2.0L Engine
Fig. 17: Remove the thermostat housing mounting bolts-2.0L SOHC engine
Fig. 18: Location of the water hose connection mounting bolts-2.0L DOHC engine
Fig. 19: Remove the thermostat and seal. Inspect the seal for damage and replace as necessary-2.0L DOHC engine To install:
SOHC ENGINE
(see Figure 17)
CAUTION
Never open, service or drain the radiator or cooling system when
hot; serious burns can occur from the steam and hot coolant. Also, when
draining engine coolant, keep in mind that cats and dogs are attracted
to ethylene glycol antifreeze and could drink any that is left in an
uncovered container or in puddles on the ground. This will prove fatal
in sufficient quantities. Always drain coolant into a sealable
container. Coolant should be reused unless it is contaminated or is
several years old.
Make sure the tabs on the thermostat engage properly into the slots in the housing.
To install:
DOHC ENGINE
(see Figures 18 and 19)
CAUTION
Never open, service or drain the radiator or cooling system when
hot; serious burns can occur from the steam and hot coolant. Also, when
draining engine coolant, keep in mind that cats and dogs are attracted
to ethylene glycol antifreeze and could drink any that is left in an
uncovered container or in puddles on the ground. This will prove fatal
in sufficient quantities. Always drain coolant into a sealable
container. Coolant should be reused unless it is contaminated or is
several years old.
Hope helps (remember to rate this answer).
Trace the upper radiator hose to the mounting area on the intake manifold. Loosen the hose clamp on the manifold end of the hose and remove the hose. Pull the thermostat out of the intake manifold.
For more help and troubleshooting go through the help links below:---
Click the link below:-----
THERMOSTAT REMOVAL PROCEDURE/LOCATION DETAILS
------------
Where is Thermostat Located on
Saturn
http://schematicsdiagram.blogspot.in/2012/06/2004-dodge-intrepid-how-to-replace.html
---------
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-thermostat-on-audi-a4.html
---------
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-thermostat-on-acura-car.html
http://repairhelpcenter.blogspot.com/2011/10/where-is-thermostat-located-on-2006.html
----------
http://repairhelpcenter.blogspot.com/2011/10/thermostat-on-audi-19-tdi.html
-----------
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-radiator-on-audi-and-vw.html
--------------
How to Replace a Thermostat.
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-thermostat.html
-------------
http://schematicsdiagram.blogspot.com/2011/12/how-to-locate-thermostat-on-any-car.html
http://technoanswers.blogspot.com/2011/12/where-is-thermostat-on-audi-a6.html
http://technoanswers.blogspot.com/2011/12/how-to-replace-thermostat-on-1992-buick.html
http://technoanswers.blogspot.com/2011/12/replacing-thermostat-on-1999-mercury.html
http://technoanswers.blogspot.com/2011/12/thermostat-replacement-on-toyota.html
309 views
Usually answered in minutes!
×