An expert who has achieved level 3 by getting 1000 points
An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.
An expert that got 20 achievements.
An expert that got 10 achievements.
Re: fuel pump relay
The relay panel is mounted just behind and below the headlight switch - actually right behind the diagnostic plug. Access to this relay is from beneath the dash. Remove the driver's-side under-dash flat plastic panel with a Torx screwdriver (T20) you only need to remove the three screws at the front edge). You should be able to access the relay from there; I believe it is the #190. Look in your users manual or service manual to confirm for your particular beetle.
- If you need clarification, ask it in the comment box above.
- Better answers use proper spelling and grammar.
- Provide details, support with references or personal experience.
Tell us some more! Your answer needs to include more details to help people.You can't post answers that contain an email address.Please enter a valid email address.The email address entered is already associated to an account.Login to postPlease use English characters only.
Tip: The max point reward for answering a question is 15.
The fuel pump relay for this 2003 Kia Sorento is located insdie the engine compartment fuse box, open the hood locate fuse box and the relay is there, the fuse box cover should have listing of the location of the relay.
It is located in the relay and Maxi fuse box under the hood near the battery, both the fuel pump fuse and relay are in this box, the fuel pump fuse is a 20Amp and is marked #10, the fuel pump relay is is marked as relay #301.
There is also a fuel pump cutoff switch (triggered by an accident exceeding 3 G's)
The fuel pump shut-off switch is
located in the passenger's foot well,
by the kick panel.
The relay and fuse for the fuel pump are located in the engine compartment
near the battery.
Fuse #9 20A* Powers Fuel Pump Relay
The relay is marked "Fuel Pump Relay" use the box lid to ID the relay position
The Fuel Pump Relay is located in the Glove Box under a little cover on the upper left side. The Fuel Control Relay is the left relay and The Fuel Pump Relay is the right. To test these relays, swap them and then try to start the vehicle, or blow the horn. If the horn blows then use that relay for the pump and you may at least drive the vehicle where needed! If the vehicle starts, then replace them as a pair.
You are looking for the constant control relay module- ( CCRM ) see below. The pump will be located inside the fuel tank.Most of the time , its the pump and not the relay but, it wouldn't hurt to check the relay out. Teh relay is housed in the CCRM. Its located behind the engine coolant reservoir.