Question about 1991 Ford Aerostar Extended

1 Answer

Air conditioner My 91 aerostar blows cold at the rear & hot through the front vents, in Texas it's unbareable please help

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

On my 90 Aerostar 3L, I had a similar problem, in that the front vent control, or blend door was not setup correctly and had to be adjusted. Somehow the choke type cable for temperature adjust, had slipped out of its holder at the door end, and was not allowing the blend door to close properly, and the outside air was not allowed to bypass the interior heater core, even thought the cooling core was lowering the air temp, but raising it again because it had to go through the heater core. Removing the top of the dash, and looking in from outside the windshield, and having someone operate the temp control will tell you if it's working properly, or needs adjustment. Alternately, if it's the manual control type, by quickly operating the temp control, you should here the blend door "thump" as you open and close it. There should be full travel in the control range, or if limited, the above problem applies, adjust at the blend door mechanism.

Posted on Jul 13, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2004 Honda Pilot hot & cold


Sounds like a blend door problem under the dash.

Jun 25, 2013 | Cars & Trucks

1 Answer

Heater blow cold air in front hot air in rear


could be blend doors in heating duct work.

Mar 22, 2013 | 2008 Saturn Outlook

1 Answer

The heater in my 1999 Land Rover Discovery Series 1 won't blow cold.


As per your problem mentioned.There are few solved help links to troubleshoot these problems.Go through the list and Click the link below:----
Air conditioner blows air but not cold air http://repairhelpcenter.blogspot.in/2012/07/air-conditioner-blows-air-but-not-cold.html

------------
Car overheats and Air blows hot at idle? http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html

------------
Heater blows cold? http://schematicsdiagram.blogspot.in/2012/02/heater-blows-cold.html

-----------
Heat blows cold on drivers side and hot on passenger side? http://schematicsdiagram.blogspot.com/2011/12/heat-blows-cold-on-drivers-side-and-hot.html---------- Hot air on the driver's side vents only? http://repairhelpcenter.blogspot.com/2012/01/hot-air-on-drivers-side-vents-only.html

--------------
2005 Chrysler PT Cruiser: A/C Blows Warm? http://whoisbyme.blogspot.in/2012/06/2005-chrysler-pt-cruiser-ac-blows-warm.html

-----------
1992 Toyota Camry: A/C Control light Flashing and A/C not Blowing Cold? http://technoanswers.blogspot.in/2012/04/1992-toyota-camry-ac-control-light.html

--------------
No heat, blower blows only cold? http://technoanswers.blogspot.in/2012/02/no-heatblower-blows-only-cold.html

------------
These will help.
Thanks.

Nov 22, 2012 | Cars & Trucks

1 Answer

2001 yukon gmc a/c blows cold to rear warmer air to front a/c


Could be a blend door problem under the dash.

Jul 05, 2012 | 2001 GMC Yukon

1 Answer

1997 gmc rear air conditioner is blowing hot


Could be a blockage in the lines to the rear unit.
Might be low on freon too. Or a blend door problem.
Can you check under the floor and see if one of the lines is cold ?

Jul 04, 2012 | 1998 GMC Suburban

1 Answer

It blows out hot air even when the air in the front is cold


Hard to read your question, do you mean it blows cold air out of the front vents and hot air out of the rear passenger vents?

If the air coming out of the front is just cool and not cold, and the rear vents are warm, you have low freon and need to have it serviced.

Jun 03, 2011 | 2000 Pontiac Montana

2 Answers

1999 Suburban, A/C on warm air from front vents, cold air in rear


The car uses the same freon in the front as it does in the rear. If the rear a/c is working, you either have a plugged evaporator in the front unit, or perhaps a bad heater switch. Try switching the heater to hot and see if it blows even warmer air from the front vents. If so, the heater switch is working and then it sounds like a plugged evaporator or maybe a plugged orifice tube. That is a good place to start looking. Hope this helps.

Jul 07, 2009 | 1997 Chevrolet Suburban

1 Answer

Air conditioning


Sound like the rear temp door actuator is bad.

May 04, 2009 | 2003 Lincoln Navigator

1 Answer

Top rear vents blow out cold air[ 2005 cadillac srx ]


Hello according the the manual, the back vent are to blew cold air only..the fronts vents are suppose to the entire car...

Feb 01, 2009 | 2005 Cadillac SRX

Not finding what you are looking for?
1991 Ford Aerostar Extended Logo

186 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

60960 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Fordexpert

Level 3 Expert

5331 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...