Question about 1993 Volkswagen Golf

1 Answer

How to fit a fuel pump in golf mark 3 cl - 1993 Volkswagen Golf

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Volkswagen Master
  • 6,826 Answers

REMOVAL & INSTALLATION NOTE: On CIS systems the main fuel pump is located under the vehicle in front of the rear axle or in front of the tank on the right side. 1990–92 Cabriolet, Golf, Jetta and Fox TRANSFER PUMP

  1. Remove the rear seat and the access cover.
  2. Disconnect the wiring and hoses and unscrew the lock ring.
  3. Carefully lift out the pump and gauge sending unit assembly.
  4. When installing the assembly, use a new seal.
MAIN PUMP
  1. Disconnect the negative battery cable.
  2. Relieve the fuel system pressure.
  3. Raise and safely support the rear or right side of the vehicle on jack stands.
  4. Disconnect the wiring from the pump. Clean any dirt away from the fuel line fitting.
  5. Use locking pliers to pinch off the fuel line from the transfer pump to the main pump. If the fuel line is metal, remove the rear seat and access panel and disconnect the line at the transfer pump.
  6. Place a pan under the pump and disconnect the fuel line fitting from the pump.
  7. Remove the retaining ring screws and slide the pump out of the reservoir. To install:
  8. Moisten the pump O-ring with a little fuel and slide it into the reservoir. Install the retaining ring screws.
  9. When connecting the fittings, use new copper washers and tighten the fittings to 15 ft. lbs. (20 Nm).
1993–99 Cabrio, Golf, and Jetta
  1. Remove the negative battery cable.
  2. Raise and safely support the vehicle.
  3. Relieve the fuel system pressure.
  4. Remove the rear seat and the access cover.
  5. Disconnect the wiring and hoses.
  6. Remove the fuel lines from the pump.
  7. On 1993–99 Golf, Jetta and Cabrio vehicles, unscrew the fuel pump retaining ring.
  8. On all other models, remove the mounting bolts and the fuel pump.
  9. Carefully lift out the pump and gauge sending unit assembly.
  10. Empty the fuel pump into an approved container. To install:
  11. Installation is the reverse of removal. Be sure to use new sealing rings and/or gaskets.
how to fit a fuel - prev.gif next.gif

Posted on Aug 19, 2010

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Golf mk4, 1.6 akl engine


Fuel supply to filter, filter to pump, pump to regulator, regulator to engine. you good?

Aug 27, 2012 | 2002 Volkswagen Golf

1 Answer

Are VW Golf fuel pumps the same? do they fit in all vw models?


The actual pump is the same, however the pump is part of a fuel pump module aseembly and that is diffrent from year to year and model to model

Jun 01, 2012 | 2001 Volkswagen Golf

2 Answers

Car lazy to start


Hey bro, your diesel pump might be on the way out but here are some things to check and do and see if they help.

Replace the hoses going from the pump to the diesel filter with new ones.

Use fuel injector type clamps, NOT gear clamps they don't tighten enough to stop air not getting in.

Change the diesel filter, and make sure the drain on the bottom of it, if it has one which most do, is nice and tight.

Air bubbles in the injection lines are usually a sign of a weakening injection pump but I ran mine like that for a long time, the air works it's way through. Are you leaking any diesel? Maybe check the returns to the tank. Cheers bro.


Mar 29, 2010 | 1995 Volkswagen Golf

1 Answer

How to fit a fuel pump to a golf vr6 1994


The pump is in the fuel tank. It can be accessed under the right side of the rear seat. 6f73d2f.jpg


Disconnect the lines and wiring harness and turn the big black 7398ffe.jpgplastic locking nut counter clockwise till its loose. Pull the pump unit out straight up and reverse procedure to reinstall.

Feb 28, 2010 | 1994 Volkswagen Golf

1 Answer

Does the vw golf 1994 cl diesal 1.9 model have


they sold em both ways with or without! just look donw the front of the motor see if theres a power steering pump on it

Jan 22, 2010 | 1994 Volkswagen Golf

1 Answer

Where is my fuel filter located on my 91 VW golf 1.8L hatchback? and how do i change it?


The fuel filter is under the car next to the fuel pump reservoir and looks like a large, metal container. Arrows point the direction of fuel flow through the filter. Banjo type fittings with copper gaskets connect the fuel lines to the filter. Always replace these gaskets any time the fittings are loosened.



Follow the replacement procedure below to change out the existing filter.

1. Relieve the fuel system pressure.

2. Raise and safely support the rear of the vehicle. Have a pan ready to catch the fuel that will run out of the reservoir.

3. Have a rag handy and wear safety glasses when loosening the fittings. The system will be under pressure and fuel will be sprayed.

4. Hold the filter with a 19mm or 22mm wrench and loosen the fittings with a 17mm wrench. Wrap the filter and wrenches with a rag to contain any pressurized fuel. Have the catch pan ready.

5 Disconnect the fuel lines, loosen the mounting bracket and remove the filter.

6 Install the new filter but do not tighten the mounting bracket yet.

7 Make sure all fittings and sealing surfaces are clean. Install the banjo bolts with new copper gaskets and torque to 14 ft. lbs. (20 Nm).

Nov 11, 2009 | 1991 Volkswagen Golf

1 Answer

Iv got 1994 golf cl it loses power then cuts out but starts up after 30 seconds or so dose this every couple of miles


sounds like a faulty relay on the fuse box for fuel pump if its electronic fuel pump

Aug 24, 2009 | 1994 Volkswagen Golf

1 Answer

1997 golf cl 1.8 L Starts ok then dies. ok above 1900 rpm


Sounds like censor issues. Have diagnostics run on the vehicle to find the culprit.

Apr 25, 2009 | 1997 Volkswagen Golf

1 Answer

1996 VW polo diesel fuel pump


easy to change its on top of the injector pump ,but you may have a antitheft shroud around it which means removing the pump from the engine to get get the shroud off

Apr 09, 2009 | 1996 Volkswagen Golf

1 Answer

Need procedure to R&R oil pump on 99 VW golf cl


petrol or diesel,remove the sump and you will see the oil pump and strainer,remove the four bolts holding the pump and then remove,refit is reverse of removal

Jan 10, 2009 | 1999 Volkswagen Golf

Not finding what you are looking for?
1993 Volkswagen Golf Logo

757 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22246 Answers

yadayada
yadayada

Level 3 Expert

76846 Answers

Jeffrey Turcotte
Jeffrey Turcotte

Level 3 Expert

8548 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...