Question about GMC Envoy
This is usually caused by a failing fan motor resistor pack. The resistors
allow changes the speed of the fan. If one or more fail, certain speed(s)
Auto Zone sell the blower motor resistor pack for the manually controlled fan speed for $28 (they may also have the automatic or climate control types, too). I did this job myself in my '04 Envoy in less than 30 minutes with a flashlight and a few simple hand tools. You might have to get into a slightly awkward position to see & remove / reinstall the screws that hold the resistor pack in place under the dashboard however.
1) Remove the two screws from the plastic cover under the glove box & disconnect / remove electrical connectors secured to the cover. Set the cover aside.
2) Empty the glove box of the contents.
3) With the glove box open, push the clip on rear of the left side of the glove box towards the firewall to allow it to fall forward.
4) Remove the electrical connector from the blower motor located to the right of the glove box opening.
5) Pull the connector and cable downward tot he floor. There is a thick rubber band that may be holding the cable - pull it away to slide the cable out easily.
6) Close the glove box.
7) Look upward - close to the firewall to follow the cable removed in a previous step (a flashlight can help out here). It enters a plastic part held in place with two screws. There is also a narrow electrical connector on this plastic part.
8) Disconnect the narrow electric connector by pulling it straight downward.
9) Remove the two screws that hold the plastic part in place.
10) Allow the part to fall / gently pry away from surface.
11) Reinstall in reverse order.
Check with the store first to make sure this part is compatible with your model year vehicle - the part is Duralast #DR755 shown below:
I hope this helps!
Posted on Nov 04, 2009
My A/C on my 2003 Envoy worked fine yesterday. Today I get nothing. I tried the fan buttons on the dash and nothing came from the vents when I used the A/C or the heat and yet it appeared to be on. No wind... I checked both fuse boxes...??
Posted on Jul 07, 2010
Tips for a great answer:
Aug 28, 2014 | 2002 GMC Envoy
May 18, 2011 | 2002 GMC Envoy
Sep 13, 2010 | 2003 GMC Envoy
Aug 22, 2010 | 2003 GMC Envoy
Jan 10, 2010 | 2002 GMC Envoy
Nov 09, 2009 | 2002 GMC Envoy
Aug 22, 2009 | 2002 GMC Envoy
Mar 15, 2009 | 2003 GMC Envoy Xl
2,139 people viewed this question
Usually answered in minutes!