Question about 1994 Chevrolet G20

1 Answer

I have a 1994 g20 chevy van 5.7 and i lost my power windows,speedometer,shifting of the transmission,radio,the fan to blow cold or hot air all at the same time. all my fuses are good and the headlights,power locks and other gauges work as well as engine starts can someone help me troubleshoot this problem

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Well everything but shifting of the transmission points to an electrical problem. What does it do when you try to shift it?

How did you know the fuses are good, did you check resistance?
For the electrical problem you need a voltage meter (voltmeter) or multimeter set to volts DC. Probe, with the fuse out, between ground (chassis steel) and where the fuse was pluged in. One side should show +12VDC, the other will be nothing. If you get the +12VDC, good. If not, there is a problem behind your fuse panel and you'll have to take that all apart to figure it out. (by the way make sure the key is on run, at least, or better yet with the engine running....try different key igniton positives (accessory, off, run) to see if it makes a difference)

If you're getting +12VDC there at the panel, then start checking for voltage elsewhere. Pinpoint where the wiring diagram would normally indicate voltage and there isn't any, there's the problem. Autozone or Advanced Auto or the library will have the manual you need, I recommend a Chilton over a Haynes.

I have this van too. My van is notorious for leaks and a rusted roof. If water got somewhere like the fuse panel slowly it's going to corrode (or short) parts of the panel or wiring.

Check ground wires too (negative are black wires, typically), like near the battery and under the dash to see if something has been broken from the chassis or badly corroded. Clean corrosion with emery cloth or a file then tighten. Antiseize can help prevent this too, it might be conductive as well, I'm not sure.

Hang in there, It can be fixed though, it will just take a little patient and checking under there till you get at the problem. It may be easier to work on it by taking the driver's side seat out, if you find you have a problem under the dash. Or remove the dash, but a seat removal is easier.

I hope this helps you start your troubleshooting. Good luck.

Posted on Apr 24, 2011

3 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 166 Answers

SOURCE: not shifting to 3rd or 4th gear

3 and 4 clutch pac . get it rebuilt

Posted on Jun 02, 2009

rickvw345
  • 3 Answers

SOURCE: 1994 Chevy G20 Van - Van (auto trans) only has high (D) gear

Sound like you're going to need to drop the transmission pan so you can replace the filter along with fresh transmission fluid. I had a problem like that many years ago, this correct the problem... I also know that the throttle positioning sensor will also cause transmission shifting problems. I would start with the filter change then go from there... Good luck.

Posted on Aug 29, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Heat or air not blowing out of any vents in my 95 Chevy g20 van


the heater control valve might be broken or plugged

Dec 11, 2016 | 1995 Chevrolet G20

1 Answer

1990 Chevy van fusebox location


Donald, You did not state the model, so I posted the link for the models I found for chevy van fuse box. Check the attached links,instruction and guides, Good luck
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."
Interior Fuse Box Location 1990 1996 Chevrolet G20 1994 Chevrolet G20...
Blown Fuse Check 1990 1996 Chevrolet G20 1994 Chevrolet G20 Chevy Van 4 3L...
fuse box diagram 1990 chevy astro van pdf 1 Docs Engine com
1990 Chevy van fusebox location Google Search

Jul 27, 2016 | Cars & Trucks

1 Answer

Where can I find a fuse block diagram for a 1994 chevy g20 van?


google fuse block diagram for a 1994 chevy g20 van, should pop right up

Jan 07, 2015 | Chevrolet Cars & Trucks

1 Answer

I have a 1994 chevy Van G20 series it will go in reverse and in low gears but wont shift


Check your E-break first, secondly check to make sure you have no errors kicking from the control unit (engine computer module) which may or may not trigger a check engine light. Moreover it could be several things. Since it's an automatic the drive train maybe damaged, controller unite could be damaged, the transmission could (and probably) is dying. I'd have a professional mechanic check it out.

Jul 31, 2014 | 1994 Chevrolet G20

1 Answer

93 chevy g20 have speedometer cable


The speedometer cable should not have anything to do with changing the ball joint. it goes directly to the transmission on a 93. your grinding sounds like either someone didn't get the bearing back in the hub right or loose bolts on the wheel ..

Apr 05, 2014 | Chevrolet G20 Cars & Trucks

1 Answer

How do you remove the back seat from a 1994 chevy g20 van?


I believe the seats are bolted to the floor of the van. Make sure you unplug all electrical connections before removing the seats.

Feb 11, 2014 | 1994 Chevrolet G20

1 Answer

My 93 chevy g 20 vans air stopped blowing but when you move the switch you can still hear the compressor engage, before this happened it would come on and off if you slammed the door what could it be?...


Check blower motor. Compressor is doing its cold air work but you need the blower fan to get it into your can/van. You could simply have a loose connection. Follow the wires and try unplugging it and pluggin' it back in. Could also be a fuse or relay. When you say you slammed the door, sounds like a loose connection. Any wires hot or being pinched? See anything thing that looks melted under there?
Also, are you hoses connected to your vents under the dash???? That is easy enough to unscrew and check. Good luck

Jun 14, 2011 | 1993 Chevrolet G20

1 Answer

Van blows cold air instead of hot ?


low coolant or no heater core or no themostat

Dec 23, 2010 | 1994 Chevrolet G20

1 Answer

Where is the shift solenoid located at on a 94 g20 van


1994 chevy 3/4 ton van, you have a 4L60E ?
You have to pull the trany pan, ther are 2 solenoids A and B. You will probably want to replace both, they are at the front on the valve block. www.rockauto.com

Feb 04, 2010 | 1994 Chevrolet G20

1 Answer

Not shifting to 3rd or 4th gear


3 and 4 clutch pac . get it rebuilt

Jun 02, 2009 | 1994 Chevrolet G20

Not finding what you are looking for?
Cars & Trucks Logo

328 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

75005 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7710 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...