Question about 2005 Dodge Grand Caravan

2 Answers

Fuel in my van

I can't get gas into my 2005 Dodge Grand Caravan. It won't go in or it will spit it back up.

Posted by on

2 Answers

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Im having a similar issue except sometimes i can fuel up and sometimes i cant. Have you tried fueling up again with out issue

Posted on Dec 20, 2013

  • Dad Z Dec 21, 2013

    It started off with being able to fill, then not. I tried different stations and that worked once then back to not being able to fill. Yet ever since I backed flow air from the canister out to filler neck, no problem. Just be careful not to over pressure anything.


  • Level 1:

    An expert who has achieved level 1.


    An expert who has answered 20 questions.


    An expert that hasĀ over 10 points.


    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 22 Answers

The usual cause for the hard fill condition is a restriction in the evaporative system hoses.
Check for a stuck closed fuel control valve. If spit back is the concern, there is a flapper door where the fill neck attaches to the fuel tank, if this flapper is not sealing properly it will allow fuel to come up the fill neck as the tank nears full. If this is condition is present a fuel tank is required to repair

Posted on Jan 09, 2009

  • Dave Dec 17, 2013

    My solution was to remove the hoses from the EVAP from the tank and use compressed air with the fuel cap off. I should have used a pressure gauge yet I heard a creek and a pop, then I could hear air coming out of the fueling neck. Took it to the pump and fueled without an issues.

  • Dave Apr 17, 2014

    Please note my solution broke the auto pump shut-off valve asI do have to manually stop the pump to prevent fueling going into the canister and stalling the vehicle after refueling. While this is not the best solution it was a lot cheaper than a new tank,


1 Suggested Answer

  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

Where is the fuel fiter?

The filter should be mounted in front of the gas tank under the van.

Jul 24, 2014 | 1996 Dodge Grand Caravan

3 Answers

Where is the fuel filter located on 2005 dodge caravan

It should be found next to the gas tank on the right side, under the sliding door of the passenger side of the van. The fuel filter is cylindrical and about five inches

May 21, 2010 | 2005 Dodge Caravan

1 Answer

Had my check engine light checked at a autozone and came up with a u110c... Any ideas for this code?

Code u110c ( no fuel level) Remove the gas cap from the van. Reinstall and make sure to give the gas cap a full 5 to 6 turns. The code set in the system was set by the gas cap not being tightened enough or a faulty fuel cap. If it continues to reset code then replace fuel cap on van. Hope this will help.

May 17, 2010 | 2005 Dodge Grand Caravan

1 Answer

Were is the fuel filter on a 2005 dodge caravan 3.3 engine

this van does not have a fuel filter, its in the tank. when you replace the fuel pump you will be replacing the filter as well

Apr 10, 2010 | 2005 Dodge Grand Caravan

1 Answer

2005 Dodge grand caravan 3.8 liters. Saturday

U may have got some bad gas, also maybe vapor lock.

Apr 27, 2009 | 2005 Dodge Grand Caravan

2 Answers

96 dodge grand caravan help me please

Check MAP sensor. If PCM gets wrong data from MAP sensor it should offset ignition timing and/or make fuel mixture too lean or too rich.

Nov 05, 2008 | 1996 Dodge Grand Caravan

2 Answers

Spits out fuel when I try to pump

For some reason, your fuel tank seems to be heating up or there is pressure within the tank. Thats why the fuel spits back..the vapours inside cause the filling mechanism to reject the filling apparatus.

It could also be a block in the fuel lines, or some other reason. Its too hard to say without a manual inspection.

My best advice would be to take it to your mechanic and have him take a look at it to diagnose the exact problem.

Should you find this advice satisfactory, kindly take a moment to "Accept" this solution. Thanks in advance and best of luck!


Jun 08, 2008 | 2005 Dodge Grand Caravan

2 Answers

Dodge grand caravan 2005

Sounds like the hose has collapsed. To my knowledge you will have to get that from the dealer, or at least all the parts houses here can't/wont get them....

Jun 06, 2008 | 2005 Dodge Caravan

Not finding what you are looking for?
2005 Dodge Grand Caravan Logo

1,004 people viewed this question

Ask a Question

Usually answered in minutes!

Top Dodge Experts


Level 3 Expert

71694 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22082 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7031 Answers

Are you a Dodge Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides