Question about 2004 Chevrolet Silverado 1500 Crew Cab

1 Answer

Looking for fuel filter on 2004 chevy silverado ss 6.0, not on frame rail

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Chevrolet Master
  • 2,984 Answers

Here is the steps for the removal and replacement...getting you the picture and location next. 6.6L Engine

  1. Disconnect the negative battery cables.
  2. Drain the fuel from the fuel filter as follows:
    • Install a hose on the water drain on the water-in-fuel sensor.
    • Place the other end of the hose into an approved container.
    • Drain as much fuel as possible from the fuel filter housing.
    • Tighten the water drain on the water-in-fuel sensor.
  3. Remove or disconnect the following:
    • Water-in-fuel sensor harness connector
    • Fuel filter from the fuel filter/heater element housing
    • Water-in-fuel sensor from the fuel filter

looking for fuel filter on 2004 chevy silverado ss - 7f47ade.gif
Exploded view of the fuel filter (2)—6.6L engine

To install:
  1. Install or connect the following:
    • Water-in-fuel sensor in the fuel filter
    NOTE Check the fuel filter/heater element housing and the filter for a dislocated filter seal or foreign debris. Contamination on the filter/heater housing may cause leakage at the fuel filter. Coat the seal with clean engine oil.

    • Fuel filter on the fuel filter/heater element housing
    • Water-in-fuel harness connector
    • Negative battery cables
  2. Prime the fuel system:
    • Pump the primer located on top of the fuel filter 30 times or until stiff.
    • Try to start and run the engine. If the engine does not start, repeat the previous step.
    • Allow the engine to run for 5 minutes at idle.
    • Check for fuel leaks and clear all Diagnostic Trouble Codes (DTCs).

Posted on May 07, 2010

  • Greg Bernett
    Greg Bernett May 07, 2010




    Same for the 6.0L unless you have the filter that is part of the intank fuel pump module.

×

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

3 Answers

Is there a fuel filter on the frame of a 1981 chevy silverado


Yes, generally on the inside of the frame rail on the side of your fuel tank.

Sep 07, 2011 | Chevrolet 1500 Cars & Trucks

1 Answer

Where is the fuel filter located in a 2001 Chevy Silverado 2500 HD?


Hello and welcome. the fuel filter is located on the frame rail, just under the drivers door. it is mounted to the inside of frame rail

Oct 27, 2010 | 2001 Chevrolet Silverado 2500HD

1 Answer

Locatiuon of fuel filter on a 2004 silverado


I'm not sure on an 04', but my 01' Silverado has it mounted to the inner frame rail (under the truck) on the drivers side just behind the drivers door. The fuel line comes out of the tank, runs along the frame, goes into the filter, then continues on to the engine bay.

Jun 02, 2010 | 2004 Chevrolet Silverado

2 Answers

Where are fuel filters on 1991 chev silverado


One filter only and it is located on the drivers side, inside frame rail near the gas tank.
Regards,

Aug 03, 2009 | Chevrolet Silverado 1500 Cars & Trucks

2 Answers

2004 chevy silverado fuel filter


it is in the drivers side frame rail just behind the cab silver can fuel lines screw on both sides

Jul 04, 2009 | 2004 Chevrolet Silverado

2 Answers

Fuel filter


It should be located just ahead of the fuel tank, mounted on the frame rail.
Good luck.
Regards,

Mar 23, 2009 | 1991 Chevrolet K1500

2 Answers

WHERE IS THE FUEL FILTER LOCATED?


located on the inside frame rail just under the drivers side door

Mar 20, 2009 | 1996 Chevrolet K1500

1 Answer

Where is the fuel filter on a 2005 chevy silverado?


check along the rails starting at the fuel tank, some are mounted below driver area, others on frame rail at right rear

Nov 17, 2008 | 2005 Chevrolet Silverado 1500 2WD

1 Answer

Fuel filter location for a 2004 silverado p/u, 2 wheel drive, 4.8 L


if you still have one it will be on the frame rail right about the transmission crossmember on drivers side. this is around the year chevy started using the in tank filter which you dont replace

Aug 20, 2008 | 2004 Chevrolet Silverado 1500 Crew Cab

Not finding what you are looking for?
Cars & Trucks Logo

2,879 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

76070 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8266 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...