Question about 1997 Subaru Outback

1 Answer

Where is the fuel pump located on the subaru outback wagon?

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Governor:

    An expert whose answer got voted for 20 times.

    Scholar:

    An expert who has written 20 answers of more than 400 characters.

  • Expert
  • 112 Answers

You should have an access panel under rear seat or in cargo area. on passenger side. here is a replacement procedure

Hope this helps, it it does please leave feedback and vote Thank You and Good Luck

  1. Release fuel pressure.
Where is the fuel pump - 62665083


  1. Disconnect fuel delivery hose (1) and return hose (2).
  2. Disconnect jet pump hose (3).
62665088


  1. Remove nuts which install fuel pump assembly on to fuel tank.
62665090


  1. Take off fuel pump from fuel tank .
INSPECTION

Where is the fuel pump - 62665091 62665091

Connect lead harness to connector terminal of fuel pump, and apply battery power supply to check whether the pump operates.

WARNING:

  • Wipe off the fuel completely.
  • Keep Battery as far apart from fuel pump as possible.
  • Be sure to turn the battery supply "on" and "off" on the battery side.
  • Do not run fuel pump for a long time under non-load condition .
INSTALLATION
Installation is in the reverse order of removal. Do the following:


  1. Always use new gaskets.
  2. Ensure sealing portion is free from fuel or foreign particles before inWhere is the fuel pump - 62665093on.
62665093


  1. Tighten nuts in numerical sequence shown to specified torque.
Tightening Torque: 4.4 ±1.5 N.m (3.3 ±1.1 ft-lb)

Posted on Jan 02, 2011

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

BCally1
  • 133 Answers

SOURCE: fuse box location on 2002 Subaru

my books say there are two. one inside vehicle on drivers side below dash to the left of the steering wheel. the other is in the engine compartment on the drivers side by fender

Posted on Jan 09, 2009

Rebgagnon
  • 382 Answers

SOURCE: were is the starter located in a subaru legacy

On the drivers side where the motor and transmission join on the top, you should see the starter. Your main hot or red battery cable should lead right to it. It has 2 bolts holding it. 1 is the bolt to hold starter and trans together, the other just holds the starter. Hope this helps and have a great day.

Posted on Jun 29, 2009

centralvalle
  • 386 Answers

SOURCE: Steering wheel clicks on 1998 Subaru Legacy Outback wagon

steering column bearing sounds like a worn out steering column... jack the front wheels off the ground both sides relieve load on steering wheel to see if it lessens the amount of feel and noise, if it does it shoud be the column bearing, replace bearings or complete column,,, also try with the wheels off the ground and safely supported to manualy steer the wheels by hand and see if you feel in roughness or hear any noises,should some minor resistance but be smooth in it movement if everything suspension and steering component wise is in good working condition... please rate my help.. thanks...

Posted on Aug 05, 2009

bschilz
  • 2049 Answers

SOURCE: Fuel Filter for a 2005 Subaru Outback

In 2005 Subaru moved the fuel filters to the fuel tank for both 4-cyl and 6-cyl cars. What is confusing is the statement in the owner's manual about replacement intervals; the statement actually only applies to 4-cyl cars. Even though the filter is mounted in the tank, this is still a replaceable element on 4-cyl, but not on 6-cyl. The 6-cyl filter element is part of the entire fuel pump assembly (a $300 assembly) and is not sold separately. Therefore the 6-cyl filter is intended to be a "lifetime" part, which really means it gets replaced when the fuel pump fails and the entire pump assembly is replaced.

Posted on Oct 30, 2009

Testimonial: "Excellent and timely advice. He cleared up a confusing question I had and got conflicting information from the vehicle owner's manual."

  • 395 Answers

SOURCE: location of fuel pump for 1992 subaru loyale wagon

REMOVAL & INSTALLATION

See Figure 1


0900c15280067055.jpg enlarge_icon.gifenlarge_tooltip.gif Fig. Fig. 1: Fuel pump assembly mounted under the vehicle-1.8L engine

  1. Release the fuel system pressure. Do not reconnect the fuel pump harness.
  2. Disconnect the negative battery cable.
  3. Raise and support the vehicle safely on jackstands.
  4. Clamp the middle portion of the hose connecting the fuel tank pipe and the pump to prevent fuel from flowing out of the tank when unfastened.
  5. Loosen the hose clamp and disconnect the hose.
  6. Remove the three pump bracket mounting bolts and remove the pump together with the pump damper.

To install:
  1. Install the fuel pump and damper, and tighten the bolts securely.
  2. Install the hose and tighten the clamp screw to 9-13 inch lbs. (1.0-1.5 Nm).
  3. Install the pump bracket in position to the vehicle body and secure it with the bolts.

Take care to position the rubber cushion properly.
  1. Connect the pump harness.
  2. Connect the negative battery cable and test the fuel pump for proper operation.
  3. Check for fuel leaks.

TESTING

  1. Turn the ignition ON and listen for the fuel pump to make a growling sound. Turn the ignition OFF .
  2. Release the fuel system pressure. Disconnect the pump harness and crank the engine for 5 seconds or more. If the engine starts, allow it to run until it stops. Turn the ignition OFF and install the fuel pump connector.
  3. Disconnect the fuel hose at the fuel pump.
  4. Connect a gauge in-line using a T-fitting.
  5. Start the engine and measure the fuel pressure. If the fuel pressure is not 36-50 psi (248-344 kPa), replace the pump.
  6. Release the fuel system pressure and remove the gauge.

Posted on May 23, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have a 2007 Subaru Tribeca. I preset the AM radio stations and when I restart my car the next day, it is on FM2 and all the AM stations that were programmed are gone. Anyone had this problem?


2007 Outback Wagon - radio controls freeze - Subaru Outback ...

www.subaruoutback.org > ... > Audio, Video, Security, & Navigation
Mar 22, 2012 - Have a 2007 Outbak Wagon with radio controls that freeze for no reason. It freezes and fixes itself randomly. What I mean by freeze is: can't ... Any luck fixing poor radio reception? - Subaru Outback - Subaru ...
Jul 19, 2010
08 O.B. radio/hvac control lighting prob.
Jun 30, 2010
radio is on, but no sound through speakers
Apr 21, 2010
Radio & Climate Control Display - Subaru Outback
May 25, 2009
More results from www.subaruoutback.org

Subaru radio problems 2008 outback - YouTube

? 0:09
https://www.youtube.com/watch?v=N9W78_ZlBdc
Oct 29, 2012 - Uploaded by NRHTX
Subaru radio problems 2008 outback. NRHTX ... Up next. 2007 Subaru Outback Suspension Noise Repair -EricTheCarGuy - Duration: 23:04.

Subaru Legacy GT Radio Problem - YouTube




Jan 10, 2016 | 2007 Subaru B9 Tribeca

1 Answer

Is there an access pannel under the rear seat of 1999 subaru legacy outback to access the top side fuel tank?


Yes, under the rear seat bottom on a sedan or behind the rear seat back on the panel under the carpet on the cargo area, right behind the seat back, screws hold the panel on, fuel pump right below it, easy to replace...I just did mine,1998 Legacy Wagon.

Jul 14, 2014 | 1997 Subaru Legacy

1 Answer

Need a stereo color code diagram for 2005 subaru outback Problems


Check this information about 2005 Subaru Outback Wagon Car Stereo Wire Guide:

Car Radio Battery Constant 12v+ Wire: Blue/Yellow
Car Radio Accessory Switched 12v+ Wire: Yellow/Red
Car Radio Ground Wire: Black
Car Radio Illumination Wire: Green
Car Stereo Dimmer Wire: N/A
Car Stereo Antenna Trigger: N/A
Car Stereo Amp Trigger Wire: N/A
Car Stereo Amplifier Location: N/A
Car Audio Front Speakers Size: N/A
Car Audio Front Speakers Location: N/A
Left Front Speaker Positive Wire (+): Brown/White
Left Front Speaker Negative Wire (-): Green/Black
Right Front Speaker Positive Wire (+): Red/Yellow
Right Front Speaker Negative Wire (-): White/Black
Car Audio Rear Speakers Size: N/A
Car Audio Rear Speakers Location: N/A
Left Rear Speaker Positive Wire (+): White/Red
Left Rear Speaker Negative Wire (-): Red/Green
Right Rear Speaker Positive Wire (+): Blue/Green

The 2005 Subaru Outback Wagon radio wire color information above is updated as it is submitted by the Modified Life community.

Hope helps (remeber to rated ans leave an testimoanial about this free answer).

Sep 29, 2011 | 2005 Subaru Outback

1 Answer

On a 2008 subaru outback where is the fuel filter located thanks


FUEL FILTER IS AN INTEGRAL PART OF THE FUEL PUMP ASSEMBLY.CANT REPLACE FUEL FILTER BY ITSELF THE FUEL PUMP AND FUEL FILTER IS ONE UNIT.

Apr 03, 2011 | 2008 Subaru Outback

2 Answers

Trying to find the location of the fuel pump relay in a 1997 4cyc outback looked under driverside dash but didnt find it


most fuel pump relays are located in the main fuse box,under the hood. look for a black box on the drivers side,or passenger side fenderwell under the hood. lift cover off and look on underside of the fuse box lid for location of the fuel pump relay and main engine fuse.hope this helps and thank you for choosing fixya.com

Jan 29, 2011 | 1997 Subaru Outback

2 Answers

Replacing brake light on a subaru outback limited wagon 2000


How To Install Replace Change Taillight and Bulb 2000-04 Subaru Outback

Apr 07, 2010 | 2000 Subaru Outback

1 Answer

Where is the fuel relay for a 2001 subaru outback


The fuel pump relay is located beneath the vehcle's rear close to the fuel tank. See image attached.

Mar 23, 2010 | 2001 Subaru Outback

1 Answer

Fuel Filter for a 2005 Subaru Outback


In 2005 Subaru moved the fuel filters to the fuel tank for both 4-cyl and 6-cyl cars. What is confusing is the statement in the owner's manual about replacement intervals; the statement actually only applies to 4-cyl cars. Even though the filter is mounted in the tank, this is still a replaceable element on 4-cyl, but not on 6-cyl. The 6-cyl filter element is part of the entire fuel pump assembly (a $300 assembly) and is not sold separately. Therefore the 6-cyl filter is intended to be a "lifetime" part, which really means it gets replaced when the fuel pump fails and the entire pump assembly is replaced.

Oct 30, 2009 | 2005 Subaru Outback

1 Answer

Where is the fuel pump in an 1989 subaru gl wagon located?


look to the driver side of the engine- Edmunds Books on the car pinpoint it.

Feb 22, 2009 | 1989 Subaru Gl Wagon

1 Answer

Fuse box location on 2002 Subaru


my books say there are two. one inside vehicle on drivers side below dash to the left of the steering wheel. the other is in the engine compartment on the drivers side by fender

Jan 09, 2009 | 2002 Subaru Outback

Not finding what you are looking for?
Cars & Trucks Logo

362 people viewed this question

Ask a Question

Usually answered in minutes!

Top Subaru Experts

yadayada
yadayada

Level 3 Expert

75744 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22114 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8123 Answers

Are you a Subaru Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...