Question about 2006 Saturn ION

2 Answers

Where is the fuel pump relay on my 06 saturn ion

Posted by on

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 638 Answers

I would look under the hood on the drivers side of your vehicle, and look for a black box, the box normally has 2-3 plastic snaps, that you can un snap in order to remove the top plastic cover, this box should say relays / fuses, look inside for the fuel pump relay, they are labeled, and normally, the cover has a diagram on the inside of it to indentify the fuses, and relays, hope that this information has helped you.

Posted on Mar 25, 2011

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Brigadier General:

    An expert that has over 10,000 points.

  • Master
  • 4,044 Answers

The relay is located under the hood in the power distribution box.

Posted on Mar 25, 2011

2 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 2 Answers

SOURCE: saturn ion fuel pump

Misnikie32 . .. I just had the same problem around the time you figured out your problem and I just got it fixed yesterday. For almost 3 weeks I had starting problems and I constantly smelled gas. The problem is a safety issue and the car needs to be recalled. The hose that is connected to the fuel pump is cracked. Since the hose is incorporated with the fuel pump, the entire mechanism needs to be changed. Look at spending about 700.00 . I informed saturn and told them my life was at danger. Please contact them on their website and goto your state's attorney general and launch a complaint, as well as the office of defective investigations and the NTSAB (google them). This needs to be brought to their attention and all owners of this car. I googled this and many other people are having this problem. Some are even on this forum. PLEASE DO THIS ! ! ! !

Posted on Oct 03, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do I remove a key switch on a 06 Saturn relay?


2005 Saturn Ion Ignition Cylinder Removal - YouTube

? 2:08
www.youtube.com/watch?v=jH69-l73hCA
Apr 24, 2013 - Uploaded by Oldsmob455 The key didn't want to turn back into the off position. The oem lock cylinder kinda sounds like a problematic ...

Sep 22, 2015 | Saturn Cars & Trucks

1 Answer

Where would the fuse or relay for fuel pump be located in my 2003 ion


Look in the interior fuse block. It is located on the drivers side of the center counsel, just to the right or where our right leg would be. You will need to remove the trim panel. The fuses will be labeled on the inside of the panel. Page 5-96 http://www.saturn.com/content/dam/saturn/northamerica/usa/nscwebsite/en/Home/Owners/Owner_Resources/Manuals/en/us/2004/ion/2004-saturn-ion-owners-manual.pdf#page325

Apr 06, 2013 | 2003 Saturn ION

1 Answer

2005 Ion 2 starts and shuts off immediately.


I would begin with the fuel pump relay and see if it is being powered after the engine starts.

Sep 10, 2012 | 2005 Saturn Ion 2

1 Answer

I have a 2004 saturn ion and it won't start. I think it's gas related. Where and how do I replace gas sensors/filters or fuel pump? What do I try and replace first? How do I I tell which is bad?


If you haven't replaced the fuel filter in the last year or so, do it now-basic maintenance.
Check if the pump is working by turning key to ON (not crank), and listen for the pump in the tank to come on for a couple of seconds. Should hear a short hum or buzz verifying tank is working. If you don't hear it come on, either the pump is bad, or power is not reaching it. May have to pull the pump connector off at tank, and check for 12 volts on pump wire when someone cranks the car. If power there, the pump must be bad. If no power there at pump, check fuses for pump and fuel pump relay.

Dec 30, 2011 | 2004 Saturn ION

1 Answer

I replaced fuel pump but did not start,poured fuel in the air breather and it stays on until the fums run out.checked the pressure on the rack and nothing.is there a relay that doesnt work a fuse or is it...


The fuel pump relay is controlled by the PCM which uses the gray and black wires all the way back through the chaissis to the fuel pump. With the key on and no pressure at the rail the pump should be running. If there is no power out of the PCM (Power Train Control Module) to the fuel pump relay the fuel pump will not work

If your looking for the fuse the fuse location is in the FREE owners manual here: (2.62 Mb)
http://www.aboutautomobile.com/OwnerManual/2004/Saturn/ION Check the IGN fuse.... and the fuel pump relay (page 330)

Some fuses are in a fuse block on the driver's side of

the vehicle, near the driver's right leg. Loosen the screw
on the cover and remove the cover.

Thanks for choosing FixYa,
Kelly

Aug 01, 2011 | 2004 Saturn ION

1 Answer

The fuel filler kicks off when i try to put gas in my 06 ion. Is this a common problem with these cars??


it's not the car, it's the ven't tube for the fuel tank if the tank can't ven't it will keep shuting off the gas pump!

Jun 04, 2010 | 2006 Saturn ION

1 Answer

Had to replace fuel pump in 2006 Saturn Ion... it's only THREE!


i just had the same issue . . .I have been having starting problems with my car (2006 Saturn Ion) and smelling gasoline. It turns out the hose connected to the fuel pump was cracked and leaking gas. The mechanic said that this is a safety issue and should be recalled. He feels that the one hose is not connected and harnessed properly and the vibration to the hose eventually caused the crack. I googled "Saturn 2006 Ion fuel leak" and several other people have had the same issue. What is also the major problem here is that the hose is configured with the fuel pump itself. So, the entire mechanism had to be replaced. It cost me 700.00 for a cracked hose because the fuel pump had to be replaced and my car only is 46,000 miles. This is a major safety issue. I drove for 2 weeks with a car that was leaking fuel. Saturn must know about this and is waiting for the same situtation to happen, but for the car to blow up instead. PLEASE IF YOU ARE READING THIS CAUSE YOU HAVE THE SAME ISSUE . . . . contact the office of defects and the NHTSA . . .This is a saftey issue and a recall needs to be in affect . . .

Sep 30, 2009 | 2006 Saturn ION

3 Answers

Saturn ion fuel pump


Misnikie32 . .. I just had the same problem around the time you figured out your problem and I just got it fixed yesterday. For almost 3 weeks I had starting problems and I constantly smelled gas. The problem is a safety issue and the car needs to be recalled. The hose that is connected to the fuel pump is cracked. Since the hose is incorporated with the fuel pump, the entire mechanism needs to be changed. Look at spending about 700.00 . I informed saturn and told them my life was at danger. Please contact them on their website and goto your state's attorney general and launch a complaint, as well as the office of defective investigations and the NTSAB (google them). This needs to be brought to their attention and all owners of this car. I googled this and many other people are having this problem. Some are even on this forum. PLEASE DO THIS ! ! ! !

Sep 04, 2009 | 2006 Saturn ION

4 Answers

06 saturn ion 2.2 power steering ligt comes on


There is no fluid in that system. You may have a relay going bad or something. With these electrical issues, I would go see the dealership since not many shops will know what to do with this system.

Mar 26, 2009 | 2006 Saturn ION

Not finding what you are looking for?
2006 Saturn ION Logo

1,266 people viewed this question

Ask a Question

Usually answered in minutes!

Top Saturn Experts

yadayada
yadayada

Level 3 Expert

75817 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8180 Answers

Are you a Saturn Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...