Question about 2002 Volkswagen Eurovan

Open Question

How to change the belt on the fuel injector pump on vw lt35 2002 5 cylinder 2.5 litre diesel

Posted by on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 16 Answers

SOURCE: 2003 vw jetta tdi fuel filter

It is on the passenger side right behind the washer fluid fill tube. You can follow the fuel lines (look like 1/4" black tubes, some are clear) from the injector pump to it. It is a caniser a bit bigger than a normal looking oil filter and sits between the washer bottle and the metal that forms the wheel well. It is held in by a screw type clamp about half way down the cylinder. Probably isn't the fuel filter unless there is air in the lines to the injector pump or they didn't bother to fill the fuel filter up with diesel after putting it in. There is not a fuel pump in the tank in these cars so everything is sucked up by the injector pump and it needs to be primed properly.

Posted on Sep 11, 2008

Ad
  • 341 Answers

SOURCE: VW Golf Mk3 1997 diesel fuel pump replacement

1993–99 Cabrio, Golf, and Jetta

  1. Remove the negative battery cable.
  2. Raise and safely support the vehicle.
  3. Relieve the fuel system pressure.
  4. Remove the rear seat and the access cover.
  5. Disconnect the wiring and hoses.
  6. Remove the fuel lines from the pump.
  7. On 1993–99 Golf, Jetta and Cabrio vehicles, unscrew the fuel pump retaining ring.
  8. On all other models, remove the mounting bolts and the fuel pump.
  9. Carefully lift out the pump and gauge sending unit assembly.
  10. Empty the fuel pump into an approved container.
To install:
  1. Installation is the reverse of removal. Be sure to use new sealing rings and/or gaskets.

Posted on Nov 29, 2008

  • 334 Answers

SOURCE: VW LT35 / hard starting when hot

have you check your fuel filter. and how hot dose the motor get when it start hard.no motor like to start when they are hot. check your fan relay. and check your coolnt ok. good luck have a nice day

Posted on Apr 18, 2009

alicantecoli
  • 22246 Answers

SOURCE: 1996 VW polo diesel fuel pump

easy to change its on top of the injector pump ,but you may have a antitheft shroud around it which means removing the pump from the engine to get get the shroud off

Posted on May 07, 2009

  • 94 Answers

SOURCE: Retiming of vw transporter diesel pump

This requires the use of a special VW tool called "the indicator tool". Visit this site to buy it:

http://www.partsplaceinc.com/catalog/vw-specialty-tools-diesel-tdi-timingtools55.shtml

You will also need to buy a repair manual for your car so you can get the appropriate timing setting for the pump. I recommend the Bently manual:

http://www.bentleypublishers.com/vw/eurovan/1992-2003/VW-Eurovan-92-99-Factory-Repair-Manual.html

It's expensive but worth it. If you don't want to spend that much, you may find pump timing information in a Haynes or Chilton manual which can be purchased on Amazon or at your local Autozone.

Good luck.

Posted on Jul 08, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2010 jeep patriot 2 litre diesel timing belt interval


this is a USA forum and we dont have that engine.
most cars is 60k, some are 90k miles. (93k miles = 153km)
the 2.0 L VW I4 (t/c diesel) turbo diesel right?
it's the VW engine.
vw: name.
1968 cc2.0 R4 8v TDI PD 47-103kW
called the 2.0 CRD on a jeep.

your, operators guide don't cover that, under normal maintenance?
odd. it does here. On most cars.
see this ?
http://www.jeeppatriot.com/forum/showthread.php?t=269570

150kmeter. belt service. ( google works for me )

Feb 24, 2015 | Jeep Cars & Trucks

2 Answers

Will a 2 litre vw Golf 2011 diesel fit a 1.6 diesel 2011 Golf


I wouldn't suggest it. It wouldn't be just an engine swap that you unplug and unbolt and and then reverse...thats not to say it can't be done with a lot of thinking and work and reprogramming that's usually for vw experts...your better off to keep looking at other wreckers for the exact motor

Nov 08, 2014 | 2011 Volkswagen Golf

2 Answers

Engine turns over on my 2003 Jetta 1.9L TDI but does not start. New battery , all lights are working. Changed fuel fillter and put diesel in it to wet it, but still does not start. It did start once and...


When were the glow plugs last changed?

They sit over the cylinder like spark plugs and warm the diesel before it goes into the inlet manifold, greatly assists starting.

May 17, 2010 | 2003 Volkswagen Jetta TDI

4 Answers

6.5 litre diesel engine, blowing lots of black


my 1995, 6.5 diesel turbo just shuts off when running

Oct 01, 2009 | 1997 GMC Sierra

2 Answers

Retiming of vw transporter diesel pump


hi there if you remove the cam pully wich drives the diesel pump you will see a key way in the end of the cam turn the engine untill the key way is flat ( i use a streight edge in the keyway and turn until it is level with the top of the cylinder head ROCKER COVER REMOVED once this is aligned up there is a mark o the back of the diesel pump pully thiss aligns up with a groove between two castings on the side of the pump at the front of the engine once all these are aligned up you can put on the belt ( it may ot start right away this wil be due to needing to bleed up the fuel ONLY IF PUMP BEEN REMOVED and bleeding up the fuel can be a right pain. hope thos helps ben

Jul 07, 2009 | 1993 Volkswagen Eurovan

1 Answer

1996 VW polo diesel fuel pump


easy to change its on top of the injector pump ,but you may have a antitheft shroud around it which means removing the pump from the engine to get get the shroud off

Apr 09, 2009 | 1996 Volkswagen Golf

2 Answers

2003 vw jetta tdi fuel filter


It is on the passenger side right behind the washer fluid fill tube. You can follow the fuel lines (look like 1/4" black tubes, some are clear) from the injector pump to it. It is a caniser a bit bigger than a normal looking oil filter and sits between the washer bottle and the metal that forms the wheel well. It is held in by a screw type clamp about half way down the cylinder. Probably isn't the fuel filter unless there is air in the lines to the injector pump or they didn't bother to fill the fuel filter up with diesel after putting it in. There is not a fuel pump in the tank in these cars so everything is sucked up by the injector pump and it needs to be primed properly.

Jun 25, 2008 | 2003 Volkswagen Jetta TDI

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

579 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22246 Answers

yadayada
yadayada

Level 3 Expert

76846 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8560 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...