Question about Isuzu Pickup

1 Answer

I have an Isuzu diesel 1986 It starts easily but cuts out after 10-15mins. and I have to bleed the system to get it started again. There is fuel and the filters have been changed.

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 836 Answers

There's a leak in the fuel system somewhere. As it's an older model, it could be a corroded steel line, or a degraded seal or hose. If there' any sign of fuel at any pojnt on those, check there first.

Posted on May 19, 2011

  • Bruce Carter Nov 13, 2011

    Check you have a consistant 12Volts at the fuel shut off solenoid, bad earths is a common fault with Rodeos also

×

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

My isuzu trooper won't start after running out ov diesel changed filter still won't start what else can I do


You need to fill the fuel filter before installing it then you need to bleed the entire fuel system of air. There should be bleed screws and a hand pump to do this.

Dec 07, 2015 | Isuzu Trooper Cars & Trucks

1 Answer

How do you bleed the diesel fuel filter on a 1986 Toyota diesel Land Crusier?


I don't know a lot about these trucks but I can tell you that somewhere between the spin-on fuel filter and the I.P. (injection pump) is a 1.5" dia X 4" long steel primer. Just under the top of it is a spring. You will need to loosen or open the "Fuel supply line", at the I.P. (going from the filter, to the pump) and manually pump the fuel primer. Continue pumping the fuel primer until diesel flow from the opening. Quickly close off the drain-port or fuel-line, pump the primer a few more times (to increase line pressure and try to start your vehicle. After it starts, check for leaks. Let me know if I can help anymore. Good luck.

Mar 06, 2014 | Cars & Trucks

1 Answer

Hi, Our ISUZU 280 KB doesn't get diesel through..if you start the bakkie it initially starts but the engine quickly dies even if you floor the accellerator. If you press the "manual diesel pump"


Blockclogs easily if you get some water in the diesel.age in fuel system. Remove both pipes from tank to pump and blow. If clogged replace. Also check fuel filter. That thing

Dec 03, 2012 | Cars & Trucks

1 Answer

1991 isuzu npr prime fuel system


normally the primer is on the filtre and bleed screw there too
what i normally do is fill the fuel filtre with clean diesol and fit and then prime if you r have=ing real difficulty you could open pipes going to injectors and turn over ttill you see the diesol coming from pipes ,but normally just prime it it should start

Nov 01, 2012 | Cars & Trucks

1 Answer

My 1981 isuzu pup Diesel won't statrt it was running fine but one day did not start,,,, checked if spark plugs had electricity and it has/ don't know what to check or do to start it back on


??diesel with spark plugs??? check you ate getting fuel desels don't have spark pluge the fire of compresion they might have glow plugs but I think if it is a gas engen with spark plugs and you put disel in it there is your problem

Oct 24, 2010 | 1986 Isuzu Pickup

1 Answer

1986 FORD F 350 DIESEL 6.9 REPLACED INJECTOR PUMP AND STILL DOSENT GET FUEL ALSO WHEN IT DOSE START THE IDLE IS AT 3000


check to see that your mechanical fuel pump is working on the lower right side of the engine. VERY problematic pump due to design and location. Have you replaced your fuel filter with the injector pump swap? cause you need to do that , its a must If your getting fuel to your injector pump you have to bleed the lines to each cylinder to bleed out the air in the system. If that all checks out then you need to set the timing to 8 deg using a timing light and a diesel injection pulse width adapter timing tool. purchase a haynes manuel for 6.9l/7.3l diesel engines to follow the correct procedure for setting timing to manufactures spec. You will have to disconnect sensor at certain times during the timing stage so make sure it is done right!
PS - I hope you marked a reference line on the pump to line up with the line on the housing cause that will get you close to start! good luck

Apr 07, 2010 | 1986 Ford F 350

2 Answers

Ran out of Diesel, now 'injector fault' light on. '05 Modus


there is air in the fuel line causing the fuel not get to the injectors. you will have to open the fuel ine AT the injectors to bleed out the air while someone turns the key as if starting the car.

Aug 11, 2009 | 1986 Renault Sport

2 Answers

My 206 1.9 diesel wont start


a diesel engine can only cutout when overheating, loss of diesel fuel and air leak in the fuel system. if you know how to bleed or ask somebody to bleed right after it stall, then start the car, if it starts immediately then it is sucking air.

May 09, 2009 | 2006 Peugeot 505

4 Answers

Isuzu 4JX1 EngineWont Start after replacing new injector


my isuzu bighorn will not start after changing valve seals and head gasket and after setting timing it still will not start. do you have a solution.

Aug 09, 2008 | 1999 Isuzu Trooper

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

140 people viewed this question

Ask a Question

Usually answered in minutes!

Top Isuzu Experts

yadayada
yadayada

Level 3 Expert

75817 Answers

Steve Hurc
Steve Hurc

Level 3 Expert

450 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Are you an Isuzu Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...