Question about 2001 Saturn L-Series

2 Answers

Where is the fuel pump located on a 2001 Saturn L200

Posted by on

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 516 Answers

You have to remove the gas tank you have to remove the exhaust pipes to get to the gas tank the best way to get to it is to put the car on a lift once you remove the tank you will see it on top it is one piece connected to the fuel gauge and the entire thing is inserted on the top side it is hard to get to because there is no access panel under the back seat like in japanese cars it is a pretty costly item too, good luck

Posted on Jun 01, 2010

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Saturn Master
  • 6,826 Answers

It is in the fuel tank

Posted on Jun 01, 2010

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 186 Answers

SOURCE: I need to replace the

The flasher for your turn signals is actually the hazzard switch on the dash with the red triangle.It is the hazzard swicth as well as the flasher relay!! Hope this helps

Posted on May 13, 2009

  • 12 Answers

SOURCE: fuel pump will not come on, have replace with new

check fuel pump relay, fuse or a bad ground to the relay

Posted on Nov 15, 2009

dad630
  • 10 Answers

SOURCE: looking for air pump relay location for saturn

As per the Haynes manual for your vehicle:
The various relays are mounted in several locations throughout the vehicle, although many key relays are located in the fuse/relay blocks under the intrument panal and the engine compartment.
Hope this helps!

Posted on Feb 11, 2010

duane_wong
  • 6826 Answers

SOURCE: I need to replace the fuel pump on my 2001 Saturn

Fuel Pump REMOVAL & INSTALLATION 1.9L Engine To prevent excessive fuel spillage, whenever the tank is removed from the vehicle it should be no more than 1?2 full. Removal of the fuel pump module assembly requires the removal of the fuel tank.

  1. Before servicing the vehicle, refer to the precautions in the beginning of this section.
  2. Properly relieve the fuel system pressure.
  3. Remove or disconnect the following:
    • Negative battery cable
    • Fuel feed and return lines from the filter/pressure regulator
    • Fuel pump vapor line from the fuel tank vent pipe
    • Fuel pump module retaining ring with service tool SA9156E. A 1?2 inch breaker bar will loosen the lockring
    NOTE: To prevent bending of the sending unit float arm, lift the pump module up slightly to disengage the orientation tabs in the tank. Rotate the module 90 degrees clockwise until the fuel lines are facing the 1 o'clock position.
    • Fuel pump module from the fuel tank until the bottom of the pump module is close to the fuel tank opening
    • Tilt the pump module approximately 45 degrees to the right hand side of the tank and lift the pump from the fuel tank
    • Fuel pump to tank seal and discard it
    To install:
  4. Install or connect the following:
    • Fuel pump module into the fuel tank by orientating the float to face the right side and tilting the module approximately 45 degrees
    • Fuel pump into the tank and rotate the assembly 90 degrees counterclockwise to align the module tabs with the slots in the tank
    NOTE: The fuel pump retaining ring cannot be properly installed if the flange locator tabs are not aligned with the slots in the fuel tank.
    • Retaining lockring with tool SA9156E
    • Vapor line to the fuel tank vent pipe
    • Fuel feed and return lines to the filter/pressure regulator
    • Fuel feed, return and EVAP canister purge line in the fuel tank retaining clip
    • Fuel tank
    • Negative battery cable
  5. Start the vehicle and check for leaks, repair if necessary.
2.2L and 3.0L Engines
  1. Before servicing the vehicle, refer to the precautions in the beginning of this section.
  2. Properly relieve the fuel system pressure.
  3. Remove or disconnect the following:
    • Negative battery cable
    • Fuel tank
    • Fuel lines from the fuel pump module cover
    • Fuel pump module retaining ring with a Sending Unit Wrench, J43827
    • Pull the retaining clip toward the float arm and lift up
    • Fuel pump straight up from the fuel tank
    • Fuel pump tank seal and discard the seal
    • Fuel feed line from the bottom of the fuel pump cover with Clamp Pliers J43914
    • Fuel pump electrical connector Fig. 1: Remove the fuel pump cover lockring-2.2L and 3.0L engines 9306zg57.gif
    To install:
  4. Install or connect the following:
    • Fuel pump feed line to the cover
    • Fuel pump electrical connector
    • Fuel pump to the new seal
    • Fuel pump cover lockring with tool J-43827
    • Fuel lines and wiring harness
    • Fuel tank
    • Negative battery cable
  5. Start the vehicle and check for leaks, repair if necessary.
prev.gif next.gif

Posted on Jan 29, 2011

  • 474 Answers

SOURCE: speakers replacement for 2001 saturn L200

try crutchfield.com

Posted on Nov 07, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Just replaced starter and 01 saturn L200 will not start


Search Results

    2001 L200 Cranks but won't start - SaturnFans.com Forums

    www.saturnfans.com > ... > Models > Saturn L-Series > L-Series Tech

    Nov 28, 2010 - 15 posts - ‎5 authors
    I have a 2001 Saturn L200 with 69K miles on the twin cam 16 valve 2.2 ... It will crank but will not start unless I put the gas pedal to the floor in ... Saturn L200 Cranks but won't start
    7 posts
    Mar 12, 2012
    2001 Saturn SC2 Cranks but does not start
    11 posts
    Dec 4, 2011
    2001 L200 won't start
    11 posts
    Dec 19, 2009
    Widow in need - L200 will not start - fuel pressure
    12 posts
    Nov 12, 2009
    More results from www.saturnfans.com

    2000 Saturn LS1, Starting Defect - YouTube

    ? 1:37
    www.youtube.com/watch?v=CBNU1IMqaRw

    Aug 9, 2009 - Uploaded by farmerinchico
    The anti theft system in the 2000 Saturn LS1, thinks you're trying to steal the car ... Once the security light is not flashing you canstart the car.


Oct 29, 2015 | Saturn Cars & Trucks

1 Answer

How do I replace my fuel pump on my 2001 saturn L200


find the fuel tank first then see if there is an access plate above it . if not the tank must be removed to replace the pump.

Oct 12, 2015 | Saturn Cars & Trucks

1 Answer

Can you get to the fuel pump on a saturn l200 '02 without dropping the tank


No there is not. Dropping the fuel tank is the only option you have on a saturn

Oct 23, 2012 | 2001 Saturn L-Series

2 Answers

Where is the thermostat located on my 2001 Saturn L200 sedan?


Follow your top radiator hose to a little housing on top of engine, under that metal housing you'll find your thermostat

Jan 04, 2011 | 2001 Saturn L-Series

2 Answers

Saturn l200 turned off while driving, won't start fuel pump is working. Any suggestions


Sound to me your crank sensor has failed.The only solution is to have it replaced.

Dec 24, 2010 | 2001 Saturn L-Series

1 Answer

WHERE IS THE FUEL PUMP LOCATED IN A 2003 SATURN L200


Hello. The fuel pump on this car is located within the fuel tank. Joe

please mark my answer as very helpful. thank you.

Apr 23, 2010 | 2003 Saturn L-Series

1 Answer

How to change 2002 saturn L200 fuel filter?


L200 just change fuel filter but still runs like there is air in it i can run it fine for about 10 mins then it just dies please help

Nov 17, 2009 | 2001 Saturn L-Series

Not finding what you are looking for?
2001 Saturn L-Series Logo

1,820 people viewed this question

Ask a Question

Usually answered in minutes!

Top Saturn Experts

yadayada
yadayada

Level 3 Expert

75066 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7754 Answers

Are you a Saturn Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...