Question about 1994 Ford Econoline

Open Question

How do you change a bad fuel pump on a 1994 Ford E150 van ?

Posted by on

  • Bob Kovalak Nov 17, 2010

    You will need to drop the fuel tank in order to get to the fuel pump. The puel pump mounts on the top side of the fuel tank, about midway down the center tank. depending where you are located the fuel tank straps could be severely corroded, as will the locking mechinism that holds the fuel pum inside of the fuel tank. It's a very tough fix for a backyard mechanic, and a very expensive fix if you take it to a mechanic - typically $400 to $500, The pump can be replaced in its entirety for about $200, or the turbine can be replaced for about $75. New straps run about $40, and new filler & vent tubing will be very difficult to find. Napa carries the large diameter filler pipe, 1.5" ID, but does not carry the vent tube in gas line. AutoZone sells the filler tube, vent tupe and metal parts for about $120.



    It's a tough fix, and be prepared to bust a few knuckles in the process.

×

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya Mechanic can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repair professionals here in the US.
click here to Talk to a Mechanic (only for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
Thompsons196
  • 350 Answers

SOURCE: E150 Ford van fuel pump, new, but still not

Instructions
1
Turn off the engine and place the
transmission
gear selector lever in the "P" position. Depress the parking brake and open the hood.
2
Locate the under-hood relay center containing the fuel pump relay. It is on the right side of the engine compartment, between the
brake fluid reservoir and the battery.
3
Remove the cover from the relay center and look at the diagram on the reverse side. Note the location of the fuel pump relay.
4
Remove the fuel pump relay by hand using a rocking/pulling motion

Did you check this one?

Posted on Jan 29, 2011

Ad
  • 1 Answer

SOURCE: 96' Ford E150 fuel pump reset switch

mine is on the passenger side in front of the front door under the dash with a small hole for acess

Posted on Apr 21, 2009

  • 67 Answers

SOURCE: my 1994 ford econoline van is not shifting gears

Hello.
This a repair for a transmission shop. Sounds like the pumps are bad inside the transmission. Thats the worst option I have.
It also can be a poor shift linkage adjustment. And the last solution can be the speed module that tell the transmission when to shift.
Goodluck! I hope this helps!

Posted on Dec 07, 2009

  • 161 Answers

SOURCE: how do i access the fuel pump shut-off switch in a

The 'inertia' switch should be located in one of 2 places. 1.) Under the dash on the drivers side, up behind the brake pedal, maybe off to left or right a little bit, 2) possibly under dash on passengers side. Was the vehicle hit or did it hit something to activate the inertia switch?? Because this switch is a safety in case of a crash with a 15-20 mph impact.

Posted on Mar 13, 2010

motor1258
  • 6674 Answers

SOURCE: how much is cost for replacement the fuel pump for

Approx, $250-$300 for pump if 5.8L engine.

Posted on Aug 06, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

E150 fuel pump relay location


some are believe it or not in the glove compartment.

Nov 14, 2012 | 2004 Ford E150

1 Answer

My Ford E150 van, when almost floored, doesn't catch gas to the engine. Then I let up, and the van slows down 5 or 10 mph the engine works fine. What could this be?


clogged fuel filter, or it may be that the fuel pump is going bad. change filter, and while you have the line off, have a bottle ready, and put it over the line to catch the fuel. have someone turn on the key, but don't crank it, and see if you have fuel coming into the bottle. if so, then you may just have a bad fuel filter.

Nov 20, 2011 | Ford Cars & Trucks

1 Answer

Would this have something to do with why my 1992 Ford E150 Econoline Van is not getting the fuel flow to the engine? I was told the van has one fuel pump that is above the Gas tank and one in my engine and...


the most likely solution is that there is a blockage in your fuel lines. this can happenfrom time to time since not all fuels are pure.
a good way to confirm this is to check your fuel filter as it may be clogged from 'filtering' out the bad stuff in the fuel.
worst case scenario, you will need a new fuel pump, or 2 in your situation.

May 02, 2011 | Ford E-150 Cars & Trucks

1 Answer

Bad leak in fuel line need to replace


You don't say whether this is at a connector or a damaged fuel line. Also you don't mention what sized vehicle/engine for the van. Auto zone shows straight replacement fuel line in stock on this page (for me here in Texas) at $19.99. Check out the link to their website:
http://www.autozone.com/autozone/parts/1994-Ford-E150-1-2-ton-Van/Fuel-Line-Assembly/_/N-j0ngfZ8ve3f

Sep 23, 2010 | 1994 Ford Econoline

1 Answer

How do i access the fuel pump shut-off switch in a 1994 Ford E150 van?


The 'inertia' switch should be located in one of 2 places. 1.) Under the dash on the drivers side, up behind the brake pedal, maybe off to left or right a little bit, 2) possibly under dash on passengers side. Was the vehicle hit or did it hit something to activate the inertia switch?? Because this switch is a safety in case of a crash with a 15-20 mph impact.

Mar 13, 2010 | 1994 Ford Econoline

1 Answer

No fuel to my ford van e150 what happen


Look for fuel pump relay on firewall..Unplug fuel pump connector closest to fuel tank along frame rail, drivers side. With Key on, check for voltage at fuel pump wireing connecter. not fuel sending unit.

Dec 07, 2009 | 2001 Ford Expedition

1 Answer

My 1994 ford econoline van is not shifting gears


Hello.
This a repair for a transmission shop. Sounds like the pumps are bad inside the transmission. Thats the worst option I have.
It also can be a poor shift linkage adjustment. And the last solution can be the speed module that tell the transmission when to shift.
Goodluck! I hope this helps!

Dec 07, 2009 | 1994 Ford Econoline

2 Answers

86 e150 w/FI 5.0. no power to fuel pump system.


If pump does not work when power is directly applied, then pump will need to be replaced. Have you tested the power from the fuel pump relay?

Aug 24, 2009 | 1986 Ford Econoline

2 Answers

96' Ford E150 fuel pump reset switch


mine is on the passenger side in front of the front door under the dash with a small hole for acess

Mar 15, 2009 | 1995 Ford Econoline

2 Answers

Stalls / Dies / dead


this engine fuel pump prassurae low. it fuel pump celan. Your problem sovel

Jul 13, 2008 | 2003 Ford E150

Not finding what you are looking for?
1994 Ford Econoline Logo

Related Topics:

781 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

77202 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22265 Answers

fordexpert

Level 3 Expert

5581 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...