Question about 2004 Suzuki Intruder 400

2 Answers

Change the battery

How to change the battery suzuki intruder?

Posted by on

2 Answers

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

I had to take the riders leftside exhaust off to drop the cradle and put the bike on blocks for clearance to remove battery.
i think the designer forgot he had to put a battery on the bike,you couldnt find a most ridiculous place if you tried.
WELL DONE SUZUKI

Posted on Mar 15, 2009

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Master
  • 2,336 Answers

Th battey on these suck! It is located underneathe the bike in the center. There is 1 bolt on each side you need to take off. Then while holding the cover whicj is on a hinge, open it slowly and the battery should come straight down. ( Hint,,, I pull my back tire on a 2 x 6 to raise the bike up a little. ) now you can access the battery cable bolts. Take then both out being carful not to short the red/positve against anything when moving the battery around trying to get to the bolts. Assemle the same way.

Posted on Nov 10, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Suzuki Intruder 800 cuts out in 4th gear


have you got a digital gear position clock on the bike

Mar 12, 2013 | Motorcycles

1 Answer

Problem with 800cc suzuki intruder 2002 2002 suzuki intruder 800cc amonth ago i changed all fuilds and brakes also plugs and filter brike ran really good yesterday a couple buddies wanted to go riding


when i shut off my 2002 suzuki motorcyle it run perfect then went to start i and have no power battery good have no light on dash no head light brrake light everything is dead what could be wrong can you help with a idea thank you dave

Mar 26, 2012 | Suzuki Motorcycles

1 Answer

How to access the battery on a 2001 Suzuki Intruder Volusia 800


Remove the seat to access the battery.

1st, remove the passenger pillion seat.
2nd, remove the driver seat

May 13, 2010 | 1995 Suzuki VS 800 Intruder

1 Answer

Suzuki intruder 1500 charging system


You need to buy a volt meter and set it on 10, or 20 v-. Start the bike and see what it says. A good charging system will show 13-14+ volts. If the meter says 11-12 volts or does not change, you have a bad stator, or rect/reg. Take to a shop to have it further tested. Chaz Moto DC

Jan 22, 2010 | 2000 Suzuki VL 1500 Intruder LC

2 Answers

Battery Removal


It is not under the seat! It is under the engine,and it is kinda a pain in the *** to get to..altho,most batteries on bikes are located under the seat,the suzuki intruder is not!

Apr 03, 2009 | 1992 Suzuki VS 800 Intruder

2 Answers

What battery fits 1995 suzuki intruder 400cc ***


Your best bet is to go to a Suzuki shop and get one there. That way you know for sure you have the right battery and that it will fit your bike.

Mar 26, 2009 | 2004 Suzuki Intruder 400

1 Answer

Battery removel for a 2004 suzuki 800 intruder


the battery is under the bike, bottom of box hinges down, just in front of rear wheel.
pain in the ***
some recomend parking bike wheels and kickstand on board for better access.

Jan 20, 2009 | 2004 Suzuki VS 800 Intruder

1 Answer

Battery location for a 2004 suzuki intruder 800


Hi ...... Find where the battery is, under the seat or behind a side panel. Disconnect the black (negative lead usually with a 10mm spanner then disconect the red (positive) lead. The battery will be held in place with a 'rubber' strap or a bracket and depending on type of battery there may be a vent hose from the battery to the lower half of the bike, this just pulls off and remains in place until you replace the battery. Installation is reverse except you connect red (positive) first.
Let us know how you get on.

Jan 19, 2009 | 2004 Suzuki VS 800 Intruder

Not finding what you are looking for?
2004 Suzuki Intruder 400 Logo

Related Topics:

339 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

60769 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

4471 Answers

Ed Nelson
Ed Nelson

Level 2 Expert

149 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...