Question about 2005 Ford F 350 Super Duty

Open Question

05 f350 fuel pump where is it loocated - 2005 Ford F 350 Super Duty

Posted by on

5 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

michigan man
  • 3533 Answers

SOURCE: f350 no start

I have a feeling you got a wholed of unleaded fuel or bad fuel
I drive a diesel box truck the station I always took it to the fuelman put unleaded in the diesal tanks and the truck just died it had to have the gas tank completed drained and cleaned out but also ask yourself how many miles are on it and when was last tune up and if you live in a cold climate I recommend a heater block plug

Posted on Jan 04, 2009

DIESELMUDDER
  • 2760 Answers

SOURCE: replace fuel pump on 03 Ford F350 diesel

simple : obtain replacement pump from parts provider (no used stuff)

Now help me out here: thats the year they were bolted to the pass side front of engine
and not inside the tank right? (better go look to see for sure)

using a tube wrench unscrew the fuel lines (i use large wire nuts to temp block off fuel leakage)

with a 12 mm wrench undo the two side bolts holding the pump to block

wiggle pump it should come straight off

clean mounting place on block with solvent let dry

silicone back (or use gasket that comes with pump ) of pump

apply pump to block (depending on where crank stopped you may have some tension on arm you will have to overcome to get flange to meet block )

use locktite (blue)or simmiliar thread lock on bolts retighten firmly but not hang up the dog tight

use light grease or vasolene on tube connections don't try to tighten dry

Now the fun part your diesel now has air in the fuel system

there are two ways to remove this ( hard and harder)
your choice here are both methods

loosten the fuel supply line for #8 injector ( I did not say remove) 1 full turn ought to be enough

crank engine 30 seconds only
wait 5 minutes for starter to cool down
crank engine 30 sec again
did it start but runs rough while it's still running tighten #8 injector (caution fuel under high pressure)
engine smooth out good your lucky
engine did not start yet
wait 5 minutes
crank engine 30 sec again
start yet
if so tighten #8 injector up

Now here's something I've done to my diesel to make this much less a hasstle

trace fuel line as it comes up from pump
obtain a small low pressure electric fuel pump and a two short pieces of fuel line
and a few clamps

use tube cutter and cut fuel line just before it bends to go in filter
deburr edges
slide tube and clamps over pipe (both sides)
insert pump observe flow arrrow towards filter

the wires of pump can be stretched over to #1 battery terminals

now any time you change a filter or open your fuel system for any reason
all you need do is connect pump to battery
open sharader valve on top of filter for a few min
and start truck as normal
then disconnect wires and stow away for another day

Posted on Jul 08, 2009

  • 130 Answers

SOURCE: install fuel pump 1974 f350 460

first disconnect the battery then disconnect the fuel lines from the pump remove the 2 bolts remove pump the reverse procedure remember to put a dab of grease on top of the arm that goes inside the engine

Posted on Jul 12, 2010

  • 1 Answer

SOURCE: location of fuel pump on 1988 Ford F350 460 engine

there could be 2. one is in the tank,this one is there for sure. the other is in the frame rail ahead of the switching valve,if you have 2 tanks.Otherwise look for a cylinder with fuel lines and 2 wires.the fittings on inline fuel pump might take a special tool,they will look like a bell.that tool can be bought at parts store, should be under $15.

Posted on Jul 13, 2012

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

My 05 f350 6.0 diesel gelled and now has a miss on exeleration


Drain water from fuel bowl.

Use Amsoil Diesel Recovery Emergency Fuel Treatment to treat fuel.

Jan 11, 2014 | Cars & Trucks

1 Answer

On 2003 Ford F350 6.0 diesel where is the fuel pump relay?


Hello freefallcrus
The fuel pump relay for the 2003 f350, is an integral part of the central junction block(fuse box) located under the left side of the dash. So in order to replace the relay, you would have to replace the junction block. Hope this is helpful.

Aug 31, 2011 | 2003 Ford F350 Super Duty DRW SuperCab

1 Answer

Install fuel pump 1974 f350 460


first disconnect the battery then disconnect the fuel lines from the pump remove the 2 bolts remove pump the reverse procedure remember to put a dab of grease on top of the arm that goes inside the engine

Jul 12, 2010 | 1979 Ford F 350

1 Answer

Need to know where the fuel pump location is on a 1997 Ford F350 Powerstoke


The fuel pump is in the valley on top of the engine behind the fuel filter

Apr 12, 2010 | 1997 Ford F350 Crew Cab

1 Answer

05 f350 will crank but wont start changed fuel filters bled fuel made sure im getting fuel on top of motor


Have you checked the HPOP? You need to hook a guage and check your high pressure pump to see if it is putting out pressure. These units are prone to failure becaue they have such close tolerances inside of the pumps. Diangosis of these tuck is not for the back yard guy so be careful if you do not know these units or what they do. This system puts out i believe 1200 psi. The system is called a heui. Hydraulic Electronic Unit Injection. It is the high pressure used to fire the injector. You may be getting fuel but if you have no "plunger" so to speak to fire the injector you will get nothing. Also check Your IPR for a broken wire or a short.

Feb 09, 2010 | 2005 Ford F 350 Super Duty

1 Answer

Which fuse is the fuel pump fuse 1996 ford f350?


here you go, it in manual

https://www.fleet.ford.com/maintenance/owners_manuals/default.asp

Jun 05, 2009 | 1996 Ford F350 Crew Cab

1 Answer

My f350 just stops some times and is not getting fuel


Your fuel pump may be starting to go. The inertia swtich is just in case the truck gets hit. It shuts off the fuel flow. Could aslo be the fuel pump relay or computer power relay. I would check for fault codes stored in the computer. An auto store may scan for free.

Mar 12, 2009 | 1992 Ford F350

1 Answer

F350 T/D 4WD CRANKS BUT WON'T START


are the batteries fully charged? Low voltage will keep vehicle from starting the fuel pump is on the frame rail below the drivers door you can check the voltage at the pump it could also be fuel pump relay

Mar 01, 2009 | 2002 Ford F350 Super Duty DRW Reg. Cab

1 Answer

F350 no start


I have a feeling you got a wholed of unleaded fuel or bad fuel
I drive a diesel box truck the station I always took it to the fuelman put unleaded in the diesal tanks and the truck just died it had to have the gas tank completed drained and cleaned out but also ask yourself how many miles are on it and when was last tune up and if you live in a cold climate I recommend a heater block plug

Dec 18, 2008 | 2005 Ford F 350 Super Duty

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

81 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

75797 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22114 Answers

fordexpert

Level 3 Expert

5495 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...