Question about kawasaki KLX 110 Motorcycles

Open Question

2005 klx 110 wont idle without the choke fully on

Wont idle with the choke off

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 2336 Answers

SOURCE: oil capacity

1.1 liters it says this on the block on the right side of the engine

Posted on Nov 10, 2008

  • 2336 Answers

SOURCE: choke on

Sounds like your idle jet is clogged. This is caused by gasoline evaporating out of the carburator during long periods of disuse which can leave a varnish residue. You will probably need to remove the float bowl and remove the jet to clear it as carb cleaning additives in the gasoline are usually useless for this problem. It is vital that you use the exact fit screw driver on float bowl screws as they are usually very tight. The jet will have a very small opening and you could damage the jet if you use the wrong method to clean it (do not use a drill bit). First try a carburator cleaner spray with the small plastic straw that comes with them. Look thru the jet hole by holding it up to a strong light to see that it is indeed clogged. Then try holding the small straw in the jet orifice and forcing the cleaner into and through the jet. Be careful that you don't deflect the spray back into your eyes. Use eye protection. You could try to soak the jet in a cap full off the cleaner for a while. If that doesn't work a very small stiff wire might work to push the clog out (from a wire brush?). Then try the spray method again.

Posted on Nov 10, 2008

  • 65 Answers

SOURCE: wont shift into neutral

I had a street bike that did that. It can be a few things. First Chang the oil and use whatever is recomened by the manufacture. other oils can make this worse. then if it still is there try adjusting the clutch plate interference you may need a manual for this one. after that it's probably a worn linkage or fork see a shop or a good manual fo radvice on your model. hope this helps

Posted on Jun 27, 2009

DoubleClutch
  • 376 Answers

SOURCE: Will not run without the choke open

You got something wrong with the injectors or in the computor.

Posted on Oct 04, 2009

  • 2 Answers

SOURCE: 2004 klx 125l bike ideling

How long has the bike been sitting? The gas may be bad or the carb might need to be cleaned out or choke may be sticking.

Posted on Feb 06, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Wont idle without choke being used


Main jet dirty. Likely Ethanol fuel fouling. Remove and clean jet. Check all rubber tubing to/from carb for cracks/deterioration and replace.

Nov 24, 2013 | Yamaha 2004 Bruin 350 Auto 4x4

1 Answer

KLX 110 not getting enough spark i think to burn the fuel


Hi, Jason and the usual suspects are:
1. Severely discharged or a damaged battery, should have 12.5 volts or better and be able to pass a "LOAD" test if necessary, your battery may show 12.5 volts but have little or zero amps and needs to be replaced.
2. Failed alternator/generator and or voltage regulator.
3. Loose or corroded battery terminals and or cables especially the "NEGATIVE" cable, look for loose, corroded, or broken connectors inside the cable harness at "BOTH" ends.
4. Failed main circuit breaker or ignition switch, check for loose connections and continuity.
5. Failed system and or ignition relay, check for continuity.
6. Failed ignition coil, stator, magneto, points/condenser ignition/electronic module.
7. Failed CKP, CPS, CMP, MAP, TPS, or BAS sensor, corroded, loose or broken wire connector pins/sockets.
8. Throttle cables and or idle speed improperly adjusted hot idle speed should be 950 RPM to 1000 RPM.
9. Air/fuel mixture screw improperly adjusted.
10. Accelerator pump damaged or not working.
11. Water or dirt in the fuel system, carburetor or filter.
12. Restricted, blocked or kinked fuel line.
13. Fuel tank empty.
14. Fuel tank contaminated with ethanol sludge.
15. The gas cap is not venting properly or fuel tank venting system blocked.
16. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
17. Needle and seat stuck closed in the float bowl.
For more information about your issue and valuable "FREE" downloads that you need please click on the blue links below. Good luck and have a wonderful day.
http://www.miniriders.com/ask-the-tech-masters-/33469-klx-110-wont-start.html
05 KLX 110 Wont Start
Kawasaki KLX110 Service Manual
OEM Parts for Kawasaki
Kawasaki KLX110 Owner Manual

Apr 06, 2017 | 2005 kawasaki KLX 110

1 Answer

Bought an 07 klx 250 and noticed that the snorkel for the air box is missing. Could this be causing erratic idling. Once the choke is pushed in it idles erraticaly


It is possible. The jets are designed for a specific amount of air flow. Without the snorkel, you may be getting too much air.

Mar 10, 2011 | 2007 kawasaki KLX 250

1 Answer

What kind of spark plug does a klx 110 have?


The KLX 110 will work with an NGK CR6HSA spark plug

Mar 09, 2011 | 2005 kawasaki KLX 110

1 Answer

KLX 100 will stay running with choke fully in


have you checked the fule flow from the fule tank?
you may need to strip the carb down to give it a realy good clean out too this bike is just not getting any fule to it

Jul 06, 2010 | 2007 kawasaki KLX 250

1 Answer

2005 tt r 125 wont idle without choke, fuel


floats out of adjustment remove the bowl check float reset if adjustable or replace

May 09, 2010 | Yamaha TT-R 125 Motorcycles

1 Answer

Won't idle without choke, turn throttle boggs out


have u checked the float hight on the carburator? also make sure ur choke curcuit i clean and free of dirt

Apr 13, 2010 | 2005 kawasaki KLX 125

1 Answer

2004 klx 125l bike ideling


How long has the bike been sitting? The gas may be bad or the carb might need to be cleaned out or choke may be sticking.

Feb 06, 2010 | 2004 kawasaki KLX 125

1 Answer

My KLX 125 2004 will turn over but wont idle


Might check: Air filter, choke malfuntion or sticking, dirty carb (idle circuit), valve adjustment, and sometimes a weak spark (cap, plug, wire). Could need a new top end (check compression after adjusting valves) or a vacuum leak in the intake manifold (cracks, petcock line off...not sure if this model uses a petcock vacuum shut off). Good luck.

Jun 25, 2009 | 2004 kawasaki KLX 125

1 Answer

Klx 110 2006 stalls when choke is pushed in


i'd say the carb is gummed up especially the pilot jet (#16158) in this pic of the USA carb. may have to remove the carb & bowl and then remove the pilot jet (w/ flat head screw driver) and clean out the tiny holes.

http://partsfinder.onlinemicrofiche.com/atlanticcycleandpower/Kawasaki_OEM/KawasakiDB.asp?Type=18&A=39&B=17&Action=O

-OR-

the carb slide is installed backwards (turned 180 degrees). its #16025 in the pic. i've done this before on my daughter's XR70 and Z50. you'll know if its this when you move the choke lever, RPMs increase and decrease.

hope this worked for you and was fast enough.

Feb 06, 2009 | 2006 kawasaki KLX 110

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

75 people viewed this question

Ask a Question

Usually answered in minutes!

Top kawasaki Experts

Arnie Burke
Arnie Burke

Level 3 Expert

4514 Answers

yadayada
yadayada

Level 3 Expert

75051 Answers

Gino Cussen
Gino Cussen

Level 2 Expert

216 Answers

Are you a kawasaki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...