Question about 1998 Chevrolet Cavalier

Open Question

How much will it cost to fix my fuel filler neck gas tank pipe on my 1997 cavalier

Posted by on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

wireguy212
  • 1627 Answers

SOURCE: gas filler neck replacement

open the fuel cover and remove the bolts.Remove the ground strap from the filler tube from under the car.Remove the hose clamps to the rubber hose going into the tank and pull off the hose.Now the filler tube will come out[ if has'nt already fallen out and hit you in the head].

Posted on Nov 18, 2009

michigan man
  • 3533 Answers

SOURCE: cant fill gas tank

if you would give these guys a call and maybe they have an answer for you they sells only GM-parts and its Schram auto & truck Parts 1-800-292-1032 and they website is www.schramauto.com and try this website also its www.alldatadiy.com and maybe you be able to get some information there.

Posted on May 29, 2009

scottyoung56
  • 89 Answers

SOURCE: gas cap is contacting inside of filler neck

YES IT CAN FROM THE RUBBER HOSE UP TO WHERE YOU PUT THE GAS IN

Posted on Aug 08, 2009

jim9813
  • 124 Answers

SOURCE: Replacing fuel filler neck on 2000 Crown Vic

Good news, no the tank doesn't have to come down. However, there needs to be less than 3/4 tank. Jack it up and set on a jack stand, remove the wheel, four screws housing to pipe, filler pipe sensing hose from filler pipe, screw retaining the cap, four retaining screws from filler pipe, screw from filler pipe retainer, slide into the tank until it can be rotated and pulled out through the fender. lube the tank grommet with clean oil and reverse the removal for install.

Posted on Aug 21, 2009

  • 169 Answers

SOURCE: gas leak on fuel filler neck

if it's a hose or pipe go to dealer or junk yard get another if broken clamp replace if neck part of tank call rad shop see if the can solder if you drain & pull tank

Posted on Aug 30, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Air does not come out of vents Gas tank is full


The vent pipe is bad coming from the filler neck hose. Replace it as a unit. The 1/2 tank reading is a defective sending unit. The are notorious for coming apart in the tank.

Oct 20, 2014 | 1997 Volvo 960

1 Answer

Fuel filler neck


Hi I'm Peter, Not sure what your problem is from just posting fuel filler neck however I am assuming you have a strong gas smell. The rubber hose that connects the filler pipe on the tank to the fuel spout may be cracked and leaking. Another common problem is the tank vent tube that runs from the tank up along side the filler tube may be rubbing on the metal part of the tube and has a hole in it. This will give you the strong fume smell and possible fuel leak as will the rubber filler tube when the tank is full. These vehicles are known for this problem and also the metal filler pipe rusting causing a pin ole. Look to see if you can see rust anywhere . Even if you don't see rust on the outside does not mean there is not rust on the inside. I have seen where a lot of people have been have the rust issue also to the point they carry the part at auto parts stores . Hope this is what you needed.

Apr 16, 2014 | 1997 Nissan Maxima

2 Answers

2006 mercury mountaineer,when putting fuel in it the gas pump keeps shutting off like it full,but its not


There is a vent hose that comes from the tank back to the filler neck, it could also be the filler neck hose. Might be kinked or seperated.

Jan 23, 2013 | 2006 Mercury Mountaineer

1 Answer

I am trying to syphon gas from my 99 Cavalier with a fluid transfer pump.when I run the hose down the filler neck I meet resistance and try to pump only getting small sprays of gas.Do the '99 model's have...


Yes, virtually all cars have them these days. You will not get any fuel out of the filler cap. There are some places you might get access to the tank contents like the outlet to or from the pump, the rubber connector that connects the filler pipe to the tank or the fuel pump if it is mounted in the tank and is accessible under the back seat.

Mar 11, 2011 | 1999 Chevrolet Cavalier

2 Answers

Fix fuel pump


Removal & Installation To Remove:
  1. Properly relieve the fuel system pressure.
  2. Drain the fuel tank through the filler pipe.
  3. Support the fuel tank.
  4. Remove or disconnect the following:
    • Negative battery cable
    • Filler neck
    • Shield and tank straps
    • Fuel lines and vapor hose from pump and tank
    • Electrical connection from fuel pump
    • Fuel tank
    • Fuel pump/sending unit assembly by turning the locking ring (located on top of the fuel tank) counterclockwise using a spanner wrench
    • Fuel pump from the fuel lever sending device
To Install:
  1. Install or connect the following:
    • Fuel pump in tank with new seal around opening
    • Tank and connect fuel lines and vapor hose
    • Tank to the frame
      1. Torque to: 33 ft. lbs. (45 Nm)
    • Shield
    • Fuel filler neck and clamp
    • Negative battery cable
  2. Refill the tank.
  3. Run the engine and check for leaks.
View of the in-tank fuel pump assembly. 7924jg21.gif

prev.gif next.gif

Nov 06, 2010 | 1997 GMC Jimmy

4 Answers

Gas leak on fuel filler neck, how can I fix this?


if it's a hose or pipe go to dealer or junk yard get another if broken clamp replace if neck part of tank call rad shop see if the can solder if you drain & pull tank

Aug 30, 2009 | 1995 Buick Regal

1 Answer

Replacing fuel filler neck on 2000 Crown Vic


Good news, no the tank doesn't have to come down. However, there needs to be less than 3/4 tank. Jack it up and set on a jack stand, remove the wheel, four screws housing to pipe, filler pipe sensing hose from filler pipe, screw retaining the cap, four retaining screws from filler pipe, screw from filler pipe retainer, slide into the tank until it can be rotated and pulled out through the fender. lube the tank grommet with clean oil and reverse the removal for install.

Aug 21, 2009 | 1996 Ford Crown Victoria

3 Answers

1999 CAVALIER WON'T TAKE GAS INTO TANK


After researching this for a lot of vehicles is this:

A ventilation line or the filler hose/neck/tube has possible damage. The only way to know is to drop the tank and inspect the lines going to and from the gas tank to the filler neck where you put the fuel pump nozzle in. If the neck has not been installed correctly, i.e., is twisted or dented/bent, this will cause the problem you are having.

If you can drop the tank and inspect these items, let us know what you find.

Mar 23, 2009 | 1999 Chevrolet Cavalier

1 Answer

Cant put much gas in tank w/o it coming back out


It souds like the air return line from the fuel filler pipe is plugged. When you fill up the car the air has to escape from the tank or else the fuel backs up into the filler neck shutting off the fuel nozzle. The air pipe is housed in the fuel filler pipe and lets the air escape as the fuel is going into the tank. Remove the filler neck and inspect air bypass line to see if it is kinked or plugged.

Mar 10, 2009 | 2001 Chevrolet Impala

Not finding what you are looking for?
1998 Chevrolet Cavalier Logo

Related Topics:

665 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

75066 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7754 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...