Question about Chrysler Voyager

1 Answer

Removing low presure fuel pump which is in the tank of a grand voyager 2.5 . I have lower the tank is there anything i have to be careful of or is is straight forward the tank is 3/4 ful of fuel. thank you ann

Posted by on


1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 20 achievements.


    An expert that got 10 achievements.


    An expert that got 5 achievements.

  • Master
  • 3,400 Answers

First disconnect battery, and before you drop tank check under rear carpet for an access panel (above tank) many newer vehicles have access panels just for this replacement. Other than that pretty straight forward.

Posted on Mar 21, 2011


1 Suggested Answer

  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017


Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

How do you remove a fuel pump on a 97 plymouth grand voyager

    • 1 Make sure the engine is completely cool. Relieve the pressure in the fuel system. Disconnect the negative battery cable. Elevate the vehicle and support the fuel tank with a jack.
    • 2 Disconnect the fuel line from the front of the tank. Remove the ground strap, the inboard side fuel tank straps and the front T-strap fastener, then lower the tank approximately six inches.
    • 3 Take the fuel lines from the fuel pump module. Plug the fuel lines with golf tees to prevent the spillage of gasoline. Remove the fuel filter.
    • 4 Install the new fuel filter. Set the bolts in place and torque them to 40 inch/pounds. Tighten the main tank straps to 40 foot/pounds and the T-strap to 250 inch lbs.
    • 5 Reconnect the fuel lines in the reverse order of their removal. Lower the vehicle. Connect the negative battery cable.
    • 6 Start the engine and let it run for several minutes. Inspect the fuel lines for any leaks.

Read more: How to Replace a Fuel Filter in a Plymouth Voyager '

Aug 27, 2011 | 1997 Plymouth Voyager

2 Answers

How to change a fuel pump?

Remove the fuel tank from the vehicle, Remove the locking ring from the fuel pump module, remove the fuel pump module, reverse steps to install.

Jan 15, 2011 | 1995 Plymouth Grand Voyager

2 Answers

Why would a chrysler grand voyager diesel stall on acceleration

Can be a fuel filter or low fuel presure,, i would replace the fuel filter first then if no help do a fuel presure check

Jul 15, 2010 | 2002 Chrysler Voyager

1 Answer

Need to replace fuel pump on 1988 plymouth voyager how do I get to it

You'll need to disconnect battery, disconnect filler tube,fuel lines, wiring connectors at tank, and remove straps, to lower tank, and it's in the tank.(from top) Try to get fuel level as low as possible, or empty, and have something, or someone under there to help support tank when ready to remove straps and lower it.

Jul 06, 2010 | 1988 Plymouth Voyager

2 Answers

Where is the fuel filter located on a 2000 chrysler grand voyager 3.3 liter v6

Commonly the fuel filter is in the tank and is good for 100k miles. You can call your local part store for a fuel filter listing but they will probably tell you that there isn't one.

Apr 17, 2010 | 2000 Chrysler Grand Voyager

1 Answer

Is my fuel pump in the gas tank in 1997 plymouth grand voyager

yes the fuel pump is in the tank and the tank has to be removed to replace the pump

Apr 14, 2010 | 1997 Plymouth Grand Voyager

1 Answer

I need to change the fuel pump on a 1997 plymouth voyager van

To do this you'll need to remove the gas tank, (if you can) run the van near empty. The tank is located on the passenger side. Start by Placing the van on jack stands, remove the battery ground, and you'll need to remove all of the wiring and fuel hoses to and from the tank with fuel filler inlet too. If my memory serves there are two large bands which hold the tank in place, these will have to be removed and carefully lower the tank. The fuel pump access is a large nut, of sort, on the top side of the tank. With care using a strap wrench you can loosen this retainer and then carefully remove the fuel pump with the sending unit.
I hope this may have assited you.

Oct 25, 2009 | 1997 Plymouth Voyager

1 Answer

Changing fuel pump on chrysler 2000 grand voyager

you have to drop the gas tank out from under the vehicle. You must first drain as much gas out of the tank as you can. Then support the tank with a jack. Preferably with a large plate. Then remove the retaining straps. If you can remove any of the fuel lines and fill nozzle before lowering please do. If you cannot, lower the tank until access to wiring harness and fuel line disconnects can be made. With a special fuel line tool remove lines and harness and anything else that may hinder the removal on the tank. Once the tank is out from under the vehicle remove as much dust and debris as you can fom the top of the unit. Remove the retaining ring using a hammer and a punch, or screwdriver. Once the retaining ring has been removed carefully remove the fuel pump assembly from the tank. be careful not to damage the float. replace pump in the reverse order above.

Jul 30, 2009 | 2000 Chrysler Grand Voyager

1 Answer

Need to remove the fuel tank

Yow! that's not going to be fun. Obviously rust etc, and dirt collected while sitting, and yes I'd be doing the same before anything else. That said, You just might have to figure out a way to lower that tank enough to get sender/pump assy, out enough to stick a siphon hose in there and try to transfer some fuel that way, unless you know where you can borrow a small pump for transferring fuel. Only other option would be to fabricate a good base to balance tank on a floor jack, when straps are off, lower it slow and wheel it out slow. I've had to do it before, so it can be done. An extra set of hands don't hurt when your ready to come out.

Mar 28, 2009 | 1990 Plymouth Grand Voyager

1 Answer

How do I replace a tank maounted fuel pump on a jeep grand cherok

its not real hateful especially if the tank is low on need to drop the tank out of the vehicle....the electrical connecto is on the drivers side in front of the tank mounted to the frame,,,,disconnect the fuel lines and undo the nuts holding the 2 straps...lower the tank and there is a plastic ring holding the pump in...loosen it counter clockwise and remove the pump

Jan 01, 2009 | 1995 Jeep Grand Cherokee

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

75 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chrysler Experts


Level 3 Expert

81285 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22326 Answers


Level 3 Expert

814 Answers

Are you a Chrysler Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides