Question about Ford Fusion

1 Answer

I own a 2007 Ford Fusion V6 front wheel drive with 59,000 miles. There`s a deep sqeaking noise coming from the passenger front while driving only when the weather outside is above 50 deg. It doesnt make any noise when the weather is cold. What is causing this noise?

Posted by on


1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 20 achievements.


    An expert that got 10 achievements.


    An expert that got 5 achievements.

  • Ford Master
  • 4,369 Answers

Check brake pads for wear and check to see if the brake dust shield is rubbing the rotor. Most are metal, but yours may be plastic.

Posted on Nov 10, 2010

  • gerry bissi Nov 10, 2010

    TSB 08-18-4

    Some 2006 Zephyr, 2007-2009 MKZ, 2006-2009 Fusion and Milan vehicles built before 8/5/2008, may exhibit a popping, rubbing, grunting, squeaking, crunching or creaking type noise from the front strut mount when going over bumps, while driving at 1-10 MPH (1-16 Km/h) and/or during parking lot maneuvers. Typically, the noise is heard in the front outboard wheel while turning at low speeds. This noise may be caused by the jounce bumper rubbing against the dry strut plate.


    Follow the Service Procedure steps to correct the condition.


    1. Raise the vehicle as described in Workshop Manual (WSM), Section 100-02.
    2. Remove front shock absorber and spring assembly per WSM, Section 204-01.
    3. Disassemble the shock absorber and spring assembly per WSM, Section 204-01 under Disassembly and Assembly section.
    4. Apply Motorcraft® Silicone Brake Caliper Grease and Dielectric Compound 360° around the upper and lower contact surfaces of the shock absorber piston bounce bumper. (Figures 1 - 2)



2 Suggested Answers

  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

A 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
The service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Good luck!

Posted on Jan 02, 2017

  • 740 Answers

SOURCE: squeaking noise from front end in cold weather

Bad ball joints. check out front end and make sure nothing else is bad. Good lucka nd thanks for using FIX YA

Posted on Mar 03, 2009

Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

How to remove and replace passenger side mirror on a 2014 ford fusion

Replace Your Car Passenger Side Mirror - How To - DIY ...

? 3:46
Apr 10, 2012 - Uploaded by GregHint
See how even a novice can repair a passenger mirror on a FordEscape. ... Replace Your Car Passenger Side Mirror - How To - DIY .... Replace 2003-2008 Toyota Corolla Side Mirror, How to Change Install 2004 2005 2006
About 22,000 results (0.61 seconds) Search ResultsHow-To: Replace Ford Fusion side mirror (HD) - YouTube? 7:27 7, 2014 - Uploaded by Derrick HardingFord Fusion SEL 3.0 Liter V6 How to fix broken side mirrorIncludes: ... Published on May 7, 2014 ..... Great instructions - just replaced the driver's side mirror on my 2007 Fusion following your instructions. ... Front brake pad replacement 2006 - 2012 Ford Fusion Lincoln Mazda Pads Rotor Install Remove ...

Jan 08, 2016 | Ford Cars & Trucks

1 Answer

I have an 06 ford fusion SEL with the 3 litre v6 and six speed automatic transmission. Its at 161000 miles currently. There is a loud rumbling nois coming from the front end. I had the tires, bearings and...

Sounds like it could be the CV joints, drive the car in reverse for a little and put steering on full lock, the noise will be a crunching sound coming from the front, if so then ist definitely the CV joint(constant velocity) joint, hope this helps

Jan 04, 2015 | 2006 Ford Fusion

1 Answer

Have a noise when driving a 1993 ford festiva.When RPM's are high no noise. but just driving. Sounds like from bck passenger side of car

does the sound go up when you trottle up?
put each wheel off the ground,put your left hand between the spring,
turn the wheel.when the bearing is bad you feel it in your left hand the trembling from that bearing.try each wheell.see iff any rubber off the excaust is good..

May 05, 2014 | 1993 Ford Festiva

1 Answer

2007 ford fusion misfire and the mechanic says i need new phasers another mechanic told me phaser sensors

Variable Cam Timing Actuators ??
on front of cams?

What sort of testing determined that?

Have you not used the correct oil & changed
it at least 4 times a year, and not over 4,500

Feb 16, 2013 | 2007 Ford Fusion V6

1 Answer

When stopped at a light or sitting talking to someone in drive, my 07 fusion has a strong vibration?

The first thing to do is check all of your fluids. Does the noise get louder as you turn the wheel at all?

Jan 23, 2013 | 2007 Ford Fusion V6

1 Answer

My 07 Fusion has 100,000 miles on it and I think I'm hearing a slight grinding noise when I make a left turn. Could this be the CV joint?

More than likely that this could be a worn CV joint needing replacement if it is a front wheel drive

Apr 26, 2011 | Ford Fusion Cars & Trucks

2 Answers

Driveline vibration

first i wound check for mud build up on the inside of the wheels

Dec 28, 2009 | 2007 Ford Fusion I4 SEL Sedan

1 Answer

2007 Hybred Camry has developed a whine

if its a loud, roaring sound then maybe wheel

Oct 10, 2009 | 2007 Toyota Camry

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

2,410 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts


Level 3 Expert

79077 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22326 Answers


Level 3 Expert

5677 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides