Question about 2003 Dodge Caravan

1 Answer

The fan on my dashboard is not working. I am thinking of replacing it with a used one from a junk yard except I dont know where is located.

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Dodge Master
  • 7,772 Answers

It's behind the glove box. here are procedures from autozone.com:

CAUTION The Supplemental Inflatable Restraint (SIR) system must be disarmed before removing the blower motor assembly. Failure to do so may cause accidental deployment of the air bag, resulting in unnecessary SIR system repairs and/or personal injury.

  • Disconnect and isolate the negative battery cable, then wait 2 minutes before proceeding with the removal. This will effectively disable the air bag system preventing possible personal injury.
Remove the glove box from the instrument panel.


The fan on my dashboard is not working.  I am - 17baf45.gif


Fig. The blower motor is located behind the glovebox, behind the blower motor cover


  • Remove the A/C-heater blower motor cover.
  • Disconnect the blower motor wiring connector.
  • Remove the blower motor wiring grommet and feed the wiring through the blower motor housing.
Remove the blower motor mounting screws.


41198be.gif


Fig. Once the cover is removed, unplug the electrical connector and push it through the opening in the housingThe fan on my dashboard is not working. I am - 803e435.gif />


803e435.gif

Fig. The blower motor is secured to the housing with three small screws


Allow the blower motor assembly to drop downward to clear the instrument panel and remove from vehicle.


To install:

  1. Place the blower motor assembly into position on the A/C-heater unit and tighten the mounting screws.
  2. Route the blower motor wiring through the blower motor housing and seat the wiring grommet in the hole of the blower motor housing.
  3. Reconnect the blower motor electrical connector.
  4. Install the A/C-heater blower motor cover.
  5. Install the glove box into the instrument panel.
  6. Reconnect the negative battery cable. Check blower motor operation.

Posted on Oct 15, 2010

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

The heater fan quit working. How do I replace the fan?


Did you check if you are getting voltage to the fan motor? There is a small circuit board located near the fan motor (under the dashboard, passenger side) I have had 2 escorts and both had the circuit boards go bad. you can get one cheap at a junk yard

Mar 22, 2013 | 1997 Ford Escort

1 Answer

I replaced the front blower resistor, now the blower will not regulate, it blowes all the time.


similar problem recently on an '02 sable.it was the EATC--Electronic Automatic Temperature Control module,located behind the dashboard,it has vacuum tubes and many wires connected to it.check vacuum lines for a leak,but the lack of fan speed control points to the auto module.Ford wanted $300,found one in a junk yard for $50.Good luck

Jan 21, 2013 | 2005 Chrysler Town & Country

1 Answer

Hello everyone , i have a 2000 jgc at these time i dont have heat fan is not working? how i can fix it?


If you don't have a blown fuse, the fan motor may be broken. You may have to replace fan motor. Please check at a junk hard first. I had the same problem once with my '95 Rodeo. I got a replacement at a junk yard that is working very good ever since.

Mar 01, 2010 | 2000 Jeep Grand Cherokee

2 Answers

Rear suspension problems, rusted out


so..... what is your question. if its rusted out it obviously needs replaced. You can either take it too a mechanic and let them replace it or you can to to a used parts location (ie. junk yard) get the parts pulled that you need, take them home and replace them your self. if your planning on taking it to a mechanic bc you dont want to deal with it or bc you dont know how, sometimes it is cheaper just to purchase another vehicle.

Nov 09, 2009 | 1991 Chevrolet K1500

2 Answers

AC electric fans do not work???


First, hot wire the fan motor to the battery. If it works, then locate the relay in the power distribution center and change it. Also check any fuses related.

Jun 08, 2009 | 1999 Jeep Cherokee

4 Answers

Gas tank won't open, trunk won't open, radio stopped working, left tail lamp won't work


It's the body control module. It's located under the dash to the left of the steering column. I had same problem, went to the junk yard and bought one and the problem went away. Dealer wants $600.00-700.00 for the BCM, I paid $30.00

May 30, 2009 | 2001 Cadillac Catera

1 Answer

1999 gmc jimmy. The heater control is stuck on HOT.


if the knob wont move replace it junk yard may have used part but if it moves and hot air keeps blowing out u may need a servo that opens and closes heater box door under dash i dont think that trucks system works off vacuum but if it does it probably electronic related problem inquire junk/salvage yard about knob and servo for heater box door and problem it may be common and u may get info if he,s a nice guy

Mar 28, 2009 | 1999 GMC Jimmy

1 Answer

Air conditioner fan not blowing


its the whole panel.go to a junk yard or on e bay and replace it

Sep 09, 2008 | 1998 Dodge Intrepid

Not finding what you are looking for?
Cars & Trucks Logo

294 people viewed this question

Ask a Question

Usually answered in minutes!

Top Dodge Experts

yadayada
yadayada

Level 3 Expert

75077 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7768 Answers

Are you a Dodge Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...