Question about 2004 Volvo S60

2 Answers

I have a 2002 S60 with over 130,000 km. Lately, the message, 'engine system services required', comes out ocassionally. Checked oil and other fluids and they were ok. donot find anything unusual while driving. What should be my course of Action? Thanks. CP

Posted by on

  • cplee Apr 05, 2011

    No, the engine light was not on.



    CP

  • cplee Apr 06, 2011

    What is PCM and how do I scan it?

×

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Volvo Master
  • 17,970 Answers

You need to have the codes pulled to find out where the problem is. Could sound like the engine control module has detected a fault with the Electronic Throttle System in the vehicle. Other fuel system related faults can also trigger that message. Scanned the PCM and tell us if some code is stored there.

Posted on Apr 06, 2011

  • ZJ Limited
    ZJ Limited Apr 06, 2011

    The message "Engine System Service Required" is not a maintenance
    reminder and the trip button is not the procedure to reset it. The
    only message that can be reset with the trip button is the service
    reminder ("Service" light on some models, "Time for Regular Maintenance
    " message on others).

    According with the Owners Manual...

    Message / Meaning:
    STOP SAFELY / Stop and switch off the engine - to help prevent serious risk of damage.
    STOP ENGINE / Stop and switch off the engine - to help prevent serious risk of damage.
    SERVICE URGENT / Take your car to an authorized Volvo retailer for inspection as soon as possible.
    SEE MANUAL / Refer to your owner's manual. For additional information, please contact your Volvo retailer.
    SERVICE REQUIRED / Take your car to an authorized Volvo retailer for inspection at your convenience (but preferably before the next scheduled maintenance service).
    FIX NEXT SERVICE / Have the system affected inspected at the next scheduled maintenance service.
    TIME FOR REGULAR SERVICE / This light will come on at 7,500 mile (12,000 km) intervals, after 750 hours of driving or after 12 months, whichever occurs first, to remind the driver that the service interval has been exceeded. The light will stay on for 2 minutes after start until reset by the servicing retailer.

    Keep us updated.

  • ZJ Limited
    ZJ Limited Apr 07, 2011

    PCM is the Powertrain Control Module (computer car); to know the fault codes stored there need use one scanner reader for OBD code (On Board Diagnostic); sometimes in Autozone or AutoShop can scanned for free.

×

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Master
  • 10,515 Answers

Hi,

Do you see check engine light being ON?

Let me know,so that we could proceed.

Hope i helped you.

Thanks for using ' Fixya ' and have a nice day!!

Posted on Apr 05, 2011

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

What services does Kia Sportage 2008 with 90000 need?


Here is recommended maintenance up to 10 1/2 yrs. If you follow through list, you should be able to tell by elimination what you may need. Here is the link - also list pasted below, here:

http://www.kia-forums.com/2g-2006-2010-rio-rio5/35574-maintenance-schedule.html


SUGGESTED Maintenance Schedule:

Months Kilometres Maintenance Type

4 months 6 000 km Maintenance #1
8 months 16 000 km Maintenance #2
12 months 24 000 km Maintenance #1
16 months 32 000 km Maintenance #3
20 months 40 000 km Maintenance #1
24 months 48 000 km Maintenance #2
28 months 56 000 km Maintenance #1
32 months 64 000 km Maintenance #3
36 months 72 000 km Maintenance #1
40 months 80 000 km Maintenance #2
44 months 88 000 km Maintenance #1
48 months 96 000 km Maintenance #3
52 months 104 000 km Maintenance #1
56 months 112 000 km Maintenance #2
60 months 120 000 km Maintenance #1
64 months 128 000 km Maintenance #3
68 months 136 000 km Maintenance #1
72 months 144 000 km Maintenance #2
76 months 152 000 km Maintenance #1
80 months 160 000 km Maintenance #3
84 months 168 000 km Maintenance #1
88 months 176 000 km Maintenance #2
92 months 184 000 km Maintenance #1
96 months 192 000 km Maintenance #3
100 months 200 000 km Maintenance #1
104 months 208 000 km Maintenance #2
108 months 216 000 km Maintenance #1
112 months 224 000 km Maintenance #3
116 months 232 000 km Maintenance #1
120 months 240 000 km Maintenance #2
124 months 248 000 km Maintenance #1
128 months 256 000 km Maintenance #3


MAINTENANCE #1

MAINTENANCE #1 INCLUDES:

Replace engine oil and filter
Check fluid levels (pwr. strg., brake/clutch, coolant, washer)
Check tire condition and pressure (including spare)
Check exterior & interior lights for proper operation
Check windshield washer/wiper function
Check horn function
Check handbrake function/freeplay
Lubricate all latches, hinges and locks

* = if equipped
See "Model-Specific Maintenance"


MAINTENANCE #2

MAINTENANCE #2 INCLUDES:

Replace engine oil and filter
Check fluid levels (pwr. strg., brake/clutch, coolant, washer)
Check tire condition and pressure (including spare)
Check exterior & interior lights for proper operation
Check windshield washer/wiper function
Check horn function
Check handbrake function/freeplay
Lubricate all latches, hinges and locks
Check engine coolant specific gravity
Check engine air filter; knock out dirt/bugs, replace as req'd
Remove wheels and brake drums, check pad/shoe thickness; inspect calipers, cylinders and shoes for proper function, leaks or damage; adjust rear brakes as required.
Rotate tires
Visually check underbody fasteners for condition & integrity
Check brake/clutch pedal freeplay
Check steering wheel components for proper operation
Check CV boots/tie rods/ball joint boots (visual inspection)
Check all seat belts and anchor integrity
Check exhaust sys. for leaks, mountings, brackets; heat shield
Check transfer case oil level & condition, fill as required
Check front & rear differential fluid, fill as required*
Check man. transaxle oil level & condition, fill as required*
Check auto transaxle fluid level & condition, fill as required*
Lubricate driveshaft u-joints (early Sportage only)
Road test vehicle

* = if equipped
See "Model-Specific Maintenance"


MAINTENANCE #3

MAINTENANCE #3 INCLUDES:

Replace engine oil and filter
Check fluid levels (pwr. strg., brake/clutch, coolant, washer)
Check tire condition and pressure (including spare)
Check exterior & interior lights for proper operation
Check windshield washer/wiper function
Check horn function
Check handbrake function/freeplay
Lubricate all latches, hinges and locks
Check coolant specific gravity
Check engine air filter; knock out dirt/bugs, replace as req'd
Inspect, deglaze, clean, adjust & lubricate brake components
Rotate tires
Visually check underbody fasteners for condition & integrity
Check brake/clutch pedal freeplay
Check steering wheel components for proper operation
Check CV boots/tie rods/ball joint boots (visual inspection)
Check all seat belts and anchor integrity
Check exhaust sys. for leaks, mountings, brackets; heat shield
Check transfer case oil level & condition, fill as required*
Check front & rear differential fluid, fill as required*
Check man. transaxle oil level & condition, fill as required*
Check auto transaxle fluid level & condition, fill as required*
Check idle speed
Inspect power steering lines & hoses (visual)
Check A/C compressor operation and performance*
Check brake line fittings, bleeder screws, booster for damage, looseness, leaks
Road test vehicle

* = if equipped
See "Model-Specific Maintenance"


KIA MODEL-SPECIFIC MAINTENANCE

In addition to the KIA Basic Scheduled Maintenance, certain KIA Models will require the following maintenance services:

ALL MODELS

(Every 36,000 km or 18 months)

Manual transaxle service (except Sportage)
Automatic transaxle service (except Magentis)
Check drive belt condition & tension
Inspect front ball joints

ALL MODELS
(Every 48,000 km or 24 months)
Replace engine coolant
Replace engine air filter
Inspect fuel lines & connections
Inspect ignition wires
Replace spark plugs (except Platinum)

ALL MODELS
(Every 60,000 km or 30 months)
Replace brake/clutch fluid
Inspect EVAP canister & vapour lines

ALL MODELS
(Every 72,000 km or 36 months)
Replace fuel filter
Inspect PVC system/hoses for integrity

ALL MODELS
(Every 96,000 km or 48 months)
Replace spark plugs (Platinum)

ALL MODELS
(Every 102,000 km)
Replace timing belt

SPECTRA
(Every 12,000 km or 6 months)
Replace HVAC air quality filter (if equipped)

MAGENTIS
(Every 12,000 km or 6 months)
Replace HVAC air quality filter (if equipped)

(Every 60,000 km or 30 months)
Automatic transaxle service

SPORTAGE
(Every 36,000 km or 18 months)
Transfer case, differential & manual transaxle service
Transfer case & differential service (auto. trans. model)

SORENTO
(Every 36,000 km or 18 months)
Transfer case & differential service

Jul 16, 2014 | Kia Sportage Cars & Trucks

Tip

Ford-Lincoln service light 1988-01


LS

2000-01

To reset CHANGE OIL SOON/OIL CHANGE REQUIRED message on the Message Center, press the STATUS control to access the System Check mode. Press the RESET button to display OIL LIFE _% RESET FOR NEW. Press and hold the RESET button until OIL LIFE IS 100% is displayed.


Mark VIII


1993-97

When "CHANGE OIL SOON" or "OIL CHANGE REQUIRED" is displayed on the Message Center, turn the ignition on. Press and hold "OIL CHANGE RESET' or the "RESET" button until "OIL LIFE RESET TO 100%" is displayed on the Message Center.


Continental


1989-94

When "SERVICE" is illuminated, on the Message Center, press the "SYSTEM CHECK" button on the right of the display. Then press the "RESET" button. The "SERVICE" symbol and mileage will start to flash. Next, press the "SYSTEM CHECK" and "RESET" buttons at the same time. The display will show "7,200 miles/11,580 km" and will count down from there as long as the buttons are depressed. Release the buttons at the desired service interval.


Continental


1988

When "SERVICE DUE" is illuminated on the Message Center, press the "CHECK OUT" button located below the display. Then press the "RESET" button. The display should now read "SERVICE DONE?" Next, press the "CHECK OUT" button and "RESET" buttons at the same time. The display will show "7,200 miles/11,580 km" and will count down from there as long as the buttons are depressed. Release the buttons at the desired service interval.







on Dec 07, 2009 | Ford Lincoln Continental Cars & Trucks

2 Answers

My 2002 Camry is starting to idle so low that it dies ocassionally


Your car probably requires a comprehensive engine tune up.
During engine tune up mostly three areas are addressed:
1. Restoring the cylinder compression.
This system requires the adjustment of valve tappet clearance at operating temperature.
Inlet=0.25mm-0.30mm, Exhaust=0.25mm-0.35mm)
2. Servicing the air and fuel system.
Servicing and inspecting the throttle body, ISC (Idle speed control valve), element air cleaner and MAF ( mass air flow sensor)
Fuel pump pressure approx. 38psi - 44psi.
3. Servicing the ignition system.
Inspecting and/or replacing/adjusting the spark plugs gaps(0.9mm-1.1mm), igniters (visual inspection)
Regards,
Shadab Lodhi

Feb 03, 2013 | 2002 Toyota Camry

1 Answer

Honda ridgeline b6


From Owner's Link:

Maintenance Minder B Scheduled Maintenance
Recommended service for your 2006 Honda Ridgeline:

Replace engine oil and oil filter
Rotate tires
Inspect front and rear brakes
Check parking brake adjustment
Inspect tie rod ends, steering gear box, and boots
Inspect suspension components
Inspect driveshaft boots
Inspect brake hoses and lines (including ABS)
Inspect all fluid levels and condition of fluids
Inspect exhaust system#
Inspect fuel lines and connections#

Adjust the valves during services A, B, 1, 2, or 3 if they are noisy.

Maintenance Minder 6 Scheduled Maintenance
Recommended service for your 2006 Honda Ridgeline:

Replace VTM-4 rear differential fluid: Driving in mountainous areas at very low vehicle speeds or trailer towing results in higher level of mechanical (shear) stress to fluid or frequently fully loaded. This requires differential fluid changes more frequently than recommended by the Maintenance Minder. If you regularly drive your vehicle under these conditions, have the differential fluid changed at 7,500 miles (12,000 km), then every 15,000 miles (24,000 km).

Oct 31, 2012 | Honda Cars & Trucks

3 Answers

How do you reset the oil change required after oil change on a 2007 ford explorer sport trac limited?


Depending on your cluster its one of these...


Message Center Configuration
Oil Life Reset - Message Center Cluster

NOTE: The oil life calculation is set at a maximum of approximately 8,000 km (5,000 miles) or 180 days

  1. Press and release the SETUP button until the message center displays PRESS RESET TO BEGIN SYSTEM CHECK.
  2. Press and release the RESET button until the message center displays HOLD RESET IF NEW OIL.
  3. Press and hold the RESET button for 2 seconds and release to reset the oil life to 100%.
  4. The message center displays SETUP MENU HOLD RESET.
Oil Life Reset - Base Instrument Cluster

NOTE: The oil life calculation is set at a maximum of approximately 8,000 km (5,000 miles) or 180 days.

  1. Place the ignition in the RUN position with the engine off (KOEO).
  2. Press and release the TRIP/RESET button until SETUP MENU HOLD RESET is displayed.
  3. Press and hold the TRIP/RESET button until SYSTEM CHECK is displayed.
  4. Release the TRIP/RESET button.
  5. Press and release the TRIP/RESET button to scroll through the system check menu items until HOLD RESET IF NEW OIL is displayed.
  6. Press and hold the TRIP/RESET button until OIL LIFE SET TO 100% is displayed.
  7. Release the TRIP/RESET button. The oil life is now reset.
Oil Life Start Value - Message Center Cluster

NOTE: The oil life start value is used to reset the oil life value back to the maximum of approximately 8,000 km (5,000 miles) if the value was previously changed or to lower the value from the maximum (8,000 km
To reset the oil monitoring system to 100% after each oil change [approximately 5,000 miles (8,000 km) or 180 days] perform the following:
  1. Enter SYSTEM CHECK to display "OIL XXX% OIL LIFE OK".
  2. Press RESET control to display "HOLD RESET IF NEW OIL".
  3. Press and hold RESET control for more than 2 seconds. Oil life is set to 100% and "OIL CHANGE SET TO 100%" is displayed

Mar 06, 2011 | 2007 Ford Explorer Sport Trac

1 Answer

What is oil change schedule for 2007 DTS also transmission fluid change schedule


Your vehicle's engine requires oil meeting GM Standard GM6094M. You should look for and use only an oil that meets GM Standard GM6094M. SAE 5W-30 is best for your vehicle.
The best Brand is 5W-30, Mobile 1 synthetic oil, but you can use Castrol GTX 5W-30, too. It is very important to use only one barand of engine oil.
When the CHANGE ENGINE OIL SOON message in the Driver Information Center (DIC) comes on,
means that an oil change service is required for your vehicle.
If the engine oil life system is ever reset accidentally, you must service an oil change for your vehicle within 3,000 miles (5 000 km), or three months wichever comes first, since your last service.
The maintenace tune ups for this car are scheduled at 25K, 50K, 75K, 100K and so on.
Dealer recomend to change the transmission oil and filter at Maintenace II, at 50K, and the air filter too. Use only DEXRON®-VI Automatic Transmission Fluid.
The dealer sugest to flush the radiator every 75K and use 50/50 mixture with distilled water, and use only DEX-COOL. I recommend to flush every 50K.

Oct 25, 2010 | 2007 Cadillac DTS Sedan

1 Answer

I want to know a list of all the materials required to service my 1996 C180 for the best performance


engine oil MOBIL 1 5W-50 fully synthetic, engine oil filter must get from dealer genuine filter for it, if your car over 80.000 km must replace spark plugs and fuel filter, if your car over 65.000 km or after last transmission service have driven another 65.000 km it's due for transmission now, transmission filter oil and oil pan gasket must get from dealer, may be need for air filter and pollen filter, it's depend on condition of filters, must check wheel bearings and brake pads and brake disc, and also be need brake fluid, if brake fluid older than two years, and normal basic check,

Oct 20, 2010 | 1996 Mercedes-Benz C-Class

1 Answer

Tundra 2007 - turn off "maintenance required" light


Oil Change Reminder Lamp: Service and Repair
Engine Oil Replacement Reminder Light
This light acts as a reminder to replace the engine oil.
This light will come on when the ignition key is turned to "ON" and will go off after about a few seconds.
When you drive for about 7200 km (4500 miles) after the engine oil replacement, this light illuminates for about 3 seconds and then flashes for about
12 seconds with the ignition key turned to the "ON" position. If you continue driving without replacing the engine oil, and if the distance driven
exceeds 8000 km(5000 miles), the light will come on. The light will remain on thereafter.
If the light is flashing, we recommend that you replace the engine oil at an early opportunity depending on the driving and road conditions. If the light
comes on, replace it as soon as possible.
Resetting the system
The system must be reset after the engine oil replacement. Reset the system by the following procedure:
1. Turn the ignition key to the "OFF" position with the odometer reading shown.
2. Turn the ignition key to the "ON" position while holding down the "TRIP METER" reset button.
Hold down the knob for atleast 5 seconds. The odometer indicates "000000" and the light goes off.
If the system fails to reset, the light will continue flashing.

Sep 30, 2009 | Toyota Cars & Trucks

2 Answers

2002 Suburban needs tune up....


Inspect Brakes and Traction Control Evaporative Emissions System (E) Inspect all the fuel and vapor lines and the hoses for proper hook-up, routing and condition. Ensure that the purge valve works properly, if equipped. Replace the components as needed. Exhaust Gas Recirculation (E) Fluid - Differential Inspect front/rear axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. Lubricate Steering and Suspension Lubricate the front suspension, ball joints, steering linkage, transmission shift linkage, transfer case shift linkage, parking brake cable guides, and brake front axle. Ball joints should not be lubricated unless their temperature is -12 degrees C (10 degrees F) or higher or they could be damaged. Replace Air Filter Element (E) Engine Oil (E) Change engine oil and filter as indicated by the GM Oil Life System (or every 12 months, whatever occurs first). Reset the indicator. Never drive the vehicle more than 16 000 km (10,000 miles) without and oil and filter change. The system will not detect dust in the oil. If the vehicle is driven in a dusty area, be sure to change the oil every 5 000 km (3,000 miles) or sooner. Fuel Filter (E) Oil Filter, Engine Rotate Tires

Nov 04, 2008 | 2002 Chevrolet Suburban

1 Answer

Pajero


No, timing chains are not expected to be replaced periodically like belts. Ocassionally they get noisey at high mileages and require a new tensioner pad but usually the chain is OK with a new pad

Jun 27, 2008 | 2002 Mitsubishi Montero

Not finding what you are looking for?
2004 Volvo S60 Logo

Related Topics:

83 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volvo Experts

yadayada
yadayada

Level 3 Expert

75077 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7768 Answers

Are you a Volvo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...