Question about 1989 Chevrolet Astro Cargo
#1 NEED TO VERIFY SPARK AT SPARK PLUGS # 2 CK FUEL PRESSURE AT SCHRADER VALVE ON FUEL RAIL ,,PRESSURE DEPENDS ON TYPE ENGINE ....IF NO SPARK AT SPARK PLUGS CHECK SPARK FROM COIL WIRE , IF NO SPARK AT COIL ,CHECK VOLTAGE TO IGNITION COIL SHOULD BE 12 VOLTS, IF NO VOLTAGE AT COIL ( KEY ON ) CHECK FUSES THEN IGHITION SWITCH. IF NO FUEL PRESSURE AND FUEL PUMP RUNS REPLACE PUMP .. CK VOLTAGE TO FUEL PUMP WHILE CRANKING . CK USING PUMP GROUND WIRE AT THE PUMP CONNECTOR THIS WILL PROVE GROUND ALSO. USE TEST LIGHT TO VERIFY
Posted on Aug 07, 2010
Do you have a Bypass Ignition System or a Non Bypass Ignition System?
Posted on Jun 07, 2014
I have a 1989 astro van i cant get power to the fuel pump and injectors i tested the wireing that powers the ecu computer and its getting power but noting from the ecu out to pump or injectors please help if any one could
Posted on Oct 10, 2010
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
SOURCE: 2000 astro van won't start
What you have to do is check and see if you have fuel pressure.You have to remove the engine cover to check it.If you don`t have a pressure tester then remove the air cleaner hose to the engine and spray it with carb.cleaner or brake cleaner.If it starts for a few seconds then it is more than likely a fuel pump.If it does not start then you have to check for spark at the spark plugs.Make sure you check more than one plug.If no spark then you have to check the distributor cap and rotor.Make sure the rotor is good and cap also.Things that can cause no spark are the ignition module,coil,and cap and rotor.Hope this helps.Good luck.
Posted on Jan 29, 2010
I have a 1986 Chevry Astro Van that I learned abot the hard way that was doing what yours is doing. In my case, after being ripped off by one fast buck mechanic after another, i learned it is the oil pump computer that probably needs to be replaced. If it does not read the right oil pressure, it won't start. But, what myinsance mechanic did was to run a wire from the ignition to the starter, etc. Cost was $11.--/ after he first pt in a starter, fuel pump, new main engine compter, etc, none of this helped it start. Then he did the hot wire thing, bypassing the oil pump computer. I undersatnd that compter is about $65.00. I got ripped off to the tune of 1,000.00 befoer thru trial and error the real cause was discovered.
Posted on Apr 07, 2009
Check to see if the fuel pump is kicking in,
when you turn the key on without starting the van you should hear it kick on for about 2 seconds,
It could be...
A clogged fuel filter...
Blown fuse for the pump..or bad pump relay..
Bad fuel pump
Posted on Mar 07, 2009
Tips for a great answer:
Jan 14, 2018 | Cars & Trucks
May 14, 2017 | Cars & Trucks
Dec 28, 2010 | 2000 Chevrolet Astro
Aug 08, 2010 | 1994 Chevrolet Astro
Sep 24, 2009 | 1996 Chevrolet Astro
Jul 31, 2008 | 2000 Chevrolet Astro
712 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: