Question about 1991 Volkswagen agon

1 Answer

Volkswagen vanagon air conditioning system

The air conditioner compressor is new and works great...i jumped power from the tail lights to the compressor and it works great.  my problem is that no power is getting to the compressor when i switch on the a/c at the control panel on the dash.  i can't find any blown fuses.  a relay may be bad but i can't find any diagrams showing which relay is for the a/c system.  
thanks.
my email address is kdgrillone@cox.net

Posted by on

1 Answer

Most of the control relays for the vanagon AC can be found on the drivers side D pillar under the plastic or in the cabinet if you have a cabinet. Best to buy a 'Bentley' factory service manual to help out. Cane Rattler...1989 Vanagon

Posted on Aug 29, 2008

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Air conditioning system freon


You'll need to have a mechanic check the system to see if it is low on freon, or if you have an electrical problem.

Jun 09, 2013 | 2008 Mitsubishi Galant

1 Answer

My air conditioner is blowing warm air on the driver side and cold on the passenger side


see this steps and think with clearly and logically NOT feared. God bless you
checkmark.gif Start with the compressor. Does it engage when you turn on the A/C?
If so, the compressor is working and the A/C system probably contains enough refrigerant to make cold air, so the problem is inside the HVAC unit. Replace the motor that controls the blend air door (this is a difficult job and best left to a professional since it involves tearing apart the HVAC unit -- about an 8 to 10 hour job!).
If the compressor does not engage when you turn on the A/C, see if it will run by jumping the compressor clutch wire directly to the battery (use a fused jumper wire). If the compressor works when you jump it, and the A/C blows cold air, the system contains refrigerant and the fault is likely a bad A/C compressor clutch relay or a bad clutch cycling switch or pressure switch.
If the compressor does not engage when you jump it, the problem is a bad compressor clutch.
If the clutch engages but the compressor does not turn (the belt will start to slip and squeal), the compressor is locked up and you need a new compressor.
If the compressor clutch engages and turns the compressor, but the A/C still does not blow cold air, the system is probably low on refrigerant and needs to be recharged.

7_25_2012_8_45_21_am.jpg

Jul 24, 2012 | 2007 GMC Sierra Classic

1 Answer

My GMC Sierra's air conditioning works great but the driver side vents will spontaneousely start blasting out hot air. The passenger side continuse to blow cold air. If iI turn the truck off and...


  1. Air conditioner system is discharged. Have the system evacuated, charged and leak tested by an MVAC certified technician, utilizing approved recovery/recycling equipment. Repair as necessary.
  2. Air conditioner compressor clutch not engaging. Check compressor clutch wiring, electrical connections and compressor clutch, and repair or replace as necessary.

May 24, 2011 | 2005 GMC Sierra

2 Answers

The air conditioning in my 2005 T&C stopped working. Right before it stopped there was a "burnt" smell coming through the vents. What happened?


No air coming from air conditioning vents
  1. Check the air conditioner fuse and replace as necessary.
  2. Air conditioner system discharged. Have the system evacuated, charged and leak tested by an MVAC certified technician, utilizing approved recovery/recycling equipment. Repair as necessary.
  3. Air conditioner low pressure switch defective. Replace switch.
  4. Air conditioner fan resistor pack defective. Replace resistor pack.
  5. Loose connection, broken wiring or defective air conditioner relay in air conditioning electrical circuit. Repair wiring or replace relay as necessary. Air conditioner has a smell when used
    1. The air conditioner evaporator drain hose is blocked or partially restricted, allowing condensation to build up around the evaporator and drainage tray. Clear the drain hose where it exits the passenger compartment.
    2. Check compressor clutch wiring, electrical connections and compressor clutch, and repair or replace as necessary.

Oct 10, 2010 | 2005 Chrysler Town & Country

2 Answers

I have a 1987 vanagon fuel injected gas engine that starts fine, but after 2 minutes it seems to starve for fuel.You can turn the key off and it restarts fine ,but dies again in 2 minutes


A common problem can be the wires to the O2 sensor, and check the connections to the Air Flow Meter. Vanagons are also prone to something called Vanagon Syndrom, which is realted to faulty ground connections. So, check ALL the chassy grounds, by the starter, transmission, battery etc. Disconnect, wire-brush apply di-electric grease and reconnect. Lastly, many of the sensors which feed signals to the ECU could have bad connections, or wires which have breaks or cracks that could lead to corrosion inside the wire increasing resistance. Oh, one more thought, the vaccum lines on Vanagon are covered with cloth and if you pull them off, you can sometimes see cracks in the rubber. The vaccum leaks can also contribute to the problem. Now I would be remiss to not warn you about changing the fuel lines on your nearly 25 year old van. The rubber on these lines have been known to breakdown and leak, leading to engine fires. There is a great web-site called vanagon.com that has all sorts of great informaion on these wonderful vans. I've owned my 84 Vanagon Westy for 23 years. Hope you find this helpful!

Sep 06, 2009 | Volkswagen Camper Cars & Trucks

2 Answers

2001 Volkswagen,Jetta,A/C


THE AIR CONDITIONING IN MY 2000 JETTA VR6 JUST STOPPED WORKING, NO WARNING. I HAD TWO DIFFERANT MECHANICS LOOK AT IT. THEY SAID THAT THE COMPRESSOR IS NOT GETTING ANY VOLTAGE, BUT WHEN THEY JUMP VOLTAGE TO THE COMPRESSOR IT STILL WILL NOT START. THEY SAID THE COMPRESSOR SEEMS TO BE OKAY. ANY SUGGESTIONS

Aug 13, 2009 | 2000 Volkswagen Jetta TDI

1 Answer

1989 Vanagon Air Conditioner


Check the gas pressure, if it low it inhibits the relay that energises the compressor.

Aug 05, 2009 | 1991 Volkswagen agon

1 Answer

What do I have to do to change the a/c compressor are there any special procedures or can I take the old one off put the new one on and then charge the system with coolant I have a 1996 oldsmobile delta...


if old compressor fail your air condition has to be discharge at dealership or a garage that does ac repair.then the ac lines has to be flushed out before putting on new one. because old one when it fails clutch lock up or compressor fail.small metal particles get in line.stop up orifice tube.you will have to replace orifice tube the accumalator .you will need vacuum pump to pump down air conditioner .to get moisture out of system.you will need a manifold gauge set for air conditioner.ac tools are expensive.it would be cheaper to buy compressor - accumulator - orifice tube. take it to a good air conditioner mechanics.let him put parts on and pump down system.then charge it up.because buying tools to get ac going .is going to cost $475.00 thats the vacuum pump price.you can buy a cheaper vacuum pump that works from air from a regular air compressor you pump tires up with.manifold gauge set causes from $100.00 up to $300.00 for a good set.another thing you have to be familiar with working on air conditioners you put too much R-134 in system you will damage compressor or get seriously hurt.

Jul 05, 2009 | 1996 Oldsmobile 88

1 Answer

Air condition suddenly blowing uncooled air.radiator full. worked great until yesterday. could it be thermostat?


The thermostat and radiator are part of the engine cooling system, not part of the air condition system. Chances are, the A/C system is low on refrigerant. The system has a low pressure switch that prevents the air conditioner compressor from being damaged with the Freon is low.

You can purchase a can or R134a refrigerant at any parts store and try recharging the system yourself….the basic instructions can be found here:
http://www.aa1car.com/library/ac_recharging.htm

Jun 24, 2009 | 1999 Ford Escort

Not finding what you are looking for?
1991 Volkswagen agon Logo

1,079 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22026 Answers

yadayada
yadayada

Level 3 Expert

69114 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6817 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...