I have a plymouth grand voyager 96 and the alternator was just replaced the battery was just replaced but the ABS light just started coming on again. My husband starts the vehicle w/o putting his foot on the break. Is this causing any problems. He just lean in an start it.

Sounds strange that "no crank" after just changing EGR valve...go back to basics...check the battery post connections, all of your lights can still work with a dirty connection...the starter requires a lot more juice to crank...Hope this helps.

Sounds like the alternator went out (quit charging) and you have been running on the remaining charge of the battery until it was depleted. Try a jump start to crank it again , if it restarts, remove cables and look at dash warning lights for a red battery. It will not run long before it shuts down again. Alternator replacement will be needed. Hope this helped. Good Luck !

Not all bench tests on alternators are reliable. That battery has to be brought back to a full charge. It could be a simple connection to the alternator. Check those battery cables as well make sure the ground wire is secure.

First, you state "the battery is only getting 11.58". This implies the alternator IS charging albeit too low. I would connect the voltmeter to the main terminal on the alternator and take a reading before starting the motor, then again with the motor running at around 1500 RPM (fast idle). This will indicate whether the alternator is working or not.

Getting back to the ign light, does it remain at the same brilliance before starting the engine and after?



.

Check the wires, could be grounding out somewhere. Make sure wire casing is not cracked or worn away.

Check the alternator pulley for a wobble when the engine is running. WIth the belt off pull up and
down on the pulley, check for up and down movement. If the belt popped off, you have some movement on one of the pulleys, a bad belt tensioner, or just the wrong belt. So check the belt tensioner as well. And find the part number on the new belt and check online to see if its the correct belt. But Im fairly certain its the alternator.

I think you have a bad bearing on your alternator. The bearing can become loose and reseat itself for a while, then loose again. Could explain the battery light randomly coming on.

Have the alternator bench tested at the auto parts store as well.

The ultanator on my chrysler grand voyager was just changed a week ago but the battrey warning light is on again in the darsh board.

New alternator is not charging battery. Get another one.

brake light switch or a headlight switch

where is the ECM on a 96 voyager van? we need to replace it. thanks.