Question about 2004 Chevrolet Silverado
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Posted on Jan 02, 2017
You have dual zones that are controlled by temperature actuators the passenger side has lost its memory or has gone bad you can put it in self programming by disconnecting the battery for ten minutes then hook it back up start the truck turn the temperature control on but do not touch any other controls let it go thru the self programming for about 6 to 7 minutes then select your temperature you want if it still does not work properly you may have a bad actuator or a bad connection at the actuator
Posted on Jun 03, 2009
It sounds like your electronic vent actuator has gone bad, it's common to go bad and may need to be replaced. There are tinny gears that wear out and the vent actuator stops working. You can try this, turn the radio off first so you don't have to enter the reset code to activate your radio. Disconnect the battery for 30 seconds and reconnect it, if the actuator has lost it's base line and stuck in the open heat position, this will reset it, just make sure the setting is to cold and off before disconnecting and reconnecting the battery. If this does not work, then it's a bad actuator and Auto Zone should have the part you need and will have the step by step instructions for you to the job you self, I believe the dealer is a $415,00 repair cost for this. Good luck and keep me posted.
Posted on Jun 22, 2009
Its more then likely the temp door broken or temp door motor broken/stuck. There is 2-3 of these motors under the dash on the side of the evap/heater core box. Some require extensive labor to replace, good luck
Posted on Jul 29, 2009
The requirement is 10 QTS. I use 10 and check it cause some times they hold 11 QTS. I hope this helps. If you have more questions reguarding this or other conserns please ask me. Please remember high ratings are very important to me.
Posted on Aug 28, 2009
Testimonial: "Thanks very much for that Regards Bryan McRae New Zealand"
GM has a known problem with the electric actuators that operate the blend and temperature doors in the HVAC system. There are 4 or 5 of these in the typical system. Any can start sticking or binding and cause this problem. Sometimes they can be cleaned, or they might need to be replaced. Sometimes resetting the HVAC system controller by disconnecting the battery for 10 minutes, then reconnecting it, will correct the problem.
Posted on Sep 15, 2009
Tips for a great answer:
Feb 11, 2017 | 2004 Chevrolet Silverado
Jul 26, 2016 | 2004 Chevrolet Silverado 2500HD
Jan 11, 2011 | 2007 Dodge Grand Caravan SXT Minivan
Dec 27, 2010 | 2004 GMC Sierra
Oct 20, 2010 | 2007 Chevrolet Silverado Classic SS New...
Sep 17, 2009 | 2004 Chevrolet Monte Carlo
Aug 25, 2009 | 2004 Chrysler Pacifica
Jul 14, 2009 | 2000 Mitsubishi Eclipse
Dec 15, 2008 | 2004 Chevrolet Silverado
252 people viewed this question
Usually answered in minutes!