Question about Volkswagen Jetta

2 Answers

I have a 1994 jetta 1.8 and i just replaced the radiator but now the car overheats,any suggestions as to what the problem may be??

Posted by on

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Master
  • 1,702 Answers

Best guess is you have an air lock in the cooling system, they can be tuff to get out the best way to do it on a VW is to jack up the front end as high as you can ( the air will move to the highest point in the system ) then run the engine with the cap of the cooling system off and keep adding coolant a little at a time until the air is pushed from the system, some times we find we have to remove a heater core hose to get the air to move out of the system.

Posted on Mar 20, 2011

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Sergeant:

    An expert that has over 500 points.

  • Volkswagen Expert
  • 341 Answers

It could be a number of things ranging from a faulty water pump to a cylinder head. I would first check that your oil is not milky in appearance by looking at the dipstick or filler cap, if it is it could be your cylinder head gasket has blown (if the engine has boiled), you may be lucky and you wont have a cracked cylinder head but it will need to be checked, especially if you have refilled with cold water when the engine has been boiling. Other things to check, and probably the most obvious one is that you don't have an airlock in your cooling system, if its been drained down then this is a good bet If the engine has been boiled, another thing it could be is that the thermostat has stuck and needs replacing, they don't like getting too hot. The water pump could be faulty, they do stop working even though they show no signs of any leaks but I would check for airlocks, leaks or the thermostat before delving in any deeper.

Posted on Mar 20, 2011

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1999 jetta overheats until heat is on full blast


You should start by checking the thermostat for the radiator. It controls the flow of coolant to your engine. Turning on the heater allows the coolant to circulate through another type of radiator. You should also check your radiator fluid to make sure you have enough( the fluid should be changed around every 5 years).

Apr 18, 2013 | 1988 Volkswagen Jetta

1 Answer

Stevemy 99 vw jetta 2.0 the cat overheats and burn the oz sensor


Hello and welcome to FixYa!


If you have overheating problem, it can lead to multiple issues. You may be running on low coolant that's why the vehicle overheats. If that's the case, please add coolant and make sure that it sits on the right level, too much coolant can cause overheating too for coolant will overflow.


The vehicle may have a faulty or worn out radiator blower motor that's why it overheats. If that's the case then you will need a blower motor replacement to resolve the issue.


If the radiator is clogged with dirt and rusts this issue occurs too. The coolant doesn't flow normally on the cooling system if it's clogged. If that's the case, I strongly suggest that you have the radiator flushed to drain out dirt and rusts. If you think that the radiator served you enough then it's better to have it replaced.


Please do check the radiator hoses, If you have worn out hoses it can cause coolant leakage which can result to overheating. A tiny hole is good enough for the vehicle to overheat.


A faulty thermostat sensor can cause the issue too. If you have worn out thermostat, the fan may not trigger that's why the fan won't work when under stressed conditions. A blown radiator blower fuse can cause this issue too so I suggest that you check the radiator blower fuse and replace it when necessary.


Hope you find this information helpful enough and thank you for using FixYa! Have a good one!

Apr 26, 2011 | 1999 Volkswagen Jetta

1 Answer

Overheating runs rough


Hello and welcome to FixYa!


If you have overheating problem, it can lead to multiple issues. You may be running on low coolant that's why the vehicle overheats. If that's the case, please add coolant and make sure that it sits on the right level, too much coolant can cause overheating too for coolant will overflow.


The vehicle may have a faulty or worn out radiator blower motor that's why it overheats. If that's the case then you will need a blower motor replacement to resolve the issue.


If the radiator is clogged with dirt and rusts this issue occurs too. The coolant doesn't flow normally on the cooling system if it's clogged. If that's the case, I strongly suggest that you have the radiator flushed to drain out dirt and rusts. If you think that the radiator served you enough then it's better to have it replaced.


Please do check the radiator hoses, If you have worn out hoses it can cause coolant leakage which can result to overheating. A tiny hole is good enough for the vehicle to overheat.


A faulty thermostat sensor can cause the issue too. If you have worn out thermostat, the fan may not trigger that's why the fan won't work when under stressed conditions. A blown radiator blower fuse can cause this issue too so I suggest that you check the radiator blower fuse and replace it when necessary.


Hope you find this information helpful enough and thank you for using FixYa! Have a good one!

Apr 16, 2011 | 1998 Volkswagen Jetta

1 Answer

V6 car drives for about 100 km then slowly overheats


Hello and welcome to FixYa!


If you have overheating problem, it can lead to multiple issues. You may be running on low coolant that's why the vehicle overheats. If that's the case, please add coolant and make sure that it sits on the right level, too much coolant can cause overheating too for coolant will overflow.


The vehicle may have a faulty or worn out radiator blower motor that's why it overheats. If that's the case then you will need a blower motor replacement to resolve the issue.


If the radiator is clogged with dirt and rusts this issue occurs too. The coolant doesn't flow normally on the cooling system if it's clogged. If that's the case, I strongly suggest that you have the radiator flushed to drain out dirt and rusts. If you think that the radiator served you enough then it's better to have it replaced.


Please do check the radiator hoses, If you have worn out hoses it can cause coolant leakage which can result to overheating. A tiny hole is good enough for the vehicle to overheat.


A faulty thermostat sensor can cause the issue too. If you have worn out thermostat, the fan may not trigger that's why the fan won't work when under stressed conditions. A blown radiator blower fuse can cause this issue too so I suggest that you check the radiator blower fuse and replace it when necessary. What causes the radiator blower fan fuse to blow? It's because of a failing radiator blower motor, If that's the case have the radiator blower fan motor replaced.


If the fluid in radiator doesn't circulate then it means that you have a blown head gasket or a faulty water pump. I suggest that you go for the water pump replacement first specially if you think that it's near the end of it's service life. Usually, water pops out the radiator when engine is reved (a sign of faulty water pump and possible blown head gasket).


Hope you find this information helpful enough and thank you for using FixYa! Have a good one!

Jan 08, 2011 | 1994 Toyota Camry

1 Answer

Changed engine temp sensor and fuse relay. Only one fan turns on and car still overheats


Hello and welcome to FixYa! If you have overheating problem, it can lead to multipleissues. You may be running on low coolant that's why the vehicle overheats. Ifthat's the case, please add coolant and make sure that it sits on the rightlevel, too much coolant can cause overheating too for coolant will overflow. The vehicle may have a faulty or worn out radiator blowermotor that's why it overheats. If that's the case then you will need a blowermotor replacement to resolve the issue. If the radiator is clogged with dirt and rusts this issueoccurs too. The coolant doesn't flow normally on the cooling system if it'sclogged. If that's the case, I strongly suggest that you have the radiatorflushed to drain out dirt and rusts. If you think that the radiator served youenough then it's better to have it replaced. Please do check the radiator hoses, If you have worn outhoses it can cause coolant leakage which can result to overheating. A tiny holeis good enough for the vehicle to overheat. A faulty thermostat sensor can cause the issue too. If youhave worn out thermostat, the fan may not trigger that's why the fan won't workwhen under stressed conditions. A blown radiator blower fuse can cause thisissue too so I suggest that you check the radiator blower fuse and replace itwhen necessary. What causes the radiator blower fan fuse to blow? It's becauseof a failing radiator blower motor, If that's the case have the radiator blowerfan motor replaced. If the fluid in radiator doesn't circulate then it meansthat you have a blown head gasket or a faulty water pump. I suggest that you gofor the water pump replacement first specially if you think that it's near theend of it's service life. Usually, water pops out the radiator when engine isreved (a sign of faulty water pump and possible blown head gasket). Hope you find this information helpful enough and thank youfor using FixYa! Have a good one!

Jan 07, 2011 | 1994 Mazda Protege

1 Answer

1994 Chevy Caprice Classic Turned on the car to warm up. The temperature went up fast. Drove to the freeway and noticed smoke coming out of the right side of the hood. Temperature went up to red as if it...


Hello and welcome to FixYa! If you have overheating problem, it can lead to multipleissues. You may be running on low coolant that's why the vehicle overheats. Ifthat's the case, please add coolant and make sure that it sits on the rightlevel, too much coolant can cause overheating too for coolant will overflow. The vehicle may have a faulty or worn out radiator blowermotor that's why it overheats. If that's the case then you will need a blowermotor replacement to resolve the issue. If the radiator is clogged with dirt and rusts this issueoccurs too. The coolant doesn't flow normally on the cooling system if it'sclogged. If that's the case, I strongly suggest that you have the radiatorflushed to drain out dirt and rusts. If you think that the radiator served youenough then it's better to have it replaced. Please do check the radiator hoses, If you have worn outhoses it can cause coolant leakage which can result to overheating. A tiny holeis good enough for the vehicle to overheat. A faulty thermostat sensor can cause the issue too. If youhave worn out thermostat, the fan may not trigger that's why the fan won't workwhen under stressed conditions. A blown radiator blower fuse can cause thisissue too so I suggest that you check the radiator blower fuse and replace itwhen necessary. What causes the radiator blower fan fuse to blow? It's becauseof a failing radiator blower motor, If that's the case have the radiator blowerfan motor replaced. If the fluid in radiator doesn't circulate then it meansthat you have a blown head gasket or a faulty water pump. I suggest that you gofor the water pump replacement first specially if you think that it's near theend of it's service life. Usually, water pops out the radiator when engine isreved (a sign of faulty water pump and possible blown head gasket). Hope you find this information helpful enough and thank youfor using FixYa! Have a good one!

Oct 25, 2010 | 1994 Chevrolet Caprice Classic

1 Answer

Overheating


replace the cap with the pressure rating recommended by the dealer it is probably over pressurizing the coolant system

Jun 12, 2009 | 2000 Volkswagen Jetta TDI

2 Answers

1996 Jetta Treck - overheating


thermostat replace temp sensor its cheap i hope your water pump is not bad you could mess engine up if you keep on running car and is overheating.

May 16, 2009 | 1996 Volkswagen Jetta

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

293 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

yadayada
yadayada

Level 3 Expert

75117 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7772 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...