Question about Chevrolet Blazer

2 Answers

I need to replace the heater fan. How do I do it and where is the fuse located?

Posted by on

Ad

2 Answers

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Expert
  • 270 Answers

Chevrolet pickup trucks utilize an electric heaterfan to push hot air into the cab. Hot engine coolant leaves the engine andflows through a heater hose to the heater core, a small copper brass oraluminum radiator mounted in the vehicle's firewall. The heater fan blows airducted either from the passenger compartment or outside the vehicle, over theheater core's fins, drawing heat off the core. Electric or vacuum-controlleddoors in the interior heating system's ducting controls whether the hot air isblown at the floor, dashboard vents or against the windshield.

Location
? On a Chevy pickup, the heater fan is locatedalong the firewall inside the passenger side fender. Stand in front of thevehicle and look at the air-conditioning condenser mounted on the engine.Follow the hoses that lead back toward the air-conditioning coil. The hoseswill connect to a large fiberglass box bolted to the firewall---this is theheater case. If your vehicle was not originally equipped with air conditioning,follow the heater hoses back to the fiberglass box. The heater fan will bemounted on the left side of the heater case (your left not the vehicle's) justbehind the fender well. Removal
Beginby disconnecting the ground cable from the negative battery terminal. Loosenthe bolt on the clamp and pull the ground cable off the negative batteryterminal. Locate the heater fan and disconnect the positive and negativeelectrical leads. Take notice of which terminal on the electrical motor theblack wire is connected to. Black wiring in automotive applications representnegative or ground. The wires must be installed on the new motor in the sameposition as they were on the old. They will be attached with plastic connectorsthat can simply be pulled off the contacts. The heater fan is bolted to the heatercase with three or four hex head screws. Remove these screws and pull theelectric motor straight out. With the motor removed, you will be able to seethe plastic fan blades mounted on the back side of the motor. Remove theretaining nut that connects the fan blades to the electric motor and pull theblades off. Installation
? Installation is the reverse of removal. Beginby reattaching the fan blade to the electric motor and reinstalling theretaining nut. Then slide the heater fan assembly back into position in theheater case. Reinstall the three to four hex head screws that secure the case.Then reconnect the positive and negative electrical leads, making sure toconnect the black wire to the negative terminal. Finally, reconnect the groundcable to the negative battery terminal.

Read more: Replacing a Chevy Pickup Heater Fan ' eHow.com

Posted on Nov 09, 2010

Ad
  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Chevrolet Master
  • 1,851 Answers

Hello.
The fuse will be listed on the fuse box and most likely is part of a larger circuit. As for moving forward please contact your local dealer with the VIN number in hand an this will help you on all other issues. Check first for re-calls or service bulletins then ask for your specific cars fuse location. They have all this information with pictures they will give you free. Also ask about the fan replacement - again they will give you FREE this information/instructions along with pictures and how to tips. This is better than I can do here.

Thanks and Best of luck,
Gary @ Fixya

Posted on Nov 09, 2010

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya Mechanic can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repair professionals here in the US.
click here to Talk to a Mechanic (only for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Were is the fuse location for the the fan for a 2006 pt cruise limited ed


fuse location for the the fan Mitsy, Check the attached links,instruction and guides, Good luck
"I hope this helped you out, if so let me know by pressing the helpful button. Check out some of my other posts if you need more tips and info."
Engine cooling fan, 50 amp fuse,at the power distribution center or relay box at engine compartment.
Heat/ Defrost fan fuse number 7 inside drivers dash fuse box.

How To Install Replace AC Heater Fan Speed Resistor Chrysler Pacifica 04...

2008 PT Cruiser Fan Relay Location

Mar 24, 2016 | Cars & Trucks

1 Answer

Location for blower motor/heater/fan fuse?


Before you rip, check the 30A HEATER CIRCUIT BREAKER in the instrument panel fuse panel. The input is hot with the engine running. CB output connects directly to the heater blower motor. A cluster of heater blower motor resistors determines blower speed as selected by the blower switch in the heater control assembly. The switch setting is sent to the powertrain control module (PCM) which acts to turn the blower motor on at the selected speed.

Sep 22, 2012 | 1994 Ford Escort

1 Answer

Where is the heater core located on a 1994 chevy corsica?


the heater core for this vehicles located behind the glove box on passenger side.in order to remove it,you will need to be mechanically inclined.are you?do you have the tools to do so?8mm sockets and ratchet? you will need patience! if not,i recommend you ask your mechanic to replace it. but 1st i will ask these questions. is it the heater core? is fluid leaking onto the passenger side floorboard? that's one sign of a bad heater core. no heat? have you checked the fluid level in your radiator? does your cooling fan come on when the engine's at operating temperature? if not, then it may be a bad temperature sensor at the radiator. it may also be a bad fan relay in the main fuse box under the hood in the main fuse box[black box w/lid under the hood.lift the cover off of it and under the lid,it tells you fuse and the relay locations.if you turn your a/c on and the fan comes on,and does'nt come on when the engine gets hot,the fan sensor may be bad.the fan sensor that tells the fan to come on when the engines running hot. thank you,for choosing fixya,com!

Jan 26, 2011 | 1994 Chevrolet Corsica

1 Answer

The heater fan isn't working, on any setting, on my 2004 cavalier


You will need to replace the fuse located underneath the drivers side steering wheel. Flip the fuse box cover lid over and you will find a diagram showing where the heater blower motor fan is located. Pull the fuse out and replace it with the same number fuse.

Dec 19, 2010 | 2004 Chevrolet Cavalier

1 Answer

2001 Volvo v70. The heater/ac fan has stopped working. I have checked all fuses. Can suggest what my next step should be?


The fuse for heater/ac fan is number 36.30 amp located end of dash
If this is ok,you need to replace heater control module behind heater controls.Save money buy haynes manual,check e bay

Apr 09, 2010 | 2001 Volvo V70

1 Answer

ABS and heater fan 25 amp fuse blowing


I would try unplugging the heater fan and see if it stops blowwing the fuse.If so I would start by either replacing the blower fan or the blower motor resister which is located on the side of the heater box around where the fan is mounted.

Feb 16, 2010 | 1994 Chevrolet Cavalier

2 Answers

Where is the heater fan relay located on 1990 mercedes 190e


If the heater is not working (fan is not turning), but you are able to press the climate control buttons to activate the AC and venting, then the relay (actually this is the ACC in the dash with the buttons, there is no separate relay that controls the AC/Heater fan) is not the problem. Check the fuse box in the right side engine compartment, then check the long 3A flat fuse located in a coverd case atop the the wheel well in front of the fuse box. If these are okay, the fan motor is the problem. If the motor needs to be replaced, you'll need to remove the front cowl under the windshield, and also the windshield wiper assembly. The motors usually bind after 20+ years and need to be replaced. Sometimes, they will bind, then work again. Sometimes they'll bind and blow the long fuse. The job takes about 2 hours and the motor is about $150-$250.

Jan 10, 2010 | 1990 Mercedes-Benz 190

1 Answer

1985 honda prelude heater blower fan/fuse? problem


yes there is a fuse
what kind of nest? did something chew through a wire?
could be under dash or the fuse box under the hood if you still have it check the owners manual in the glove box dont jump steps and just replace the fan could be fruitless

Jan 16, 2009 | 1985 Honda Prelude

1 Answer

Heater fan will not run


check the heater blower motor resistor not entirely sure where it is on your vehicle but they are always located near the fan in the heater box
you may also want to check the fan speed switch as well as the heater fuse in your fuse box
Hope This Helps.Good luck

Dec 15, 2008 | 1989 Oldsmobile Ninety Eight

7 Answers

2001 BMW 525I Heater/AC Blower-Fan Motor not pushing out air


hedgehog is a final stage unit located on passenger side deep behind the radio. Replace my batt before fiding the post. did my self and part cost about 70.00 bucks but area is very tight. The fuses 75 and 76 are located behind the glove box and very difficult to get to and see. I am trying to find the solution to that as we speak.

Dec 01, 2008 | 2001 BMW 5 Series

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

367 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

77201 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22265 Answers

Ronny Bennett Sr.
Ronny Bennett Sr.

Level 3 Expert

6927 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...