Question about 2000 Chevrolet Blazer
It usally a good idea to replace the straps holding the tank in. as well as changing the fuel filter. since you are already under there.
Posted on Apr 06, 2011
You should not need any additional parts unless something breaks. Might be a good idea to see about getting a seal for the fuel pump if you intend on putting the one you have in the new tank.
Posted on Apr 06, 2011
a 6ya Mechanic can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repair professionals here in the US.
click here to Talk to a Mechanic (only for users in the US for now) and get all the help you need.
Posted on Jan 02, 2017
It is mounted on the RH inner fender under the hood. It's a black metal box with fins on it and a few large wiring harnesses going into it. You MUST have the battery disconnected when you hook the new one. Good luck
Posted on Jan 03, 2009
SOURCE: 95 chevy blazer tank removal
Park the vehicle in a place where you’ll have plenty of room to work. If you have access to a lift, that would be great.
Relieve any fuel pressure by removing the fuel cap. Disconnect the negative battery terminal. Pre soaking any required bolts/nuts with WD-40 prior to the job will help also. There are 3 lines and 2 electrical connectors to be removed from the fuel pump, and the filler and vent hoses that need to be removed from the back of the tank. There was also a small hose on the front part of the tank that needs to be removed, but we didn’t see it until we actually started lowering the tank. Just remember where everything hooks back up. Label the lines, if needed take picture with your cell phone.
Start by removing the skid plate, Once the skid plate is off, you’ll have access to the straps that hold the fuel tank on. The forward ******** the Blazer will pretty be rusted and not very stout. It's basically formed as a strap that ended in a threaded bolt and in most will end up breaking trying to remove it. Supported the tank with a floor jack with a transmission removal assembly on it.
You easily fixed the broken strap problem by welding a bolt to the strap. Once all the straps were loose, lower the tank just enough to get better access to the lines and connectors leading to the fuel pump. There is not much room to get in there on a Blazer.
Once the tank is off, it’s a good time to look around in that area to see if there are any other problems that may need to be addressed.
If you are going to replace the fuel pump here's how to do it. Before removing the fuel pump, be sure to clean off all the junk that has collected around it.
Replacing the float and sending unit is fairly simple. Just pay attention to how the old parts are removed, and install the new parts in reverse order. Be sure to get the wiring routed correctly and install the new seal that comes with the kit. The sock filter on the bottom of the pump was just a little bit clogged, so we made a trip to the auto parts store to get a new one. Luckily they had one that would match up.
While we had the tank off, siphoned what fuel was in there and cleaned out the tank really well.
The installation is basically just a reverse of the removal. Be prepared to take quite a bit of time for this project. It took much longer that I expected. Somewhere around 6-7 hours, but that’s including several little problems, getting propane for BBQ lunch, and making a trip to the parts store for a new sock filter for the bottom of the pump. And Mom and dad showing up.
Good luck and hope this help
Posted on May 26, 2009
there is a vapour purge line from the tank to a charcoal cannister. The line& cannister has been contaminated with liquid gas. When the engine attempts a normal purge from cannister it gets loaded with raw gas, causing rough running and cherck engine light. Replace cannister. Never over fill gas tank, especially on hot sunny days
Posted on Jun 06, 2009
Tips for a great answer:
Feb 17, 2012 | 2000 Chevrolet Blazer
Apr 04, 2011 | 2000 Chevrolet Blazer
Nov 04, 2010 | 1999 Chevrolet Blazer
Jul 27, 2010 | 2000 Chevrolet Blazer
Jun 01, 2010 | 2000 Chevrolet Blazer
Feb 13, 2010 | 2000 Chevrolet Blazer
Jun 03, 2009 | 2002 Chevrolet Blazer
Jun 02, 2009 | 2001 Chevrolet Blazer
Mar 13, 2009 | 2000 Chevrolet Blazer
99 people viewed this question
Usually answered in minutes!