bike on her side stand
remove the negative battery lead at the left side, just below the transmission tube ( cone ) 10mm socket wrench
On the right side remove the security cap on the positive lead ( cross screwdriver ), then remove the positive lead.
The battery is hold in place with a 'floor plate'. remove both bolts of the floorplate ( on each side ) while holding the palte into place.
gently lower the plate and the battery.
I hope the 2004 model has the same assembly!
Posted on Apr 02, 2009
You need to buy a volt meter and set it on 10, or 20 v-. Start the bike and see what it says. A good charging system will show 13-14+ volts. If the meter says 11-12 volts or does not change, you have a bad stator, or rect/reg. Take to a shop to have it further tested. Chaz Moto DC
Posted on Jan 22, 2010
Tips for a great answer:
Apr 25, 2017 | 1993 Suzuki VS 1400 Intruder
Feb 10, 2017 | 1993 Suzuki VS 800 Intruder
Apr 14, 2014 | 1993 Suzuki VS 1400 Intruder
Nov 30, 2013 | 1993 Suzuki VS 800 Intruder
Aug 03, 2011 | 1993 Suzuki VS 800 Intruder
Apr 28, 2011 | 1993 Suzuki VS 1400 Intruder
Jan 22, 2011 | 1993 Suzuki VS 1400 Intruder
Jul 20, 2009 | 1993 Suzuki VS 1400 Intruder
Jan 14, 2009 | 1993 Suzuki VS 800 Intruder
687 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: